Faculty Profiles - NORINAGA Koyo

Papers - NORINAGA Koyo

Division display 121 - 140 of about 236 ／ All the affair displays >>

Production of High-strength Cokes from Non-/Slightly Caking Coals. Part I: Effects of Coal Pretreatment and Variables for Briquetting and Carbonization on Coke Properties Reviewed Open Access

Matoba Masahiro, Kudo Shinji, Mori Aska, Norinaga Koyo, Uchida Kenya, Dohi Yusuke, Uebo Kazuya, Hayashi Jun-ichiro

ISIJ INTERNATIONAL Vol. 59 ( 8 ) page： 1440 - 1448 2019

Language：English Publishing type：Research paper (scientific journal) Publisher：The Iron and Steel Institute of Japan

In continuation of the present authors’ studies on production of high strength coke from lignite by sequential binderless hot briquetting and carbonization, this study has been carried out aiming at proposing methods to produce high strength coke from non-/slightly caking coals of subbituminous to bituminous rank. This paper firstly demonstrates preparation of cokes with cold tensile strengths above 10 MPa from two single non-caking coals (particle size; < 106 µm) by applying briquetting at temperature and mechanical pressure of over 200°C and 100 MPa, respectively. Such strength of coke is obtained over a wide range of heating rate, 3–30°C/min, during carbonization with final temperature of 1000°C. Then, a simple pretreatment, fine pulverization of coal to particle sizes smaller than 10 or 5 µm, is examined. This pretreatment enables to prepare coke with tensile strength even over 25 MPa, by decreasing porosity of resulting coke and more extensively the size of macropores simultaneously. The coke strength changes with carbonization temperature having a particular feature; significant development of strength at 600–1000°C, i.e., after completion of tar evolution, in which macropores and non-porous (dense) part of coke shrink in volume, inducing bonding and coalescence of particles and thereby arising the strength.

DOI： 10.2355/isijinternational.ISIJINT-2018-819

Quantitative Analyses of Chemical Structural Change and Gas Generation Profile of Coal upon Heating toward Gaining New Insights for Coal Pyrolysis Chemistry Reviewed Open Access

Fukuoka Tetsuya, Takeda Norihiro, Zhang Lu, Machida Hiroshi, Zhang Wei, Watanabe Masahiko, Nishibata Yuko, Hayashi Jun-ichiro, Norinaga Koyo

ISIJ INTERNATIONAL Vol. 59 ( 8 ) page： 1376 - 1381 2019

Language：English Publishing type：Research paper (scientific journal) Publisher：The Iron and Steel Institute of Japan

Chemical structure of coal is evolutionary changed during pyrolysis that accompanies gas release. The chemical structural change and gas formation profiles play important roles in determining caking property and physical properties such as strength and size of the resultant coke. However, analyses of volatile components and structural analysis of solid char have been mostly performed individually, and it is difficult to combine both and to obtain quantitative understanding on the thermal decomposition of coal at mechanistic level. In this study, simultaneous analyses of solid chemical structures of the heat treated coals and gas formation profiles were conducted for two kinds of coals that were pyrolyzed at an identical condition. On-line gas analysis with a quadrupole mass spectrometer and spectroscopic methods (NMR and FT-IR) were employed for quantitative evaluation of gas formation characteristics and solid chemical structure, respectively. The information obtained were then integrated to acquire new insight for coal pyrolysis mechanism. Here an approach to quantify the transferable hydrogen that contributes to stabilize radicals formed in pyrolyzing coal was proposed. It includes the quantitative assessment of aromatic cluster growth, decomposition of hydroxyls, and releases of hydrogen and pyrolytic water into gas phase. The proposed approach suggested that a bituminous coal that exhibits plasticity during pyrolysis had 3.5 mol/kg-coal transferable hydrogen, whereas the amount of transferable hydrogen of the sub-bituminous coal, a non-caking coal, was 1.3 mol/kg-coal, during pyrolysis up to 500°C.

DOI： 10.2355/isijinternational.ISIJINT-2018-816

Production of High-strength Cokes from Non-and Slightly Caking Coals. Part II: Application of Sequence of Fine Pulverization of Coal, Briquetting and Carbonization to Single Coals and Binary Blends Reviewed Open Access

Uchida Kenya, Kudo Shinji, Mori Aska, Ashik U. P. M, Norinaga Koyo, Dohi Yusuke, Uebo Kazuya, Hayashi Jun-ichiro

ISIJ INTERNATIONAL Vol. 59 ( 8 ) page： 1449 - 1456 2019

Language：English Publishing type：Research paper (scientific journal) Publisher：The Iron and Steel Institute of Japan

Sequential coal briquetting and carbonization was applied to preparation of cokes from 9 non- or slightly caking coals with carbon contents (fC) of 67–85 wt%-daf. Coal pulverization to sizes of <106 µm and briquetting at 40°C enabled to prepare cokes with tensile strength (σ) over 10 MPa from 4 coals with fC of 82–85 or 67 wt%-daf. Then, by introducing fine pulverization to sizes of < 10 µm before the briquetting, 7 coals were converted successfully into cokes with σ = 11–25 MPa. Increasing the briquetting temperature to 240°C further increased σ to 19–35 MPa for all the 9 coals. It was thus demonstrated that the hot briquetting of finely pulverized coal was a method to prepare high strength coke regardless of the rank of parent coal. Cokes were also prepared from 14 binary coal blends. All the cokes prepared by applying the fine pulverization and hot briquetting had σ of 20–35 MPa, which agreed well with that calculated by weighted average of those from the component coals. On the other hand, positive and also negative synergistic effects of blending occurred when blends were briquetted at 40°C. Characteristics of bonding/coalescence among particles of different types of coals were responsible for such synergies.

DOI： 10.2355/isijinternational.ISIJINT-2018-847

An approach for quantifying transferable hydrogen in pyrolyzing coals Reviewed

Norinaga K

36th Annual International Pittsburgh Coal Conference: Clean Coal-Based Energy/Fuels and the Environment, PCC 2019 2019

Reducing energy required for CO<inf>2</inf> separation and recovery process by employing phase separation solvents Reviewed

Norinaga K

36th Annual International Pittsburgh Coal Conference: Clean Coal-Based Energy/Fuels and the Environment, PCC 2019 2019

An approach for quantifying transferable hydrogen in pyrolyzing coals Reviewed

Norinaga K

36th Annual International Pittsburgh Coal Conference: Clean Coal-Based Energy/Fuels and the Environment, PCC 2019 2019

Reducing energy required for CO<inf>2</inf> separation and recovery process by employing phase separation solvents Reviewed

Norinaga K

36th Annual International Pittsburgh Coal Conference: Clean Coal-Based Energy/Fuels and the Environment, PCC 2019 2019

Characteristics of gas evolution profiles during coal pyrolysis and its relation with the variation of functional groups Reviewed Open Access

Zhang, L, Qi, S, Takeda, N, Kudo, S, Hayashi, J, Norinaga, K

International Journal of Coal Science and Technology Vol. 5 ( 4 ) page： 452 - 463 2018.12

Effects of HZSM-5 on volatile products obtained from the fast pyrolysis of lignin and model compounds Reviewed

Yang Huamei, Norinaga Koyo, Li Ji, Zhu Wenyou, Wang Haijun

FUEL PROCESSING TECHNOLOGY Vol. 181 page： 207 - 214 2018.12

Transient three-dimensional simulation of densification process of carbon fibre preforms via chemical vapour infiltration of carbon matrix from methane

Tang Zhepeng, Li Aijun, Hatakeyama Tomo, Shuto Hiroki, Hayashi Jun-ichiro, Norinaga Koyo

CHEMICAL ENGINEERING SCIENCE Vol. 176 page： 107-115 2018.2

Theoretical Study on Elementary Reaction Steps in Thermal Decomposition Processes of Syringol-Type Monolignol Compounds

Furutani Yuki, Dohara Yuki, Kudo Shinji, Hayashi Jun-ichiro, Norinaga Koyo

JOURNAL OF PHYSICAL CHEMISTRY A Vol. 122 ( 3 ) page： 822-831 2018.1

Predicting molecular composition of primary product derived from fast pyrolysis of lignin with semi-detailed kinetic model

Furutani Yuki, Kudo Shinji, Hayashi Jun-ichiro, Norinaga Koyo

FUEL Vol. 212 page： 515-522 2018.1

Current situation and future scope of biomass gasification in Japan Reviewed

Furutani, Y, Norinaga, K, Kudo, S, Hayashi, J.-I, Watanabe, T

Evergreen Vol. 4 ( 4 ) page： 24-29 2017.12

Theoretical Study on the Kinetics of Thermal Decomposition of Guaiacol and Catechol

Furutani Yuki, Dohara Yuki, Kudo Shinji, Hayashi Jun-ichiro, Norinaga Koyo

JOURNAL OF PHYSICAL CHEMISTRY A Vol. 121 ( 44 ) page： 8495-8503 2017.11

An approach for on-line analysis of multi-component volatiles from coal pyrolysis with Li+ -attachment ionization mass spectrometry Reviewed

Zhang Lu, Qi Shi-Chao, Iwanaga Keita, Uemura Kazuhiro, Zhang Li-Xin, Kudo Shinji, Hayashi Jun-ichiro, Furuya Kenji, Norinaga Koyo

FUEL PROCESSING TECHNOLOGY Vol. 158 page： 141-145 2017.4

Theoretical Study on Hydrogenolytic Cleavage of Intermonomer Linkages in Lignin Reviewed

Qi Shi-Chao, Zhang Lu, Kudo Shinji, Norinaga Koyo, Hayashi Jun-ichiro

JOURNAL OF PHYSICAL CHEMISTRY A Vol. 121 ( 15 ) page： 2868-2877 2017.4

Theoretical Study on Reaction Pathways Leading to CO and CO2 in the Pyrolysis of Resorcinol Reviewed

Furutani Yuki, Kudo Shinji, Hayashi Jun-ichiro, Norinaga Koyo

JOURNAL OF PHYSICAL CHEMISTRY A Vol. 121 ( 3 ) page： 631-637 2017.1

Production of Levoglucosenone and Dihydrolevoglucosenone by Catalytic Reforming of Volatiles from Cellulose Pyrolysis Using Supported Ionic Liquid Phase Reviewed

Kudo Shinji, Goto Nozomi, Sperry Jonathan, Norinaga Koyo, Hayashi Jun-ichiro

ACS SUSTAINABLE CHEMISTRY & ENGINEERING Vol. 5 ( 1 ) page： 1132-1140 2017.1

Toward Low-Temperature Coal Gasiication: Experimental and Numerical Studies of Thermochemical Coal Conversion Considering the Interactions between Volatiles and Char Particles Reviewed Open Access

Li Cheng-Yi, Zhang Li-Xin, Kudo Shinji, Hayashi Jun-Ichiro, Norinaga Koyo

KONA POWDER AND PARTICLE JOURNAL ( 34 ) page： 70-79 2017

Nano-sized nickel catalyst for deep hydrogenation of lignin monomers and first-principles insight into the catalyst preparation Reviewed

Qi Shi-Chao, Zhang Lu, Einaga Hisahiro, Kudo Shinji, Norinaga Koyo, Hayashi Jun-ichiro

JOURNAL OF MATERIALS CHEMISTRY A Vol. 5 ( 8 ) page： 3948-3965 2017

　 PREV - NEXT 　

<NORINAGA Koyo>

Papers - NORINAGA Koyo