研究者詳細 - 成瀬　一郎

The role of post-pyrolysis carbon dioxide capture in hydrogen recovery from waste-derived pyrolysis gas

Wang, YX; Veksha, A; Ong, J; Ueki, Y; Yoshiie, R; Naruse, I; Lisak, G

FUEL 381 巻 2025年2月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Fuel

The study elucidated the role of post-pyrolysis CO2 removal using a CaO sorbent on upgrading pyrolysis gas into H2-rich gas. The pyrolysis gas was obtained from various waste-derived feedstocks (municipal sewage sludge, refused derived fuel (RDF), pine sawdust (biomass), and marine litter) by pyrolysis (600 °C), and underwent the treatment with CaO (600 °C) followed by the thermolytic decomposition at 1300 °C. The results show that CaO utilization does not change significantly H2 yield and higher heating value of gas on a feedstock mass basis but increases H2 purity from 49.6–83.3 to 63.7–94.4 vol% and H2/CO ratio from 1.1–5.7 to 1.9–19.8 of the product gas across all feedstocks. Normalized rate constants K for CO2 capture by CaO, determined by the grain model, varied between 0.0001 and 0.0006 min−1, revealing the feedstock-specific effectiveness of CaO. The higher CaO consumption rates were observed in case of RDF and biomass compared to sludge and marine litter. This could be attributed to the coking and faster carbonation of CaO caused by the composition of pyrolytic products. The obtained results emphasize the potential of integrating CaO sorbent into pyrolysis-based processes for the production of decarbonized H2-rich gas with higher purity. Moreover, the use of normalized kinetic parameters provides a straightforward method for the selection of feedstocks suitable for decarbonization of pyrolysis gas using CaO sorbent. The predominant factor affecting the carbonation kinetics of the CaO sorbent was found to be the CO2 flow rates in their respective pyrolysis gases.

DOI： 10.1016/j.fuel.2024.133293

Effect of temperature on reaction and degradation behaviors during CO2 and H2O gasification reactions of coke in same conversion ratio

Zheng Zhenjie, Ueki Yasuaki, Naruse Ichiro

ISIJ International advpub 巻 ( 0 ) 2025年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：The Iron and Steel Institute of Japan

The efficiency of blast furnaces is adversely affected by coke degradation via gasification. Considering the utilization of hydrogen-enriched blast furnaces, it is essential to investigate the reaction and degradation behaviors of coke at different temperatures. In this study, coke gasification experiments were conducted under CO2 and H2O atmospheres at different temperatures to prepare cokes with a conversion ratio of 0.2. The reaction rate of the H2O gasification reaction was higher than that of the CO2 gasification reaction at the same temperature. The activation energies for CO2 and H2O gasification were 150.2 and 126.0 kJ/mol, respectively. After gasification, the shrinkage ratio was low by H2O gasification at 1273 K and increased with increasing temperature, indicating that the surface reaction became the control factor that consumed the coke matrix with increasing temperature. On the other hand, the shrinkage ratio by CO2 gasification tended to be stable from 1273 to 1673 K. Furthermore, the increase in the porosity of coke by H2O gasification was lower than that by CO2 gasification at higher temperatures. In addition, the strength of the coke via H2O gasification was higher than that of the coke via CO2 gasification.

DOI： 10.2355/isijinternational.isijint-2024-344

O-05　バイオマス燃料の流動層燃焼炉における灰凝集評価

田内希, 宮下和大, 茂田潤一, 出町豊子, 植木保昭, 成瀬一郎

バイオマス科学会議発表論文集 20 巻 ( 0 ) 頁： 9 - 10 2024年12月

O-10　充填層ガス化炉における木質バイオマスのCO2ガス化特性

長谷川翔一, 出町豊子, 植木保昭, 成瀬一郎, 義家亮

バイオマス科学会議発表論文集 20 巻 ( 0 ) 頁： 19 - 20 2024年12月

O-06　多種バイオマス燃料の燃焼挙動の解明とそのモデル化

高橋広大, 出町豊子, 植木保昭, 成瀬一郎, 義家亮, 松成祥平

バイオマス科学会議発表論文集 20 巻 ( 0 ) 頁： 11 - 12 2024年12月

Degradation of solid oxide fuel cell anodes by the deposition of potassium compounds Open Access

Zhang, H; Yoshiie, R; Naruse, I; Ueki, Y

CARBON RESOURCES CONVERSION 7 巻 ( 4 ) 2024年12月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Carbon Resources Conversion

Alkali contents with low melting points in the ash of woody biomass vaporize during the biomass gasification process, damaging various downstream energy conversion devices, such as the solid oxide fuel cells (SOFCs). In this study, the degradation of SOFC anodes by the deposition of potassium compounds (KCl, K2CO3, and KOH) was investigated. An aqueous solution of potassium compounds was dripped onto the anode surface of the SOFC button cell at room temperature. After drying at 343 K, 6.964 × 10-6 mol KCl, 6.964 × 10-6 mol KOH, and 3.482 × 10-6 mol K2CO3 was deposited on the anode. Button cells with the deposition of K compounds were employed for power generation experiments at 1023 K with the supply of artificial syngas from biomass gasification. After the power generation experiments, the surface structures of the anodes were microscopically analyzed using the SEM and EDS. As a result, K compounds hardly affected the OCV of SOFC. With the addition of KCl, no apparent change in the anode structure was observed, and only a slight KCl deposit was detected. However, chloride tends to be chemisorbed on Ni, increasing the ohmic resistance as well as the adsorption/desorption resistance. However, KOH transformed to K2CO3 and then remained massively on the anode, which was clearly observed in the SEM images. K2CO3 significantly decreased the cell voltage under a current density of 100 mA·cm−2. Through impedance analyses, this voltage drop was mainly attributed to the ohmic resistance and gas diffusion resistance. However, there is no evidence that this deposit degrades Ni particles.

DOI： 10.1016/j.crcon.2024.100238

Open Access

Comparative life cycle assessment of organic industrial solid waste co-disposal in a MSW incineration plant

1-01　高温でのコークスのガス化反応過程における粉化挙動

鄭振傑, 植木保昭, 出町豊子, 成瀬一郎

石炭科学会議発表論文集 61 巻 ( 0 ) 頁： 2 - 3 2024年10月

2-12　廃棄物処理プラントにおける灰付着・高温腐食の低減技術

長沼宏, 澤田晃宏, 森岳人, 後藤妙子, 小坂祥枝, 成瀬一郎

石炭科学会議発表論文集 61 巻 ( 0 ) 頁： 52 - 53 2024年10月

1-11　バイオマス燃焼時の伝熱管へのCl付着挙動の解明

和田知歌子, 佐藤直樹, 渡邊和宏, 成瀬一郎

石炭科学会議発表論文集 61 巻 ( 0 ) 頁： 22 - 23 2024年10月

Liu, YH; Li, AJ; Guo, GZ; Zhang, JW; Ren, Y; Dong, L; Gong, LF; Hu, HY; Yao, H; Naruse, I

ENERGY 305 巻 2024年10月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Energy

Co-disposal experiments involving industrial solid waste (ISW) are conducted at a municipal solid waste (MSW) incineration plant in this study, investing the environmental impact of co-disposal with different ISW addition proportions using life cycle assessment (LCA). Results show that increasing ISW proportions improves economic indicators, reducing the payback period from 7.92 years (0 % ISW) to 6.58 years (40 % ISW). Environmental impact indicators initially decrease and then increase. The indicator with the greatest environmental impact is Eutrophication Potential (EP), the only major indicator with positive values in all scenarios when considering power output. Its normalization value reaches a minimum at 30 % ISW blending, at 7.85 × 10−12. Contribution analysis reveals that the direct emissions of N-containing gases are the primary cause, while the addition of urea, ammonia water, and quicklime in flue gas treatment, as well as the ash-slag landfill, also have significant effects. Technical optimization of stepwise co-disposal, denitrification system and ash-slag reduction will be the focus. Compared to the existing conventional situation, the co-disposal system exhibits considerable improvements in environmental benefits and carbon reduction potential. Notably, there is a significant reduction in non-CO2 greenhouse gas emissions. This study offers theoretical insights for multi-source waste disposal in MSW incineration plants.

DOI： 10.1016/j.energy.2024.132322

Processing plastic waste via pyrolysis-thermolysis into hydrogen and solid carbon additive to ethylene-vinyl acetate foam for cushioning applications

3-3-2　廃プラスチックおよび木質バイオマスによる酸化鉄の還元挙動

加田航平, 出町豊子, 植木保昭, 成瀬一郎, 義家亮

日本エネルギー学会大会講演要旨集 33 巻 ( 0 ) 頁： 58 - 59 2024年7月

5-2-1　産業廃棄物によるエネルギーリカバリ時の灰溶融挙動および灰付着制御

向本舜, 出町豊子, 植木保昭, 成瀬一郎, 義家亮

日本エネルギー学会大会講演要旨集 33 巻 ( 0 ) 頁： 148 - 149 2024年7月

Wang, YX; Chang, BP; Veksha, A; Kashcheev, A; Tok, ALY; Lipik, V; Yoshiie, R; Ueki, Y; Naruse, I; Lisak, G

JOURNAL OF HAZARDOUS MATERIALS 464 巻頁： 132996 2024年2月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Journal of Hazardous Materials

A strategy for enhancing value creation from pyrolysis gas and oil, derived from plastic waste, through the generation of two additional outputs of solid carbon and hydrogen was investigated. Three types of hard-to-recycle plastic waste (marine plastic litter, household mixed plastics and cosmetic products packaging) were thermally treated in two stages: (i) decomposition of feedstock into gas and oil via pyrolysis at 600 °C; and (ii) thermolytic conversion of the pyrolysis gas and a fraction of oil into hydrogen and solid carbon at 1300 °C separately. The thermolysis of both pyrolysis gas and oil fractions predominantly resulted in the production of solid carbon (39–70 wt% per plastic feedstock and carbon content of 91.3–98.6 wt%) and H2-rich gas (H2 yield of 5.9–10.8 wt% per plastic waste feedstock and H2 content of 71.4–97.2 vol% per gas volume). The incorporation of pyrolysis oil into the thermolysis process could enhance the outputs of solid carbon and hydrogen. Characterizations of solid carbon and hydrogen obtained from pyrolysis gas and oil fractions were further conducted. The observed similar properties of H2 and solid carbon from pyrolysis gas and oil supported the feasibility of introducing all the pyrolytic products together into the thermolysis process without condensation of oil. To enhance the value of these solid carbon derived from plastics for practical usage, we utilized the obtained solid carbon as a reinforcing agent for polymer composite foam development. The solid carbon reinforced composite foam displayed great abrasion resistance (wear loss: 240 mg), compression strength (0.347 MPa), and dynamic impact properties (energy returned: 124 J/m and energy absorbed: 57.3 J/m), emphasizing the viability of solid carbon as a nucleating agent and reinforcing filler in polymer foam for cushioning applications. Overall, the strategy of pyrolysis-thermolysis, which harnesses both pyrolysis gas and oil, unlocks additional value creation by producing two new outputs from plastic waste. Depending on the market prices for solid carbon and hydrogen, this can substantially change the economics of plastic waste management and create new revenue streams, incentivizing plastic waste collection and processing.

DOI： 10.1016/j.jhazmat.2023.132996

Ash deposition and corrosion mechanisms of tubes in Waste-to-Energy plants

PubMed

Naganuma, H; Mori, T; Watanabe, S; Sawada, A; Goto, T; Ueki, Y; Yoshiie, R; Naruse, I

MECHANICAL ENGINEERING JOURNAL 11 巻 ( 2 ) 頁： 23-00486 - 23-00486 2024年

Mechanism of arsenic migration and transformation during pulverized coal combustion

Huang, YD; Li, AJ; Hu, HY; Li, S; Zou, C; Zou, RJ; Wu, XJ; Naruse, I; Yao, H

PROCEEDINGS OF THE COMBUSTION INSTITUTE 40 巻 ( 1-4 ) 2024年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Proceedings of the Combustion Institute

The gaseous arsenic released from pulverized coal combustion not only poses environmental impacts but also causes the severe poisoning of selective catalytic reduction catalyst. The unclear understanding of the interactions between gaseous arsenic and minerals in coal hinders the arsenic emission control by promoting gaseous arsenic transformation into less troublesome particulate-bound arsenic. To clarify the mechanism of arsenic migration and transformation during pulverized coal combustion, field test, pilot-scale combustion trial, lab-scale adsorption experiment, and molecular-scale theoretical calculation were synergistically conducted in this study. The results demonstrated that the interactions between gaseous arsenic and mineral components included chemical reaction and oxidation process, which began at high temperatures (∼1350 °C) and mainly took place in medium-high temperature region (650∼1350 °C). The metakaolin, magnetite, hematite and anhydrite were found to be active components for the interactions. Among these, anhydrite was the main trapper for gaseous arsenic at high temperatures due to the high thermal stability of calcium arsenate. While metakaolin, magnetite and hematite owned high arsenic adsorption performance in medium-temperature region. In the process of flue-gas cooling, gaseous arsenic tended to be captured by anhydrite thereby forming calcium-bound arsenic at high temperatures, and subsequently reacted with metakaolin, magnetite and hematite by generating iron- or aluminum-bound arsenic as flue gas further cooled down. High flue-gas temperatures and ash components (especially magnetite and hematite) facilitated the arsenic oxidation to hypotoxic arsenate in fly ash. These findings provided the foundation for in-depth control of arsenic emission from coal combustion by promoting arsenic migration and transformation into fly ash.

DOI： 10.1016/j.proci.2024.105467

Influence mechanism of chlorine on arsenic release and transformation during municipal solid waste incineration

Li, S; Hu, HY; Zou, C; Dong, L; Huang, YD; Liu, H; Naruse, I; Yao, H

PROCEEDINGS OF THE COMBUSTION INSTITUTE 40 巻 ( 1-4 ) 2024年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Proceedings of the Combustion Institute

Arsenic release presents a critical environmental pollution issue during municipal solid waste (MSW) incineration. The increase of chlorine-containing waste for incineration processes has heightened interest in the volatilization of heavy metals induced by chlorine. However, the migration and transformation of arsenic, which has a strong affinity for oxygen at high temperatures, are less understood in the context of chlorine influence, leading to the absence of corresponding regulatory strategies. Therefore, this study first investigated the mass distribution of arsenic during co-incineration of MSW and chlorine-rich solid waste (plastics) in a grate incinerator. In addition, Ca3(AsO4)2 was selected as the predominant form of arsenate in the bottom ash to perform decomposition experiments under the influence of HCl, supported by thermodynamic calculations and density functional theory (DFT) calculations. The results demonstrated that chlorine enhances the migration of arsenic from the bottom ash to the fly ash during the co-incineration process. For the first time, it has been discovered that Ca3(AsO4)2 transforms into Ca5(AsO4)3Cl when exposed to HCl at high temperatures, releasing As2O3 (g) into the flue gas. Importantly, the presence of HCl significantly lowers the initial temperature for the release of As2O3 (g). This effect is attributed to the adsorption of chlorine from HCl onto the calcium atoms in Ca3(AsO4)2, which affects the binding energy of adjacent Ca-O-As structure, thereby facilitating arsenic release at lower energies. Furthermore, the initial transformation temperature of Ca3(AsO4)2 into Ca5(AsO4)3Cl is reduced from 1300 °C to 600 °C in a high-chlorine atmosphere, which was obtained by incorporating the thermal properties of Ca5(AsO4)3Cl. These insights are crucial for the understanding of arsenic transformation in high-chlorine environments and offer guidance for arsenic emissions control during the incineration of chlorine-rich solid waste.

DOI： 10.1016/j.proci.2024.105586

Electrochemical characteristics of solid oxide fuel cells supplied with CO-rich fuel gases Open Access

Zhang, H; Onogi, R; Yoshiie, R; Ueki, Y; Naruse, I

JOURNAL OF THERMAL SCIENCE AND TECHNOLOGY 19 巻 ( 1 ) 頁： 23-00525 - 23-00525 2024年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会・社団法人日本伝熱学会

CO2 biomass gasification is an attractive option for reducing CO2 emission which produces gas mixtures with higher CO concentrations than typical syngas compositions. However, carbon deposition and catalyst degradation may occur when CO-rich fuel gas is supplied to a Ni-Yttria-stabilized Zirconia solid oxide-based fuel cell. In this study, the electrochemical performance of an SOFC (anode: NiO-YSZ/NiO-GDC) with various CO-rich gas compositions was experimentally investigated. Four distinct gas mixtures were tested using electrochemical experiments at 1073 K. Impedance and steady-state polarization measurements were taken, and electric power generation was assessed at 100 mA·cm-2 under the 4 gas mixtures. Gas 1, a mixture of H2 (38%), CO (19%), CO2 (9.5%), and H2O (5%) was prepared as a reference gas to model a typical syngas mixture obtained from biomass gasifier. It generated the highest voltage without any degradation of the anode over 8 h. Gas 2, containing CO (19%), CO2 (9.5%), and H2O (5%), caused serious anode degradation compared with Gas 1. Gas 3, containing CO (19%) and H2O (5%) showed good performance with a relatively small polarization resistance and good stability in long-term electric power generation test. Gas 4, consisting of CO (20%) and CO2 (10%), exhibited the largest charge-transfer resistance at low overpotential and a significant diffusion resistance at high overpotential. Additionally, Gas 4 had the worst stability in the electric power generation test. Based on these results, we conclude that biomass gasification gas is a promising fuel for use in SOFCs. CO direct oxidation can provide electric power generation, although it appears to be unstable and shows high resistance at both low and high overpotentials. H2O addition can efficiently improve the stability of the CO direct oxidation process.

DOI： 10.1299/jtst.23-00525

産業廃棄物処理炉内における灰付着機構の解明とその制御

新居大生, 出町豊子, 植木保昭, 成瀬一郎, 義家亮

廃棄物資源循環学会研究発表会講演集 35 巻 ( 0 ) 頁： 395 2024年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

廃棄物由来の燃料を用いる焼却炉やボイラにおいて生じるスラッギングやファウリングといった伝熱管表面への灰付着は，伝熱阻害による発電効率の低下や焼却炉の運転阻害，伝熱管表面の化学腐食に起因するボイラ蒸気の高温および高圧化の阻害等の問題を発生させている．そこで本研究では，より高温および高圧な蒸気条件の実用化に向けて，産業廃棄物灰の溶融挙動を解明するとともに，灰付着を低減することのできる伝熱管表面への溶射材料の検討を行った．各材料を用いて接触角測定実験及びSEM/EDX分析を実施することで溶射材料の難灰付着性、耐食性について検討した．接触角測定実験から，いずれの条件でも開発材料Ni-2はSUS310Sよりも接触角が大きく，灰付着抑制・低減できると考察できる．また，SEM/EDX分析の結果から，Ni-2はSUS310Sに比べて溶融灰による化学腐食の進行を抑制できると考えられる．

DOI： 10.14912/jsmcwm.35.0_395

速度解析論による多様なバイオマス粒子の揮発分放出挙動の解明

松成祥平, 高橋広大, 植木保昭, 義家亮, 成瀬一郎

動力・エネルギー技術の最前線講演論文集 : シンポジウム 2024.28 巻 ( 0 ) 頁： A113 2024年

Pyrolysis and steam gasification properties of mangroves

Sakurai Y., Kobayashi J., Sakai Y., Naruse I.

Chemosphere 345 巻頁： 140388 2023年12月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Chemosphere

The rising atmospheric CO2 emissions from the burning of fossil fuels remains a global concern. Mangrove forests, which are important for global biodiversity, are known for their high carbon fixation capacity. However, the characteristics of the pyrolysis and gasification of mangroves remain unclear. Thus, this study focused on mangroves' basic pyrolysis and steam gasification properties for use as a gasification fuel. Three mangrove species: Rhizophora mucronata, Bruguiera cylindrica, and Avicennia marina, were used as experimental samples. In addition, three species of land wood were used for comparison: Eucalyptus, Japanese cedar, and Japanese cypress. In addition to the raw sample, a demineralized sample was used for each sample to account for the influence of the alkali and alkaline earth metals (AAEMs) on pyrolysis and steam gasification. Thermogravimetric analysis was performed to obtain thermogravimetric curves of mangroves and land wood. A laboratory-scale instrument for pyrolysis and gasification using a batch-type horizontal electric furnace was also used at 800 °C in an inert and steam atmosphere. The char yield of raw mangroves was high and independent of the Klason lignin content, suggesting that AAEMs influence char formation during the initial pyrolysis of the mangroves. The results of pyrolysis and gasification under steam atmosphere showed that the H2 production ratio (Steam/Inert) from mangroves was 2.52–5.33, compared to 1.76–2.35 for land woods, the addition of steam significantly enhanced the steam gasification of mangroves. Mangroves contain relatively large amounts of AAEMs, which indicates their potential as a gasification feedstock.

DOI： 10.1016/j.chemosphere.2023.140388

PubMed

O-11　木質バイオマスチャーのガス化挙動に及ぼすチャー粒径の影響

重吉晟之介, 義家亮, 植木保昭, 成瀬一郎, 中島充幸, 遠藤好弘, 梁川哲

バイオマス科学会議発表論文集 19 巻 ( 0 ) 頁： 25 - 26 2023年11月

O-16　木質バイオマスのCO2ガス化挙動におけるCO2濃度依存性

伊藤典紘, 義家亮, 植木保昭, 成瀬一郎

バイオマス科学会議発表論文集 19 巻 ( 0 ) 頁： 35 - 36 2023年11月

1-01　コークスのガス化反応過程における粉化挙動に及ぼす温度の影響

鄭振傑, 義家亮, 植木保昭, 成瀬一郎

石炭科学会議発表論文集 60 巻 ( 0 ) 頁： 2 - 3 2023年10月

2-17　廃棄物燃焼条件における高温腐食機構の速度論的考察

長沼宏, 後藤妙子, 澤田晃宏, 森岳人, 渡邉章, 成瀬一郎, 義家亮, 植木保昭

石炭科学会議発表論文集 60 巻 ( 0 ) 頁： 58 - 59 2023年10月

2-16　NaCl存在下における高温加速酸化機構の速度論的解析

澤田晃宏, 長沼宏, 後藤妙子, 森岳人, 渡邉章, 成瀬一郎, 義家亮, 植木保昭

石炭科学会議発表論文集 60 巻 ( 0 ) 頁： 56 - 57 2023年10月

1-04　燃焼場におけるバイオマス中シリカ粒子の生成挙動

末澤諒, 義家亮, 成瀬一郎, 植木保昭, 岡高憲

石炭科学会議発表論文集 60 巻 ( 0 ) 頁： 8 - 9 2023年10月

3-2-1　木質バイオマスのCO2 ガス化時のタール及びすすの生成挙動

岡田拓己, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 32 巻 ( 0 ) 頁： 40 - 41 2023年8月

5-2-3　一般廃棄物処理炉内における灰付着制御

粟田洋祐, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 32 巻 ( 0 ) 頁： 114 - 115 2023年8月

Defossilization and decarbonization of hydrogen production using plastic waste: Temperature and feedstock effects during thermolysis stage 査読有り

Andrei Veksha, Yuxin Wang, Jun Wei Foo, Ichiro Naruse Grzegorz Lisak

Journal of Hazardous Materials 452 巻 ( 131270 ) 2023年6月

Effect of temperature on behavior and mechanism of biochar gasification in the mixed CO2 and H2O atmosphere 査読有り

Yuxin Wang, Ryo Yoshiie, Yasuaki Ueki, Ichiro Naruse

Journal of the Energy Institute 108 巻 ( 101238 ) 2023年6月

Characteristics of biomass gasification by oxygen-enriched air in small-scale auto-thermal packed-bed gasifier for regional distribution 査読有り

Yuxin Wang, Ryo Yoshiie, Yasuaki Ueki, Ichiro Naruse

Fuel 342 巻 ( 127852 ) 2023年2月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：The Japan Institute of Energy

This study focuses on the operation of Ni-YSZ-based SOFC fueled with artificial fuel gas simulating syngas from biomass gasification. H2, CO, CO2 and H2O were mixed to make up artificial fuel gas with various compositions. Electrochemical behaviors were investigated under constant current conditions at 1073K during 8h using Galvano-stat. Cyclic voltammetry was also conducted to assess the stability of SOFC. Measurement results showed that CO2 and H2O have significant impacts on power generation performance. In particular, the performance degradation was significant in the absence of CO2.

金属リサイクル炉における非化石燃料によるエネルギーリカバリ

渡邊宏満, 植木保昭, 義家亮, 成瀬一郎, 大嶋祐介, 中川原聡

廃棄物資源循環学会研究発表会講演集 34 巻 ( 0 ) 頁： 295 2023年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

カーボンニュートラル実現に向けて、非鉄製錬業界ではリサイクル原料の処理拡大に向けての取り組みが加速しているが、金属リサイクル炉として重要な役割を担っているTop Submerged Lance(TSL)炉では、熱量当たりのCO2排出量が多い石炭を多量に消費している。今後は石炭の使用量の削減が急務であるため、本研究では、代替燃料の候補として、廃基板、廃プラ、廃タイヤ、バイオマス燃料等を検討し、発熱量が低いバイオマス燃料においては、半炭化によって使用燃料の大同精炭と同程度の発熱量が得られるかを確認した。6種類のバイオマス燃料の試料性状および半炭化後の発熱量を大同精炭と比較した結果、いずれの試料も大同精炭に比べ揮発分の割合が高く、固定炭素分の割合は低かったが、灰分の割合は試料によって差が見られた。また、いずれの試料も半炭化することにより発熱量を大幅に増加させることができた。

DOI： 10.14912/jsmcwm.34.0_295

Degradation Behaviors of Coke in CO2 and H2O Gasification Reactions at Low Temperatures Open Access

Zheng, ZJ; Ueki, Y; Yoshiie, R; Naruse, I

ISIJ INTERNATIONAL 63 巻 ( 11 ) 頁： 1810 - 1816 2023年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

This study aims to investigate the degradation behavior of coke during CO2 and H2O gasification reactions. Gasification experiments were conducted in CO2 and H2O atmospheres at 1 000°C using cokes with different coke reaction indices (CRIs) at 20% reaction ratio. After gasification, the shrinkage ratio in CO2 gasification was higher than that in H2O gasification. Moreover, the shrinkage ratio increased with increasing CRI, indicating that the ratio of the surface reaction became larger than that of the internal reaction with increasing CRI at same reaction ratio. The increase value in porosity by gasification reaction decreased with increasing CRI. Owing to the faster diffusion rate of water vapor at 1 000°C, water vapor diffuses into the inner part of coke faster, whereas CO2 gasification reacted from the outer to the inner slowly. Therefore, the increase in porosity of the inner part of coke by H2O gasification is larger than that by CO2 gasification. In addition, the degradation behavior in same coke by CO2 or H2O gasification did not have obviously difference at same reaction ratio in 1 000°C.

DOI： 10.2355/isijinternational.ISIJINT-2023-207

Reduction of Nitrogen Oxides by Calcium Ferrites in an Iron Ore Sintering Plant Open Access

Katayama, K; Ueki, Y; Yoshiie, R; Naruse, I; Nagata, J; Higuchi, K

ISIJ INTERNATIONAL 63 巻 ( 10 ) 頁： 1647 - 1657 2023年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

In iron ore sintering plants, the emissions of nitrogen oxides (NOx) must be reduced. Previous studies have shown that calcium ferrites could significantly reduce NOx emissions. However, the reaction paths between calcium ferrites and NOx have not been clarified yet. In this study, NOx reduction tests were conducted at 1 073 K–1 373 K with a CO/CO2 ratio of 0.03–0.10. Accordingly, the phase compositions of calcium ferrites before and after NOx reduction were investigated. CaO·FeO·Fe2O3 (CWF), which had a significant effect on NOx reduction, was formed with a CO/CO2 ratio of 0.03–0.10. Based on the phase compositions of the calcium ferrites before and after NOx reduction, we determined that the CWF reduced the amounts of NOx, and CaO·Fe2O3 (CF), 2CaO·Fe2O3 (C2F), and Fe3O4 are produced from the CWF. The NOx reduction behavior during coke combustion tests was also investigated. By coating a mixture of iron ore and quicklime around the coke, NOx formation was decreased during coke combustion. This phenomenon may have been caused by the formation of reduced calcium ferrites from a mixture of iron ore and quicklime on the coke surface.

DOI： 10.2355/isijinternational.ISIJINT-2023-210

産業廃棄物によるエネルギーリカバリ時の灰付着制御

向本舜, 植木保昭, 義家亮, 成瀬一郎, 永津伸治

廃棄物資源循環学会研究発表会講演集 34 巻 ( 0 ) 頁： 435 2023年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

廃棄物由来の燃料を用いる焼却炉やボイラにおいて生じる伝熱管表面への灰付着は，伝熱阻害による発電効率の低下や焼却炉の運転阻害，ボイラ蒸気の高温および高圧化の阻害等の問題を発生させている．本研究では，灰付着を低減できる伝熱管表面への溶射材料の検討を行った．熱力学平衡計算を用いて，各材料について灰付着現象に関わりのある溶融塩生成割合を比較・評価し，各材料を用いて接触角測定実験を実施することで計算および実験の両面から溶射材料の難灰付着性について検討した．開発材料Ni-2は他2つの材料と比べ、溶融塩の生成が大幅に抑制されていることが見て取れ，高温腐食に対して優れた材料であることが予想される．接触角については，Ni-2は他の基板より高い値を示し，灰付着抑制・低減できると考察できる．Ni-2は双方で比較材料より優れた結果を示し，高い耐食性・難灰付着性が期待できる溶射材料であることが分かった．

DOI： 10.14912/jsmcwm.34.0_435

1-03　コークスのガス化反応過程における灰粒子挙動

鄭振傑, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 59 巻 ( 0 ) 頁： 6 - 7 2022年10月

2-28　廃棄物系バイオマス処理プラントにおける灰付着と高温腐食機構

長沼宏, 後藤妙子, 澤田晃宏, 森岳人, 渡邉章, 成瀬一郎, 義家亮, 植木保昭

石炭科学会議発表論文集 59 巻 ( 0 ) 頁： 84 - 85 2022年10月

2-27　塩化物環境下における高温加速酸化機構の速度論的解析

澤田晃宏, 長沼宏, 後藤妙子, 森岳人, 渡邉章, 成瀬一郎, 義家亮, 植木保昭

石炭科学会議発表論文集 59 巻 ( 0 ) 頁： 82 - 83 2022年10月

Ash deposition mechanisms in Waste-to-Energy plants 査読有り

Hiroshi NAGANUMA, Takehito MORI, Sho WATANABE, Akihiro SAWADA, Taeko GOTO, Yasuaki UEKI, Ryo YOSHIIE, Ichiro NARUSE

Mechanical Engineering Journal 9 巻 ( 4 ) 頁： 21 2022年6月

充填層ガス化炉での酸素富化空気によるバイオマスガス化

義家亮, 白戸大輔, 小田将矢, 植木保昭, 成瀬一郎

日本燃焼学会誌 64 巻 ( 207 ) 頁： 74 - 79 2022年

廃棄物由来炭材による酸化鉄の還元特性

植木保昭, 義家亮, 成瀬一郎

廃棄物資源循環学会論文誌 33 巻 ( 0 ) 頁： 11 - 17 2022年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

製銑プロセスから排出される CO2 を削減する対応策の一つとして，現状未利用である有機系の廃棄物を炭材として有効利用する方法がある。本研究では，酸化鉄から金属鉄を製造するための還元材として，都市ごみ炭化物および木質バイオマス炭化物といった有機系の廃棄物を利用し，それらの炭材への適用性を実験的に検討した。主な結果として酸化鉄 (Fe2O3) と還元材 (都市ごみ炭化物，木質バイオマス炭化物，石炭およびグラファイト) の混合試料による還元実験を実施したところ，都市ごみ炭化物および木質バイオマス炭化物の各混合試料において金属鉄を生成した。これは都市ごみ炭化物および木質バイオマス炭化物中の固定炭素による還元反応性が石炭やグラファイトのそれよりも高いためである。このような実験成果から都市ごみ炭化物および木質バイオマス炭化物は還元鉄を製造するための還元材として十分に有効利用できる廃棄物であることがわかった。

DOI： 10.3985/jjsmcwm.33.11

廃棄物焼却におけるチャーNOx生成挙動に対するCO2及びH2Oの影響

庄倫太朗, 義家亮, 植木保昭, 成瀬一郎, 傳田知広

環境工学総合シンポジウム講演論文集 2022.32 巻 ( 0 ) 頁： 2205-08-04 2022年

1-04　微粉炭ボイラー用脱硝触媒上のSi化合物析出特性

柴田竜弥, 義家亮, 植木保昭, 成瀬一郎, 岡高憲, 吉田拓也, 矢田部翔多

石炭科学会議発表論文集 58 巻 ( 0 ) 頁： 8 - 9 2021年10月

微量炭化水素による固体酸化物燃料電池の劣化挙動 Open Access

張慧, 義家亮, 成瀬一郎, 植木保昭

日本エネルギー学会誌 100 巻 ( 9 ) 頁： 169 - 176 2021年9月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

本研究ではNi-YSZのアノード極を持つSOFCにタール模擬物質を混合した燃料ガスを供給し，SOFCの劣化挙動を調査した。バイオマスガス化研究において典型的なタール構成物質とされているトルエンを3.1％水蒸気含有水素に添加した。発電特性を考察するため，トルエン添加濃度を0 mg/Nm3から1900 mg/Nm3まで変化させて定電流モードにて約30 時間の発電実験を実施した。また，開放端でのインピーダンス測定を行うことによりSOFC内部抵抗を評価した。トルエン無添加実験ではSOFCは良好な状態及び安定した発電が持続したのに対して，200 mA/cm2の電流を印加すると380 mg/ Nm3の低濃度トルエン添加においても電圧の降下が見られた。さらにトルエン濃度が高くなると電圧降下も大きくなる傾向があった。トルエン濃度1900 mg/Nm3の場合には，電圧降下が深刻する一方でアノード極表面に炭素析出した様子も確認できた。ただし，アノード極構造に重篤なダメージがない限り，発電性能は部分的に回復した。

DOI： 10.3775/jie.100.169

Open Access

O-08　気泡流動層を用いたバイオマス燃焼挙動の解明

Degradation Behavior of Solid Oxide Fuel Cell (SOFC) with Trace Hydrocarbons

Zhang Hui, Yoshiie Ryo, Naruse Ichiro, Ueki Yasuaki

JOURNAL OF THE JAPAN INSTITUTE OF ENERGY 100 巻 ( 9 ) 頁： 169 - 176 2021年9月

3-1-3　バイオマスチャーのガス化挙動に及ぼす温度およびガス化剤の影響

義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 30 巻 ( 0 ) 頁： 38 - 39 2021年7月

5-1-1　流動層を用いたオキシ石炭燃焼における環境汚染物質生成挙動

山中建人, 義家亮, 成瀬一郎, 植木保昭

日本エネルギー学会大会講演要旨集 30 巻 ( 0 ) 頁： 122 - 123 2021年7月

加藤紘輝, 義家亮, 植木保昭, 成瀬一郎, 成川公史, 中村英樹

バイオマス科学会議発表論文集 16 巻 ( 0 ) 頁： 19 - 20 2021年1月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Woody biomass is attracting attention as an alternative energy to fossil fuels. The use of woody biomass is expected to expand in the future. In order to use biomass efficiently as a fuel, it is necessary to clarify its combustion characteristics. Therefore, in this study, in order to clarify the combustion characteristics of biomass, a biomass combustion experiment was conducted using a bubble fluidized bed. Palm Kernel Shell (PKS) was used as an experimental sample. The effect of temperature on the combustion behaviors of biomass was experimentally considered.

DOI： 10.20550/jiebiomassronbun.16.0_19

O-09　バイオマス燃焼ボイラ内における灰付着挙動

山下達也, 義家亮, 植木保昭, 成瀬一郎, 佐藤直樹

バイオマス科学会議発表論文集 16 巻 ( 0 ) 頁： 21 - 22 2021年1月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Operational problems in biomass-fired boilers include ash deposition to heat transfer tubes and corrosion of heat transfer tubes. Therefore, in this study, we focused on potassium compounds in biomass and conducted an ash deposition experiment using an electrically heated drop tube furnace. In the experiment, potassium-containing mineral (K-feldspar) was used as simulated ash. The amount of ash deposition in various atmospheres was measured. The cross section of samples was observed and analyzed by SEM-EDX, and the atmosphere dependence of the ash deposition characteristics was experimentally considered.

DOI： 10.20550/jiebiomassronbun.16.0_21

Tar generation and decomposition in downdraft packed bed reactor for woody biomass gasification

Yoshiie Ryo, Yamada Atsushi, Nunome Yoko, Ueki Yasuaki, Naruse Ichiro

JOURNAL OF THERMAL SCIENCE AND TECHNOLOGY 16 巻 ( 3 ) 頁： JTST0034 - JTST0034 2021年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会・社団法人日本伝熱学会

When the biomass gasifier is connected with a gas engine system directly, tar should be removed from the syngas to prevent the engine from breaking down. A downdraft packed bed gasifier has the advantage for low tar emission because the syngas passes through the char gasification zone downstream of the reactor, where tar compounds can be trapped and decomposed. Then, objective of this study is to confirm the tar decomposition behaviors inside the downdraft packed bed reactor. Woody biomass gasification experiments were carried out, using an auto-thermal downdraft packed bed gasifier. The reactor’s height and inner diameter were 1000mm and 100mm, respectively. Black pine pallets were continuously fed into the reactor from the top. The gasifying agent was air, which was introduced into the reactor at the air-fuel equivalent ratio of 0.49. The packed bed height was kept to be constant at 600mm. The reactor has eleven thermo-couples and eleven sampling ports at the wall along the flow direction. They were used for measurements of temperature profiles and gas compositions in the reactor. Micro-GC was used for the measurement of N2, O2, CO, CO2 and H2, and FIDGC was used for other hydrocarbons. In some ports among them, tar in syngas was also sampled via dichloromethane scrubbing in ice-bath, and analyzed for molecular weight distributions of tar compounds by TOF-MS. As a result, tar and larger hydrocarbons were confirmed to be generated in the upstream, and then decomposed downstream inside the downdraft reactor.

DOI： 10.1299/jtst.2021jtst0034

義家亮, 小林知嗣, 植木保昭, 成瀬一郎, 河合卓也, 遠藤正人

環境工学総合シンポジウム講演論文集 2021.31 巻 ( 0 ) 頁： 309 2021年

バイオマス燃料の燃焼挙動の解明と速度論解析

溝口創紀, 植木保昭, 義家亮, 成瀬一郎

廃棄物資源循環学会研究発表会講演集 32 巻 ( 0 ) 頁： 251 2021年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

今日，エネルギー需要は日々高まり，この傾向は今後も続くと予想される．しかし，地球上の化石資源は限られており足りないことは明白である．この状況下において，バイオマスを化石資源の代替として利用することが注目を集めている．また，バイオマス資源の中には建築廃材や農業残渣など廃棄物系の有機資源が多く存在し，それらの高効率有効利用が必須である．本研究では実際の燃焼炉の燃焼条件に近い等温条件においてバイオマスの燃焼速度を測定し，反応機構を解明することを目的としている．木質バイオマスである，黒松ペレットを実験試料として等温燃焼実験を行うことにより，温度および酸素濃度依存性を調べた．さらに，速度論解析を行い反応機構についても考察した．バイオマス燃料は，低温から大きな反応速度を持つ物質である揮発分の割合が高いため，昇温過程での燃焼についても考慮することで再現性の高いモデル化が可能であると明らかになった．

DOI： 10.14912/jsmcwm.32.0_251

脱硝触媒による排ガス中水銀の吸収特性

中山航汰, 義家亮, 成瀬一郎, 植木保昭

廃棄物資源循環学会研究発表会講演集 32 巻 ( 0 ) 頁： 409 2021年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

水銀排出量の抑制は現在世界的な問題であり，排出量の低減技術が早急に要求されている．発電施設や廃棄物焼却炉から排出される水銀の大部分は0価の金属水銀であり，これに対し高い捕捉性能を有する捕捉剤の開発は極めて重要である．本研究では，石炭燃焼設備や廃棄物焼却設備に組み込まれている脱硝触媒に対して，充填層型の実験装置を用いて0価水銀の捕捉実験を行い，得られた水銀含有脱硝触媒に対しXPS分析による捕捉水銀の化学種同定を試みた．結果としては，雰囲気中の酸素が脱硝触媒の水銀捕捉性能を向上させること，HClガスの存在下では水銀は主に酸化され放出されることが確認された．インプットする水銀量を大幅に増やした場合，ほとんどの水銀は捕捉されなかったが，酸素が捕捉性能を向上させる傾向は変化しなかった．XPS分析については，試料中の水銀量が微量であったため水銀のスペクトルを検出できず，化学種同定には至らなかった．

DOI： 10.14912/jsmcwm.32.0_409

Recent progress in tar removal by char and the applications: A comprehensive analysis

Zeng X., Ueki Y., Yoshiie R., Naruse I., Wang F., Han Z., Xu G.

Carbon Resources Conversion 3 巻頁： 1 - 18 2020年1月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：Carbon Resources Conversion

Tar catalytic removal by char is a promising technology for gasification process because of its porous structure, good catalytic activity, low cost, and easy to treatment after deactivation. To provide comprehensive information on the tar catalytic removal by char, this study focuses on the ongoing efforts and advances from fundamental researches to the industrial applications. The tar removal efficiency by char much depends on reaction conditions and char property, such as char origin, porous structure, the functional group on char surface, carbon structure, and AAEM components. The typical reaction kinetics, reaction mechanism, and the deactivation, will be introduced. Then, for the different gasification processes, the potential or typical applications of tar removal by char are discussed and compared. Finally, a comprehensive analysis and improvement in scaling up, commercializing tar removal technologies and integrating the gasification process, are also evaluated and analyzed in this review.

DOI： 10.1016/j.crcon.2019.12.001

下水汚泥チャーの燃焼挙動に及ぼす温度と酸素分圧の影響

小林知嗣, 植木保昭, 義家亮, 成瀬一郎, 河合卓也

廃棄物資源循環学会研究発表会講演集 31 巻 ( 0 ) 頁： 227 2020年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

日本国内では2019年において年間約3.8億トンもの産業廃棄物が排出されており、この中に含まれる可燃性廃棄物をエネルギー資源として有効利用することは、資源節約および環境保護の観点から重要である。本研究は産業廃棄物の中の下水汚泥に着目した。下水汚泥は国内で排出される産業廃棄物の20%を占めるが、バイオガスや汚泥燃料としての利用は17%に留まっていることから改善の余地が大きくある。そこで本研究では、下水汚泥チャーの基礎的な燃焼挙動を把握するために，熱量分析装置を用いて等温燃焼実験を行い，下水汚泥チャーの燃焼挙動に及ぼす燃焼温度および雰囲気ガス中酸素分圧の影響について検討した。実験試料は乾燥消化汚泥チャーおよび混合生汚泥チャー、比較試料としてRDFチャーの３種類を用いた。燃焼実験の結果、反応完結時間はRDFチャー、乾燥消化汚泥チャー、混合生汚泥チャーの順に速くなることを確認することができた。

DOI： 10.14912/jsmcwm.31.0_227

廃棄物チャー燃焼過程の NOx 生成に対するガス組成の影響

義家亮, 塚本和峻, 植木保昭, 成瀬一郎, 薄木太一, 傳田知広

環境工学総合シンポジウム講演論文集 2020.30 巻 ( 0 ) 頁： 304 2020年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

An incineration process is the most dominant method of the waste disposal in Japan. A stoker furnace incinerator is widely used for the waste incineration. In the stoker furnace incinerator, waste products can be sufficiently stirred and burned completely. Recently, low air ratio and high temperature incineration have been applied to the stoke furnace incinerator to improve efficiencies of power generations. However, they result in the increase in the amount of air pollutant NOx due to their higher flame temperatures. In addition, Exhaust Gas Recirculation (EGR) system, which is also applied into advanced incinerators, makes the NOx formation more complicated. In this research, NOx and other gaseous emissions from RDF char combustion were experimentally analyzed, investigating effects of exhaust gas compositions on NOx formations.

DOI： 10.1299/jsmeenv.2020.30.304

O-17　充填層ガス化炉における酸素富化空気によるバイオマスガス化

小田将矢, 白戸大輔, 義家亮, 成瀬一郎, 植木保昭

バイオマス科学会議発表論文集 15 巻 ( 0 ) 頁： 31 - 32 2019年12月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In recent years, biomass gasification processes are attracting attention to produce renewable gaseous fuels. However, it is difficult to use raw biomass because it has low heating values. So, we considered the introduction of oxygen enriched air. By supplying oxygen-enriched air, the heat loss due to water evaporation can be compensated. It is considered that partial combustion of the fuel can be promoted and sufficient heat can be obtained. In the experiments, we used a packed bed gasifier. This gasifier is small in size and suitable for small-scale distributed utilization of biomass. From the experimental results, it was found that even if moisture content of the wet biomass is high, the gasification of the biomass is possible by increasing the oxygen concentration of the gasifying agent. The syngas contained more H2 and CO compared with normal biomass gasification.

DOI： 10.20550/jiebiomassronbun.15.0_31

P-3-2 各種バイオマスのガス化挙動の解明

白戸大輔, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 28 巻 ( 0 ) 頁： 248 - 249 2019年7月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In recent years, due to problems of fossil fuel depletion and global warming, biomass has attracted attention as an alternative energy source. So we focused on biomass gasification. In this study, gasification experiments of three types of biomass are conducted as preliminary experiments of gasification by packed bed gasifier. Assuming that the gas produced when each sample burns completely is assumed as a gasifying agent, the mass loss and gas yield of the sample during gasification were measured.

DOI： 10.20550/jietaikaiyoushi.28.0_248

P-3-9 各種バイオマスの混合による燃焼挙動への影響

加藤紘輝, 植木保昭, 義家亮, 成瀬一郎, 成川公史, 森井一彦

日本エネルギー学会大会講演要旨集 28 巻 ( 0 ) 頁： 262 - 263 2019年7月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Biomass is attracting attention as an alternative energy of fossil fuel. It is expected that the use of woody biomass will increase in the future. In order to use biomass efficiently as fuel, it is necessary to clarify its combustion characteristics. So, in this study, in order to clarify the combustion characteristic of biomass, pyrolysis and combustion experiment during the temperature rising process of two kinds of biomass were conducted by using the thermogravimetric analyzer. Two kinds of woody biomass were used as experimental samples. The effects of mixing each biomass on the combustion behavior of woody biomass were discussed.

DOI： 10.20550/jietaikaiyoushi.28.0_262

Oxygen chemisorption of sub-bituminous coal at temperature

Yoshiie R., Ueki Y., Naruse I.

12th Asia-Pacific Conference on Combustion, ASPACC 2019 2019年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：12th Asia-Pacific Conference on Combustion, ASPACC 2019

The effective utilization of sub-bituminous coals has been extended as an energy source for power generation because of their low cost and long minable years. However, sub-bituminous coal may undergo spontaneous combustion owing to high reactivity with oxygen in low-temperature air compared with bituminous coal. Therefore, the objective of this study is to elucidate the low-temperature oxidation behaviors of sub-bituminous coal. In particular, transition from oxygen chemisorption to low-temperature oxidation of sub-bituminous coal has been experimentally examined in detail. Isothermal gravimetric analyses are conducted for several bituminous and sub-bituminous coal samples at temperatures varying between 356 K and 476 K in oxygen-enriched air. The chemical compositions of emission gas are continuously monitored under low-temperature oxidation conditions. The experimental results show that the mass of all tested coals, including those of bituminous and sub-bituminous coals, increases at temperatures below 426 K as a result of oxygen chemisorption. At 476 K, the mass of sub-bituminous coal increases slightly with low H2 and CO2 emissions at the beginning and subsequently decreases with high CO and CO2 emissions. This mass change indicates that the transition from oxygen chemisorption to low-temperature oxidation occurs during this period.

バイオマスガス化ガス希釈による火花点火機関の高効率運転

千野みつき, 久保直紀, 小林潤, 成瀬一郎

年次大会 2019 巻 ( 0 ) 頁： J07108P 2019年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Low temperature combustion due to dilution of intake air using inert gas is one of the effective methods for heat loss reduction of the engine. However, the combustion velocity almost decreases due to high dilution and that is the reason why a misfire occurs. To prevent the misfire due to reduction of the combustion velocity, application of a biomass gasified gas containing both hydrogen and inert gas to dilution was proposed. Dilution gas in which hydrogen was added to the inert gas was introduced into the engine. And it was suggested that the efficiency be improved.

DOI： 10.1299/jsmemecj.2019.j07108p

廃棄物チャー燃焼過程における NOx 生成挙動評価

塚本和峻, 義家亮, 成瀬一郎, 植木保昭, 傳田知広, 薄木太一

環境工学総合シンポジウム講演論文集 2019.29 巻 ( 0 ) 頁： J206 2019年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

An incineration process is the most dominant method of the waste disposal in Japan. A stoker furnace is widely used for the waste incineration. Recently, in the stoker furnace, low air ratio and high temperature incineration have been applied increasingly. However, they result in the increase in the amount of air pollutant NOx generated due to flame instability. Especially, it is difficult to control NOx production in char combustion. In this research, in order to evaluate the NOx generation mechanisms in char combustion of waste incineration process, RDF char burning experiments were carried out, investigating the combustion behaviors and exhaust gas compositions. The incineration experiments were conducted at different temperatures and gas conditions such as O2, CO2, steam, EGR(Exhaust gas recirculation). The char-NOx production behavior showed different behaviors depending on experiment conditions. In particular at the steam gas and EGR conditions, the char-NOx concentration was very high due to the steam gas shift reaction.

DOI： 10.1299/jsmeenv.2019.29.j206

地産地消エネルギー源である廃棄物の燃焼技術

成瀬一郎

日本エネルギー学会機関誌えねるみくす 97 巻 ( 6 ) 頁： 623 - 630 2018年11月

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

地域から発生する廃棄物は，すでに地域資源の一つになっていると考えてよかろう。すなわち，廃棄物燃焼プラントが立地している場所では，近隣への熱供給に留まらず，それなりの効率で発電して，所内利用のみならず売電も行えている。一方，廃棄物燃焼プラントは，定常的に安定処理できることが必須になっており，必然的に年間の定期点検の回数が複数回になったり，プラントの基数も複数基設置することが余儀なくされている。今後，各地域からのごみの総排出量は減少傾向になるであろうものの，発電効率を意味する微分的な効率や年間稼働日数を意味する積分的な効率のさらなる向上とともに，厳格化する環境規制への対応にも万全なプラントにしなければならなくなるであろう。

DOI： 10.20550/jieenermix.97.6_623

Synergistic effect of thermal cracking/partial oxidation/catalytic reforming by char on tar removal in a fluidized bed two-stage gasification process of industrial biomass

Ueki Yasuaki, Zeng Xi, Naruse Ichiro, Yoshiie Ryo, Han Zhennan, Xu Guangwen

廃棄物資源循環学会研究発表会講演集 29 巻 ( 0 ) 頁： 597 2018年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

Industrial biomass is the byproduct of light-industry, such as spirit lees, herb residue, bagasse and so on. It is not only a kind of biomass resource, but also a serious environmental pollution source. Gasification is promising and attractive because of cleanness, high efficiency and large treating capacity. However, due to high content of moisture, nitrogen, and organic residue, the existing direct gasification process faces challenges, such as low efficiency, large temperature fluctuation and high tar content in fuel gas. So, innovating gasification process and reactor structure become essential and necessary. In this study, a new fluidized bed two-stage (FBTS) gasification process, mainly consisting of a fluidized bed (FB) pyrolyzer and a transport fluidized bed (TFB) gasifier, has been proposed by the Institute of Process Engineering, Chinese Academy of Sciences. This process decouples direct gasification process into two sub-processes, namely feedstock pyrolysis and char gasification. Depending on thermal cracking, partial oxidation and catalytic reforming by char, the produced tar will be removed to a very low level. To research and develop the FBTS gasification process successfully, the synergistic effect of thermal cracking, partial oxidation and catalytic reforming by char was examined systematically on a laboratory FBTS reaction apparatus.

DOI： 10.14912/jsmcwm.29.0_597

廃棄物焼却炉におけるNOx濃度予測に向けた簡略燃焼反応機構の検討

傳田知広, 薄木太一, 植木保昭, 義家亮, 成瀬一郎

廃棄物資源循環学会研究発表会講演集 29 巻 ( 0 ) 頁： 301 2018年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

本研究では、ストーカ式廃棄物焼却炉における燃焼挙動の予測を目的に、簡略燃焼反応機構を適用した三次元燃焼シミュレーション手法を開発している．著者らは、これまで実用的な簡略燃焼反応機構を選定し、炉内温度分布およびCO濃度分布を概ね良好に計算できることを示した．本報では更にNOx濃度を予測するため、窒素分の化学種および素反応式を加えた新たな簡略燃焼反応機構を作成した．さらに、作成した簡略燃焼反応機構の計算精度を検討するため、汎用的な詳細燃焼反応機構であるGRI-Mech3.0をベンチマークとした層流拡散火炎の二次元解析を実施したので、ここに報告する．

DOI： 10.14912/jsmcwm.29.0_301

廃棄物焼却炉における NOx 予測に向けた簡略燃焼反応機構の検討

傳田知広, 薄木太一, 植木保昭, 義家亮, 成瀬一郎

環境工学総合シンポジウム講演論文集 2018.28 巻 ( 0 ) 頁： 205 2018年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

We have developed the technique of numerical simulation which uses the reduced reaction mechanism to predict the combustion behavior in a waste incinerator. In this paper, we newly made the reduced reaction mechanism “N916” (34 species, 76 reactions) for NOx concentration prediction by benchmarking GRI-Mech3.0 (50 species, 326 reactions) which is the typical combustion reaction mechanism. In order to examine the precision of N916, we calculated temperature and NOx concentration distribution in two-dimensional diffusion flame by using N916 and GRI-Mech3.0. The results showed that temperature and NOx concentration distributions were similar and the rate of divergence of NOx concentration value on center axis in the flame was almost 10%. There is a possibility that N916 is able to be used as the substitution for GRI-Mech3.0 in numerical simulation.

DOI： 10.1299/jsmeenv.2018.28.205

廃棄物燃焼過程におけるNOx生成特性の解明

塚本和峻, 義家亮, 成瀬一郎, 植木保昭, 傳田知広, 薄木太一

廃棄物資源循環学会研究発表会講演集 29 巻 ( 0 ) 頁： 309 2018年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

現在，日本のごみ処理方法のほとんどが焼却である．ごみ焼却には一般的にストーカ炉が用いられている．近年ストーカ炉では，低空気比高温燃焼が主流となっている．しかしそれにともなう問題として，火炎の不安定さに起因する大気汚染物質NOxや温室効果ガスN2Oの発生量の上昇が挙げられる．本研究では廃棄物の燃焼によるNOx生成機構の解明を目的に，廃棄物模擬燃料としてRDFを用いた燃焼実験を行いRDFの燃焼挙動及び燃焼ガスの分析を行った．RDF質量減少において，RDFは温度に比例し燃焼は速く進んだ．排ガスの測定結果から，NOx濃度は従来と異なり，温度上昇とともに減少した．RDF近傍で発生する局所的な還元雰囲気による影響と考えられる．また，素反応速度解析を用いたRDF燃焼シミュレーションを行い，比較・検討を行った．その結果，高温時HCN，NH3はほとんどがNO，N2O，N2に転換していることが分かった．

DOI： 10.14912/jsmcwm.29.0_309

脱硝触媒による水銀の酸化・吸収・脱離機構の解明

義家亮, 坂井田雅哉, 植木保昭, 成瀬一郎

東海支部総会講演会講演論文集 2018.67 巻 ( 0 ) 頁： 528 2018年

脱硝触媒による水銀の酸化・吸収・脱離機構

義家亮, 坂井田雅哉, 植木保昭, 成瀬一郎

環境工学総合シンポジウム講演論文集 2018.28 巻 ( 0 ) 頁： 307 2018年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

The Minamata Convention on Mercury was adopted in 2013, and regulations on mercury emissions are becoming stricter all over the world. Coal combustion is one of the major mercury emission sources. The majority of mercury emissions from coal combustion is in elemental mercury. This is because elemental mercury is water-insoluble, although oxidized mercury is water-soluble and easily captured by wet scrubbing systems. In this study, we expected the De-NOx catalyst to have a mercury oxidation/capture performance and conducted mercury oxidation/capture experiment using the De-NOx catalyst as a sorbent. In the result, when HCl existed in the atmosphere, the De-NOx catalyst oxidized all of vapor mercury. On the other hand, when HCl existed in the atmosphere, the De-NOx catalyst showed high mercury capture performance. Furthermore, De-NOx catalyst maintained high mercury capture performance at a high temperature (743 K)

DOI： 10.1299/jsmeenv.2018.28.307

P-1-2 微粉炭燃焼における灰粒子の凝集・脱離挙動のモデル化

“ふんりゅう”とのおつきあい

成瀬一郎

日本エネルギー学会機関誌えねるみくす 96 巻 ( 3 ) 頁： 234 2017年

松山達也, 植木保昭, 義家亮, 成瀬一郎

日本エネルギー学会大会講演要旨集 26 巻 ( 0 ) 頁： 256 - 257 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

One of major problems in pulverized coal combustion process is ash deposition which causes corrosion of the heat transfer tube, decrease in the heat exchange rate, blockage of the gas flow path, etc. The properties of ash particle such as particle number, particle diameter and elemental composition are very important factors to predict and control such ash deposition phenomena. Moreover, it is also important to distinguish whether an ash particle is Included Mineral (IM) or Excluded Mineral (EM). In this study, we made the models of single pulverized coal particle in combustion process using the CCSEM data of different carbon conversion and coal types gotten by DTF experiment in authors' previous study and evaluated properties of ash particles through the simulation.

DOI： 10.20550/jietaikaiyoushi.26.0_256

廃プラスチックの熱分解・ガス化挙動の評価

松永新平, 植木保昭, 義家亮, 成瀬一郎

廃棄物資源循環学会研究発表会講演集 28 巻 ( 0 ) 頁： 301 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

今日，廃プラスチックのエネルギー回収を実現する燃料化プロセスにおいて，タール生成低減と生成ガス増加を目的とした水蒸気添加等をともなうガス化の技術が期待されている．本研究では，3種のプラスチックについて，熱分解および水蒸気ガス化のバッチ炉実験を行い，そのガス・タール・すすの生成挙動について分析した．プラスチック試料としてABS(アクリロニトリルブタジエンスチレン), PC(ポリカーボネート), PE(ポリエチレン)の粉砕物を用いた．試料の粒径は1～2mmである．プラスチック試料の熱分解・ガス化は横型のバッチ炉を用いて行い，ガス採集実験とタール採集実験に分けて行った．炉内にN2ガスを流して不活性雰囲気にし，温度をそれぞれ973K，1073K，1173Kまで上げてから試料を約1.2g投入した．水蒸気ガス化時には炉内に水蒸気を過剰に添加した．投入された試料は熱分解・ガス化され，ガス，タール，すすを生成した．その後，採集したガス，タール，すすの成分分析，質量分析を行った．

DOI： 10.14912/jsmcwm.28.0_301

固形産業廃棄物の基礎燃焼挙動

浅井俊比古, 植木保昭, 義家亮, 成瀬一郎, 寺崎淳一, 上野直樹

日本エネルギー学会誌 96 巻 ( 6 ) 頁： 167 - 175 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

固体可燃性廃棄物の基礎的な燃焼挙動を把握するために，電気加熱式バッチ炉を用いて固体可燃性廃棄物の等温燃焼実験を行い，廃棄物の燃焼挙動に及ぼす炉壁温度および雰囲気ガス中酸素分圧の影響について検討した。また，すべての試料について実験結果をもとに各種反応モデルを用いて速度論解析を定量的に試みたところ，以下のような知見を得た。まず，炉壁温度および酸素分圧を上昇させると燃焼完結時間は短くなる。揮発分放出時間は瀝青炭，オイルコークスおよび複合材系廃プラスチック，95％反応時間はオイルコークス，複合材系廃プラスチックおよび瀝青炭の順に短くなる。オイルコークスは容積反応モデルとグレインモデルによる並列モデルで，複合材系廃プラスチックおよび瀝青炭は容積反応モデルと細孔モデルによる並列モデルを用いることにより実験結果の反応挙動をモデル化できる。固定炭素燃焼の活性化エネルギーはオイルコークスが最も大きく，複合材系廃プラスチックおよび瀝青炭はほぼ類似している。いずれの試料においても揮発分放出については酸素分圧の反応次数がほぼ0，固定炭素燃焼は酸素分圧の反応次数がほぼ1 となる。

DOI： 10.3775/jie.96.167

固体燃焼・ガス化過程における反応・環境汚染物質・灰成分の挙動解明に関する研究

成瀬一郎

日本エネルギー学会機関誌えねるみくす 96 巻 ( 3 ) 頁： 236 - 241 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Both resources and environmental controls have globally become obvious. Although alternative energy resources should be utilized more and more, it is also necessary to enhance efficient and ecological use of fossil fuels, which have undertaken basis of global energy society. As coal is one of the even-distributed and reasonable fossil fuels worldwide, huge amount of coal has been consumed in economically developed countries, such rising countries as China and India and economically developing countries. As a result, not only tightness of the coal supply, but also increase of load of the global environment have worried in the near future. From the present viewpoint and the future trend, coal must utilize efficiently and ecologically, and another solid fuels, including biomass and solid wastes, must also be recognized as one of the alternative ones. Additionally, development of both the global, ecological and efficient utilization technologies for those solid fuels and the core and component technologies to support them as well as the academic studies to elucidate the mechanisms in the phenomena occurring have been much more important in the near future to sustain the basis of global energy society.

DOI： 10.20550/jieenermix.96.3_236

P-7-10 脱硝触媒による水銀酸化・捕捉機構の解明

坂井田雅哉, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 26 巻 ( 0 ) 頁： 336 - 337 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

The Minamata Convention on Mercury was adopted in 2013, and regulations on mercury emissions are becoming stricter all over the world. Coal combustion is one of the major mercury emission sources. The majority of mercury emissions from coal combustion is an elemental mercury. This is because oxidized mercury is water-soluble, but on the other hand elemental mercury is water-insoluble. In this study, we expected the De-NOx catalyst to have a mercury oxidation/capture performance and conducted mercury oxidation/capture experiment using the De-NOx catalyst as a sorbent. In the result, when HCl is present in the atmosphere, the De-NOx catalyst oxidized mercury and when HCl is not present in the atmosphere, the De-NOx catalyst showed high mercury capture performance. Furthermore, De-NOx catalyst maintained high mercury capture performance at a high temperature (743 K)

DOI： 10.20550/jietaikaiyoushi.26.0_336

P-5-4 各種プラスチックの熱分解および水蒸気ガス化の挙動

松永新平, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 26 巻 ( 0 ) 頁： 308 - 309 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Among various recovery processes from waste plastics, the gasification with steam addition is one of the promising technologies to reduce unwanted tar and increase the conversion to syngas. In this study, batch furnace experiments of pyrolysis and steam gasification were conducted on three kinds of plastics. Gas, tar and soot and generation behaviors were examined in them. Granular samples of ABS (acrylonitrile butadiene styrene), PC (polycarbonate) and PE (polyethylene) were used as simulated waste plastics. All experiments were duplicated using different sampling trains for gas collections and tar collections. Nitrogen gas was fed into the furnace to achieve an inert atmosphere, and the temperature was raised to 973 K, 1073 K and 1173 K, respectively. 1.2 g of the sample was inserted into the furnace. In the steam gasification experiment, water vapor was entrained by the nitrogen.

DOI： 10.20550/jietaikaiyoushi.26.0_308

P-1-4 石炭ガス化プロセスにおける微量成分分配挙動

渥美翔太, 植木保昭, 義家亮, 成瀬一郎

日本エネルギー学会大会講演要旨集 26 巻 ( 0 ) 頁： 260 - 261 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In this study, we conducted coal gasification experiments by electrical drop tube furnace. In the experiments, we used Low Pressure Impactor (LPI) for the particle sampling in different particle size. Captured particles are dissolved in the acid on each particle size and the trace element concentrations of the solutions in the particles are analyzed by ICP-AES. For the consideration of the result of the experiments, we conducted thermodynamic equilibrium calculations. Calculation results support to investigate the chemical compounds of trace elements in the gasification atmosphere.

DOI： 10.20550/jietaikaiyoushi.26.0_260

P-1-3 流動層を用いたOxy-Fuel石炭燃焼におけるSOx放出挙動

浅井良介, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 26 巻 ( 0 ) 頁： 258 - 259 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Oxy-fuel coal combustion has drawn attention in the world as useful technique to achieve carbon dioxide capture and storage (CCS). It is a technology to enrich CO2 in exhaust gas by the flue gas recirculation with additional pure O2 to combustion atmosphere, which makes easy to capture CO2 downstream. Meanwhile, bubbling fluidized bed coal combustion has advantages of direct de-sulfurization in bed material and reduction of thermal NOX in low combustion temperature. However, there are few studies of oxy-coal fluidized bed combustion including emission behaviors of SOx and NOx. In particular, SO3 is of special concern, because the elevated SO2 and H2O concentrations in boiler by the flue gas recirculation may promote the formation of SO3. Objectives of this study are to understand SOx emission behaviors during the oxy-coal fluidized bed combustion under the actual flue gas recirculation condition, compared with those under the air and CO2-O2 combustion conditions.

DOI： 10.20550/jietaikaiyoushi.26.0_258

石炭燃焼排ガス中水銀の酸化・捕捉特性

坂井田雅哉, 植木保昭, 義家亮, 成瀬一郎

廃棄物資源循環学会研究発表会講演集 28 巻 ( 0 ) 頁： 323 2017年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

現在、石炭燃焼に伴い排出される水銀による大気汚染が問題となっている。石炭燃焼により煙突から排出される水銀のうち大部分を0価の元素水銀が占めている。これは、2価の酸化水銀は水溶性のため排ガス処理プロセスとしてあらかじめ備え付けてある湿式脱硫装置などにより回収されるのに対して、元素水銀は非水溶性のため回収が困難であるという理由からである。そこで、本研究では酸化・捕捉剤によりガス中の元素水銀を酸化・捕捉することで取り除く方法を提案している。酸化・捕捉剤としては水銀酸化性能を有していることを期待して、粉末状の脱硝触媒を用いた。脱硝触媒粉末および比較試料の水銀用活性炭を酸化・捕捉剤に用いて充填層型の元素水銀酸化・捕捉実験を行うことで、脱硝触媒粉末の水銀酸化・捕捉性能を評価し、脱硝触媒粉末による石炭燃焼排ガス中水銀の酸化・捕捉機構について検討した。

DOI： 10.14912/jsmcwm.28.0_323

Sintering characteristics of CaO-rich municipal solid waste incineration fly ash through the addition of Si/Al-rich ash residues

Hu Hong-Yun, Liu Huan, Zhang Qiang, Zhang Ping-An, Li Ai-Jun, Yao Hong, Naruse Ichiro

JOURNAL OF MATERIAL CYCLES AND WASTE MANAGEMENT 18 巻 ( 2 ) 頁： 340 - 347 2016年4月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Journal of Material Cycles and Waste Management

Thermal treatment is a promising technology for the fast disposal of hazardous municipal solid waste incineration (MSWI) fly ash in China. However, fly ash produced in grate incinerator (GFA) is rich in CaO and chlorides, which promote the formation of toxic hexavalent chromium [Cr(VI)] and ash agglomeration during the thermal process, inhibiting the thermal disposal of GFA. In this study, sintering characteristics of CaO-rich GFA were improved by adding Si/Al-rich MSWI ash residues. According to the results, ash agglomeration was well suppressed during thermal treatment of the mixed ash. Si/Al/Fe-compounds competed with un-oxidized Cr-compounds to react with CaO and suppressed Cr(VI) formation. Meanwhile, chlorides in GFA facilitated heavy metal volatilization from added ashes to the secondary fly ash, favoring the recovery of these metals. Ca-aluminosilicates was found as the main mineral phase in the thermally treated mixed ash, which has attractive potential for applications. The formation of the aluminosilicates made the heavy metals that remained in the treated mixed ash more stable than the thermally treated single ash.

DOI： 10.1007/s10163-014-0341-z

Products of High Temperature Gasification of ABS, PC and PE

NEDJALKOV Ivan, YOSHIIE Ryo, NUNOME Yoko, UEKI Yasuaki, NARUSE Ichiro

日本燃焼学会誌 58 巻 ( 186 ) 頁： 234 - 241 2016年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本燃焼学会

In this study a series of steam gasification experiments were performed on three thermoplastics - Acrylonitrile butadiene styrene (ABS), Polycarbonate (PC) and Polyethylene (PE), in a batch reactor. The effects of steam flow rate and reactor temperature (600～1000℃.) on the amount of tar, soot and char have been studied. The results were then compared with those of Pyrolysis, from our previous study. In addition time of flight mass spectrometry (TOF-MS) analysis was performed to identify the fingerprints of several different tars. It was found out that steam addition has varying effects on each of the studied polymers. It had a positive effect on soot reduction in the case of ABS and PE; tar reduction in PE; and some char reduction in PC. Temperature increase was found to decrease the relative amount of tar while increasing char production. According to the TOF-MS data, the average molecular weight of tar increases with temperature increase.

DOI： 10.20619/jcombsj.58.186_234

廃棄物焼却における初期熱分解の挙動

井寺涼, 義家亮, 成瀬一郎, 植木保昭

環境工学総合シンポジウム講演論文集 2016.26 巻 ( 0 ) 頁： 304 2016年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

In order to incinerate heterogeneous fuel such as waste products completely, high excess air ratio was traditionally applied to the burning zone in the incinerator. However, from viewpoints of heat recovery efficiency and flue gas treatment, low excess air ratio at high temperature has been becoming more popular for the waste incinerator year by year. Meanwhile, technologies for NOx emission control should be stricter since high temperature and flame instability under low excess air incineration conditions intend to extend NOx formation. In this study, initial pyrolysis behaviors of wastes in their incineration processes were analyzed to investigate their contributions to NOx formations.

DOI： 10.1299/jsmeenv.2016.26.304

充填層ガス化炉における木質バイオマスのガス化およびタール生成・分解挙動

植木保昭, 山田淳司, 布目陽子, 義家亮, 成瀬一郎

動力・エネルギー技術の最前線講演論文集 : シンポジウム 2016.21 巻 ( 0 ) 頁： E224 2016年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Recently, the issue of global environment becomes worse and it is caused by greenhouse gas such as carbon dioxide. Woody biomass attracts attention since it is a renewable energy source and carbon-neutral. One of the promising methods for energy conversion from woody biomass is gasification technology. The purpose of this study is to clarify the gasification behavior of woody biomass and formation/decomposition behavior of tar in the packed-bed gasifier. Gasification experiments (downdraft gasification) were carried out by using the packed-bed gasifier. In this study, pellets of black pine were fed intermittently and using air as the gasification agent. In the gasification experiments, the temperature distribution and the gas compositions in the gasifier were measured during gasification, and the amount of tar in the gasified gas was measured.

DOI： 10.1299/jsmepes.2016.21.e224

廃棄物発電設備の灰付着と腐食に関する現状と課題

長沼宏, 佐々木頼明, 成瀬一郎, 義家亮, 植木保昭, 二宮善彦, CHEN Juan, 野口学, 長洋光

日本エネルギー学会誌 95 巻 ( 11 ) 頁： 1089 - 1104 2016年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

廃棄物焼却プラントの熱交換器では管表面にごみ中の灰が付着し，伝熱阻害や運転障害，高温腐食などの問題を引き起こす可能性がある。それらの課題解決に向けて，著者らは灰付着・高温腐食低減を可能とする伝熱管の表面改質技術開発に関する基礎的な研究を実施した。本報では，廃棄物焼却炉内での灰付着・高温腐食の機構についてレビューするとともに，本研究で実施した分析・熱力学平衡計算結果によって腐食機構を考察した。また，最近の灰付着・腐食の測定・評価方法や従来提案されている課題解決策を整理し，解決策の有効性や実現性について評価した。

DOI： 10.3775/jie.95.1089

膜分離溶媒抽出を用いた廃潤滑油再生手法の開発

義家亮, 片岡直也, 植木保昭, 成瀬一郎

廃棄物資源循環学会論文誌 27 巻 ( 0 ) 頁： 37 - 43 2016年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

現在，潤滑油は多岐の産業分野にわたって使用されており，国内で年間80 万 kLの廃潤滑油が発生しているが，再生潤滑油としての再生割合は約 2 %に留まる。本研究で提案する膜分離を伴う溶媒抽出は，溶媒抽出の際に使用する有機溶媒のほぼ100 %がプロセス内で循環するため省資源であるうえ，残渣は廃油中の不純物成分のみであることから廃棄物を低減できる。本研究ではこの膜分離を伴う溶媒抽出による再生手法の実証を目指す基盤研究として，廃油・溶媒を連続供給する連続処理装置の構築，2 種類の廃潤滑油を用いた連続運転におけるプロセスの評価および再生基油の品質評価を行った。評価項目として硫黄，残留炭素，動粘度，炭素数分布，水分の測定を行った。15 時間に達する連続運転において再生基油抽出が定常状態に達し，また再生基油の品質も15 時間の抽出において顕著な低下はみられず，十分に再利用可能な品質であることが確認できた。

DOI： 10.3985/jjsmcwm.27.37

Use of Soft Plasma Ionization Source at Evacuated Air Atmospheres in Time-of-Flight Mass Spectrometry to Suppress Fragmentation of Volatile Organic Compounds

Nunome Yoko, Park Hyunkook, Kodama Kenji, Ueki Yasuaki, Yoshiie Ryo, Lee Sang C., Kitagawa Kuniyuki, Wagatsuma Kazuaki, Naruse Ichiro

SPECTROSCOPY LETTERS 48 巻 ( 6 ) 頁： 436 - 440 2015年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Spectroscopy Letters

This study describes a measuring system for mass spectrometry, consisting of a glow discharge ionization source for soft plasma ionization and a time-of-flight mass spectrometer, to detect toxic volatile organic compounds rapidly and easily. It is the most important to determine how the complicated fragmentation of such compounds can be suppressed to occur so as to recognize the mass spectra of the volatile organic compounds as their fingerprints. The novelty of this work is that the optimal discharge condition for the soft plasma ionization-time-of-flight mass spectrometer system could be selected, so that the parent mass peak of analyte molecules could be observed both with high sensitivity and with little or no fragmentation of them. Use of air gas at a pressure of 1000 Pa provided the most favorable result for these criteria, whereas, in a previous report, the soft plasma ionization source operating with argon at a pressure of 346 Pa had yielded additional mass peaks of the fragmented species. The reason for this would be explained by the fact that energetic electrons in the plasma, which principally cause the fragmentation of the volatile organic compounds, have lower number density at higher gas pressures, through de-accelerated collisions with the plasma gas.

DOI： 10.1080/00387010.2014.905962

模擬バイオマスと石炭との水蒸気共ガス化反応における相乗効果

義家亮, Joseph KIHEDU, 植木保昭, 成瀬一郎

日本燃焼学会誌 57 巻 ( 179 ) 頁： 21 - 26 2015年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本燃焼学会

Lignin and cellulose chemicals were used as artificial biomass components to make-up a simulated biomass. Alkali and alkaline earth metal (AAEM) as well as volatile matter contents in these chemicals were much different from each other. Co-gasification of coal with simulated biomass shows improved conversion characteristics in comparison to the average calculated from separate conversion of coal and simulated biomass. Two conversion synergetic peaks were observed whereby the first peak occurred around 400 °C while the second one occurred above 800 °C. Although co-gasification of coal with lignin that has high AAEM content also shows two synergy peaks, the one at higher temperature is dominant. Co-gasification of coal with cellulose shows only a single synergy peak around 400 °C indicating that synergy at low temperature is related with interaction of volatiles. Investigation of morphology changes during gasification of lignin and coal, suggests that their low reactivity is associated with their solid shape maintained even at high temperature.

DOI： 10.20619/jcombsj.57.179_21

P-05 木質バイオマスを用いた酸化鉄の還元特性解明(熱分解,Poster Session)

若田俊輔, 義家亮, 布目陽子, 植木保昭, 成瀬一郎

バイオマス科学会議発表論文集 9 巻 ( 0 ) 頁： 62 - 63 2014年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

The iron making process, especially pig iron making process discharges the huge amount of CO_2 because coke made from coal is used as a reductant. For this reason, steel industry discharges the largest amount of CO_2 and it occupies about 13% in Japanese emission. This paper focused the woody biomass substitute for coke in pig iron making process and studied reduction characteristics of iron oxide when heated iron oxide and woody biomass mixed sample in N_2 atmosphere. In addition, we aim to clarify the reduction characteristics of iron oxide by volatile matters in woody biomass.

DOI： 10.20550/jiebiomassronbun.9.0_62

Regeneration of Used Alkali Carbonates for Gaseous Sulfur Removal in a Gasification System

Raharjo Slamet, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

ENERGY & FUELS 27 巻 ( 5 ) 頁： 2762 - 2766 2013年5月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Energy and Fuels

Integrated coal gasification combined cycle is expected to play an important role as one of a number of highly efficient conversion technologies for carbonaceous resources. However, it is vital to remove as much H 2S and COS as possible. Our previous study suggested that the molten alkali carbonates of 43 mol of Na2CO3 + 57 mol of K 2CO3 can completely adsorb them at 1173 K to form alkali sulfides. Furthermore, to enhance the overall efficiency in the gasification system, the regeneration characteristics of the used alkali carbonates should be studied. Therefore, the current study works on that issue. The optimum regeneration condition for experiments was estimated by chemical equilibrium software, FactSage 6.2, prior to the regeneration experiments. Chemical equilibrium calculations suggested that a mixture of carbon dioxide and steam could regenerate the used alkali carbonates. The experiments were conducted in an electrically heated tube reactor using a mixture of CO2 and steam as the regeneration agent. As a result, the remaining sulfur in solid after regeneration experiments was around 5 mass % of the total sulfur content in the raw sample at an optimum temperature range of 650-773 K. It is expected that around 95% of alkali sulfides was converted back to alkali carbonates. © 2013 American Chemical Society.

DOI： 10.1021/ef400219q

Reduction mechanisms of ash deposition in coal and/or biomass combustion boilers

Naganuma Hiroshi, Ikeda Nobuya, Ito Tadashi, Matsuura Mikio, Nunome Yoko, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

FUEL 106 巻頁： 303 - 309 2013年4月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Fuel

Some ash particles in solid fuels adhere on heat exchanger tube surfaces inside coal and/or biomass combustion boilers. The authors have already proposed a surface treatment on tubes, using a thermal spraying technique, to reduce ash deposition. Understanding reduction mechanisms of the ash deposition is necessary to evaluate effects of the surface treatment technique on the reduction of ash deposition. The reduction mechanisms of the ash deposition were elucidated due to physical and chemical aspects, measuring adhesion forces between the ash particles and some alloy specimens of the tube at high temperature under the simulated boiler conditions. As a result, the adhesion force increased with time and depended on both the ash types and the alloy specimens. The thermal spraying of Ni-alloy, in particular, could reduce the adhesion force. Moreover interface reactions between the ash particles and the alloy specimen played an effective role in increasing the adhesion force, alkali metal compounds in the ash samples also related to an increase of the adhesion force. Fe, which was one of the main alloy elements, diffused into the ash deposition layer beyond the interface. This observation result suggested that the interface reactions of the ash particles with the alloy caused an increase of the adhesion force. © 2012 Elsevier Ltd. All rights reserved.

DOI： 10.1016/j.fuel.2012.11.017

Reaction behavior during heating biomass materials and iron oxide composites

Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro, Ohno Ko-ichiro, Maeda Takayuki, Nishioka Kold, Shimizu Masakata

FUEL 104 巻頁： 58 - 61 2013年2月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Fuel

Effective utilization of biomass materials as a reducing agent in the ironmaking process is one of the key technologies for environmental protection. In this work, in order to study the possibility of effective use of woody biomass as a reducing agent in the carbon composite method, we carried out experiments of the thermal decomposition of woody powder and reduction of mixture of woody powder and iron oxide. Conversion ratio into H2 from woody powder was almost the same between thermal decomposition of woody powder and reduction of the mixture sample. Conversion ratio into CO by reduction was larger than that by thermal decomposition. The final reduction degrees of mixture samples at the temperature from 1273 to 1573 K were 100%. © 2010 Elsevier Ltd. All rights reserved.

DOI： 10.1016/j.fuel.2010.09.019

The mechanism of gravity shedding of ash deposits in coal fired boiler

Sato N., Ueno S., Aramaki H., Nunome Y., Ueki Y., Yoshiie R., Naruse I.

30th Annual International Pittsburgh Coal Conference 2013, PCC 2013 5 巻頁： 4053 - 4060 2013年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：30th Annual International Pittsburgh Coal Conference 2013, PCC 2013

The purpose of this study is to examine the gravity shedding mechanisms of ash deposits experimentally. A horizontal furnace, which could simulate the temperature profile in practical boilers, was used in this experiment. The pulverized coal was burned in this furnace. The typical bituminous coal was selected as a sample coal. The gravity shedding of ash deposits was observed, inserting a water-cooling tube into the furnace during combustion. After the experiments, the cross-sectional surface of the water-cooling tube was analyzed using a scanning electronic microscopy. The ash deposits before shedding were found to be between 2 and 3 mm thick. The ash deposits near the metal surface consisted of ash particles, while the surface of the ash deposits partly consisted of lightly sintered ash particles. After shedding, the remaining ash layer was found to be 500 μm thick on the tube surface.

固体燃料の利用技術と環境

成瀬一郎

日本燃焼学会誌 55 巻 ( 172 ) 頁： 87 - 93 2013年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本燃焼学会

According to the supply trend of primary energy resources, the resources of such fossil fuels as oil, natural gas and coal have still been consumed steadily worldwide. Among those fossil fuels, the coal resource has the highest ratio of reserves to production. On the other hand, the global environmental issues have strongly been focused recently. In these points of view, the coal must be utilized efficiently and ecologically as well as carbon neutral resources like biomass and solid wastes should also be utilized more effectively. The coal, biomass and solid wastes are generally categorized as solid fuel. Even for the biomass, it is necessary to convert it high-efficiently and environment-friendly. However, those solid fuels have not only their own structural difficulties, but also compositional diversity. In order to solve those difficulties, the harmonization between the theory or model and the social needs is necessary, and the interdisciplinary cooperation will also be effective.

DOI： 10.20619/jcombsj.55.172_87

Volatilization characteristics of boron compounds during coal combustion

Noda Naoki, Ito Shigeo, Nunome Yoko, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

PROCEEDINGS OF THE COMBUSTION INSTITUTE 34 巻 ( 2 ) 頁： 2831 - 2838 2013年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Proceedings of the Combustion Institute

Boron behavior during coal combustion was studied experimentally and theoretically. Seven types of coal with different boron concentrations were pyrolyzed or burned, using an electrically heated drop tube furnace. In order to understand the effect of coal type on the boron component of ash, chemical equilibrium calculations were made to determine which boron compounds contributed to forming the boron compounds found in the ash particles. Additionally, XAFS analyses were also carried out to evaluate the results obtained by the chemical equilibrium calculations. Some boron compounds in coal were volatilized, and others remained in the molten coal ash after combustion. Both the chemical equilibrium calculations of the boron compounds under the combustion condition and the boron analysis of the ash particles by the XAFS suggested that the boron compound contained in the ash was mainly B 2O3. The boron compounds were concentrated in the molten slag during combustion. The enrichment of boron into the ash as particles was related to the amount of slag formed. The index, (Base/Acid ratio) × (Ash content), correlates well with the volatilization fraction of boron even in the actual power plants. © 2012 The Combustion Institute. Published by Elsevier Inc. All rights reserved.

DOI： 10.1016/j.proci.2012.07.018

微粉炭ボイラにおける灰付着低減技術の開発(Session 1)

成瀬一郎

日本エネルギー学会大会講演要旨集 22 巻 ( 0 ) 頁： vi - vii 2013年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In order to enhance net power generation efficiency obtained by pulverized coal fired boilers more, it is necessary to fundamentally develop reduction technologies of ash deposit during operation. The thermal coating technology on surfaces of heat exchanger tubes was applied to reduce the ash deposit during coal combustion in this study. Such several tests as the ash melting experiments at high temperature, the deposition experiments of ash particles and the measurements of deposition force after long-term keeping under the simulated boiler condition were carried out. Consequently, the Ni alloy specimen was selected as the best coating material to control the ash deposit. Finally, that coating material was also tested in practical boilers and showed the good performance on the reduction of ash deposit.

DOI： 10.20550/jietaikaiyoushi.22.0_vi

膜分離溶媒抽出による廃潤滑油の再生手法

片岡直也, 義家亮, 成瀬一郎, 植木保昭, 布目陽子

廃棄物資源循環学会研究発表会講演集 24 巻 ( 0 ) 頁： 355 2013年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

現在，潤滑油は多岐の産業分野にわたって使用されており，国内で年間84万kLの廃潤滑油が発生しているが，再生潤滑油としての再生割合は約6％に留まる．本研究で提案する膜分離を伴う溶媒抽出は，溶媒抽出の際に使用する有機溶媒のほぼ100％がプロセス内で循環するため省資源であり，残渣は廃油中の不純物成分のみであることから廃棄物を低減できる．本研究ではこの膜分離を伴う溶媒抽出による再生手法の実証を目指す基盤研究として，セミバッチ試験による膜分離溶媒抽出のモデル化および，廃油・溶媒を連続供給する連続処理装置の構築，長時間の運転におけるプロセスの評価を行った．モデル化に際して，Kedem-Katchalskyの式を用いることで，膜内への溶媒の侵入を考慮した膜分離溶媒抽出のモデルを構成することができた．また，連続抽出装置を構築し，連続運転条件において900minの長時間抽出を行うことができた．

DOI： 10.14912/jsmcwm.24.0_355

No.62 固体酸化物燃料電池における微量成分による劣化挙動解明(灰・微量元素(2))

資源・エネルギー

成瀬一郎, 神原信志, 汲田幹夫, 大友順一郎, 坂田興, 野田玲治, 義家亮

化学工学 = Chemical engineering 76 巻 ( 10 ) 頁： 620 - 627 2012年10月

笈田晃行, 義家亮, 成瀬一郎, 植木保昭, 布目陽子

石炭科学会議発表論文集 49 巻 ( 0 ) 頁： 120 - 121 2012年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In recent years, protections of environmental pollution and global warming are most important issues to discuss the world energy use. Efficient and clean use of fossil energy resources in the world has been increasing in importance. Coal is produced all over the world also, and it amount of reserves is larger than any other fossil fuels (oil, natural gas, etc.). Consequently, IGFC (Integrated gasification fuel cell combined cycle) has been attracting attention as one of efficient coal utilization. However, trace elements in coal are emitted to coal syn-gas in vapor phase, and affect fuel cell electrodes to deteriorate their performances. In this study, we assess the effect of trace element in syn-gas on SOFC power generation. We have tested a button cell in 900℃ for about 20 hours with simulated gas doped vapor As and Se.

DOI： 10.20550/jiesekitanronbun.49.0_120

Reduction of ash deposition in pulverized coal fired boilers

Naruse I., Yoshiie R., Ueki Y., Matsuura M., Naganuma H.

Cleaner Combustion and Sustainable World - Proceedings of the 7th International Symposium on Coal Combustion 頁： 517 - 522 2012年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Cleaner Combustion and Sustainable World - Proceedings of the 7th International Symposium on Coal Combustion

This study proposes reduction technology of ash deposition on the heat exchanger tube in pulverized coal fired (PCF) boilers. Thermal spraying technique is adopted to change the surface properties of tube to reduce the ash deposition. As a result, Ni alloy as a thermal spraying material played an effective role to reduce the deposition under both the ash deposition experiments and the actual coal combustion experiments. However, it is necessary to change ash types in order to evaluate that the thermal spraying technology is universally useful or not. If this technology will be applied to the commercialized PCF boilers, additionally, the effectiveness for the long-term will also be studied as well as the theoretical elucidation on the reduction of ash deposition must be discussed. In this study, therefore, four types of coal ash with different melting points were tested as samples for the ash deposition experiments. The long-term ash adhesion experiments were also carried out, using a precise tension tester at high temperature. As the theoretical approaches, the compositions of each ash particle depositing on the tube surface were analyzed by a computer-controlled scanning electron microscope (CCSEM) with electron dispersive spectroscopy (EDS) detector, thereby the interfacial reactions between the ash deposition layer and the heat exchanger tube were discussed. Those results obtained were also compared to the results obtained by the thermal equilibrium calculations. © Tsinghua University Press, Beijing and Springer-Verlag Berlin Heidelberg 2012.

Slagging behavior of upgraded brown coal and bituminous coal in 145MW practical coal combustion boiler

Akiyama K., Pak H., Takubo Y., Tada T., Ueki Y., Yoshiie R., Naruse I.

Cleaner Combustion and Sustainable World - Proceedings of the 7th International Symposium on Coal Combustion 頁： 77 - 82 2012年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Cleaner Combustion and Sustainable World - Proceedings of the 7th International Symposium on Coal Combustion

The purpose of this study is to quantitatively evaluate behaviors of ash deposition during combustion of Upgraded Brown Coal (UBC) and bituminous coal in a 145 MW practical coal combustion boiler. A blended coal consisting 20 wt% of the UBC and 80 wt% of the bituminous coal was burned for the combustion tests. Before the actual ash deposition tests, the molten slag fractions of ash calcualted by chemical equilibrium calculations under the combustion condition was adopted as one of the indices to estimate the tendency of ash deposition. The calculation results showed that the molten slag fraction for UBC ash reached approximately 90% at 1523 K. However, that for the blended coal ash became about 50%. These calculation results mean that blending the UBC with a bituminous coal played a role in decreasing the molten slag fraction. Next, the ash deposition tests were conducted, using a practical pulverized coal combustion boiler. A water-cooled stainless-steel tube was inserted in locations at 1523 K in the boiler to measure the amount of ash deposits. The results showed that the mass of deposited ash for the blended coal increased and shape of the deposited ash particles on the tube became large and sperical. This is because the molten slag fraction in ash for the blended coal at 1523 K increased and the surface of deposited ash became sticky. However, the mass of the deposited ash for the blended coal did not greatly increase and no slagging problems occurred for 8 days of boiler operation under the present blending conditions. Therefore, appropriate blending of the UBC with a bituminous coal enables the UBC to be used with a low ash melting point without any ash deposition problems in a practical boiler. © Tsinghua University Press, Beijing and Springer-Verlag Berlin Heidelberg 2012.

膜分離を伴う溶媒抽出による廃潤滑油の再生処理 Open Access

義家亮, 植木保明, 三輪高裕, 成瀬一郎

日本機械学会論文集Ｂ編 78 巻 ( 789 ) 頁： 1048 - 1052 2012年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

A process to recover base oil from waste lubricating oil is proposed in this study, which is based on solvent extraction with membrane. In this process, organic solvent is circulated in a closed loop, leading to a resource saving. Residue consists of only impurities in waste lubricating oil, such as suspended particles, aqueous droplets, soot and tar, leading to a waste reducing. This process includes a fractional distillation, too, but it is for separating out organic solvent from oils. Then, temperature for fractional distillation is lower than 100 °C, leading to an energy saving. Rubber film is utilized as membrane, whose polymer network structure works as filter to separate impurities from oil dissolved in solvent. In order to verify the feasibility of this process, effect of extraction period, solvent volume and extraction temperature on both yield and quality of the extracted oil was experimentally estimated. © 2012 The Japan Society of Mechanical Engineers.

DOI： 10.1299/kikaib.78.1048

国際協力機構・インドネシア高等教育開発計画プロジェクトに携わって

成瀬一郎

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 89 巻 ( 10 ) 頁： 947 2010年10月

Reaction characteristic of woody biomass with CO<inf>2</inf>and H <inf>2</inf>O

Naruse I., Ueki Y., Isayama T., Shinba T., Kihedu J., Yoshiie R.

Tetsu-To-Hagane/Journal of the Iron and Steel Institute of Japan 96 巻 ( 4 ) 頁： 151 - 154 2010年6月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Tetsu-To-Hagane/Journal of the Iron and Steel Institute of Japan

Objective in this study is to elucidate the fundamental gasification characteristics for carbonaceous resources. Effects of temperature and gaseous agents on the gasification characteristics of carbonaceous materials were experimentally and theoretically studied by the gasification of woody sawdust, using an electrically heated drop tube furnace. Results of the co-gasification of CO2 with H2O were compared by the gasification by a single gaseous agent such as CO2 or H2O. As a result, H2 and CO concentrations increased with an increase of temperature. CO concentration under the co-gasification condition produced more than that under the single gasification condition. The H2 formation showed the opposite tendency to the CO formation during the co-gasification. This synergy effect was also elucidated theoretically by the simulation of reaction kinetics. The simulated temperature indicating the maximum synergy effect on CO formation agreed well with that obtained by the experiments.

乾燥下水汚泥燃焼域における窒素酸化物の生成・消滅特性とその機構

成瀬一郎, 平林美和, 義家亮, 植木保昭

廃棄物資源循環学会論文誌 21 巻 ( 6 ) 頁： 193 - 201 2010年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

乾燥下水汚泥の燃焼域における窒素酸化物，特にN2Oの生成・消滅特性について，その機構を明らかにすることを目的とし，窒素雰囲気下で熱分解実験および空気比1.2での燃焼実験をそれぞれ行った。乾燥汚泥粒子が電気炉内に供給されると，瞬時に粒子温度が上昇し膨潤して，バルーン構造のチャー粒子になることを観察した。これは，汚泥中可燃分の約7割が揮発分であることと高温で溶融しやすい炭素質であることによるものと考察している。N2Oは火炎帯内で生成し，その後，NOが生成した。これはN2Oが生成した後に生じるCOの酸化反応で生成するHラジカルによる分解やNOへの酸化が生じたことによる。汚泥中N分のN2Oへの転換率は炉壁温度の上昇とともに低下したが，NOへの転換率は上昇した。また，汚泥はN2Oが生成しやすいHCNを熱分解時に高濃度で生成するので，これが石炭から生成するN2Oよりも高くなっている理由であると考察する。

DOI： 10.3985/jjsmcwm.21.193

木質バイオマスのＣＯ２およびＨ２Ｏとの反応特性

成瀬一郎, 植木保昭, 伊佐山勉, 榛葉貴紀, 義家亮

鉄と鋼 96 巻 ( 4 ) 頁： 150 - 155 2010年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

Synopsis : Objective in this study is to elucidate the fundamental gasification characteristics for carbonaceous resources. Effects of temperature and gaseous agents on the gasification characteristics of carbonaceous materials were experimentally and theoretically studied by the gasification of woody sawdust, using an electrically heated drop tube furnace. Results of the co-gasification of CO2 with H2O were compared by the gasification by a single gaseous agent such as CO2 or H2O. As a result, H2 and CO concentrations increased with an increase of temperature. CO concentration under the co-gasification condition produced more than that under the single gasification condition. The H2 formation showed the opposite tendency to the CO formation during the co-gasification. This synergy effect was also elucidated theoretically by the simulation of reaction kinetics. The simulated temperature indicating the maximum synergy effect on CO formation agreed well with that obtained by the experiments. © 2010, The Iron and Steel Institute of Japan. All rights reserved.

DOI： 10.2355/tetsutohagane.96.150

流動層燃焼炉における炉内脱硫特性の理論的考察

村上高広, 栗田典之, 成瀬一郎

高温学会誌 36 巻 ( 1 ) 頁： 41 - 46 2010年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人スマートプロセス学会（旧高温学会）

Sulfur oxides (SOx) are one of the main sources of acid rain. In a fluidized bed combustor, limestone is a directly supplied into the combustor, as a desulfurizer in order to decrease the emissions of SOx from fuel, such as sewage sludge and coal. In our previous studies, NaCl-doped limestone has a good performance on the desulfurization characteristics. In the present study, the effect of alkali metal compounds NaCl, KCl and LiCl-dopings on the formation of CaO crystal structure was simulated by the molecular dynamics method. The result indicates that KCl in KCl-doped CaO deforms more largely the CaO crystal structure than NaCl, because K atom tends to separate from Cl atom at high temperature due to larger ionic radius of K than that of Na. For LiCl-doped CaO, LiCl also deforms the CaO crystal structure, because Li, whose ionic radius is smaller than that of Na, can move freely inside the CaO crystal lattice at high temperature. Based on the results obtained by the molecular dynamics simulations, only the NaCl-doping into CaO has a positive effect on the CaO crystallization. Consequently, this NaCl-doping may enhance the desulfurization efficiency. From this viewpoint, the molecular dynamics simulation can well explain the relationship between the desulfurization efficiency of CaO and the effect of alkali metal compounds addition into CaO.

DOI： 10.7791/jhts.36.41

Using sorbents to control heavy metals and particulate matter emission during solid fuel combustion

Yao Hong, Naruse Ichiro

PARTICUOLOGY 7 巻 ( 6 ) 頁： 477 - 482 2009年12月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Particuology

Some of the heavy metals in coal and wastes vaporize during combustion, concentrate in fine particulates, and emit with the flue gas into the atmosphere, to produce adverse effect on environment and health. This study first investigates the fate of the heavy metal species, especially Pb, Cd and Cr, known as semi-volatile, in various flue gases, especially in the presence of HCl and SO2, by chemical equilibrium calculation, in which, Si and Ca were proposed as base sorbent materials to capture Pb, Cd and Cr. Then Si- and Ca-based compounds as well as waste materials used as sorbents were optimized to capture the heavy metals. Finally, the optimal sorbent was tested in actual burning of dried sewage sludge as solid fuel, to evaluate the effectiveness of the sorbent. Calculated results show that Cl increases the volatility of most heavy metals, while SO2 enhances formation of condensed phases. Among the sorbents tested, kaolin appears most efficient to capture Pb and Cd. For sludge combustion with kaolin addition, both Pb and Cd were shifted from sub-micron to macro-sized particles, and accompanied by considerable decrease of 0.1 μm particles. © 2009.

DOI： 10.1016/j.partic.2009.06.004

名古屋大学大学院工学研究科機械理工学専攻機械科学分野環境・エネルギー工学講座 : 高温エネルギー変換工学研究グループ(成瀬・義家研究室)

成瀬一郎

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 88 巻 ( 1 ) 頁： 81 - 84 2009年1月

界面反応を伴う石炭灰付着機構の解明

長沼宏, 池田信矢, 伊藤正, 佐藤文夫, 浦島一晃, 多久和毅志, 義家亮, 成瀬一郎

日本エネルギー学会誌 88 巻 ( 9 ) 頁： 816 - 822 2009年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In order to control ash deposition on heat exchanger tubes in coal or woody biomass combustion boilers, surface treatment of the tubes, using a thermal spraying technique, was proposed in this study. The ash deposition mechanisms were elucidated, based on physical and chemical aspects, under the condition of long exposure period First, adhesive force (Sb) between ash and alloy surface at high temperature was measured. As the physical aspect, Sb increased with an increase of the exposure time and could be predicted by an improved logistic function. Moreover, Sb depended on the temperature, so that an interface reaction controlled the increasing rate of adhesive force. As the chemical aspect, the interface between the ash deposition and alloy was observed and analyzed by a SEM-EDS and a FE-EPMA to consider the mechanisms of an increase of the adhesive force. The result showed that S and Na contained in the ash composition diffused into the alloy and that Fe mainly composing of the alloy specimens also diffused into the ash deposition. The diffusion coefficient of Fe into the ash deposition was also calculated by the results of a point elemental analysis. These results suggested that the interfacial reactions of the ash particles with the alloy affected the increase of adhesive force.

DOI： 10.3775/jie.88.816

充填層式木質バイオマスガス化炉の反応挙動解明(熱工学,内燃機関,動力など)

多久和毅志, 鳥越隆志, 義家亮, 成瀬一郎

日本機械学会論文集Ｂ編 75 巻 ( 752 ) 頁： 810 - 816 2009年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Gasification technology is recognized as one of the candidates to utilize the biomass effectively. From this viewpoint, this study focused fundamentals on woody biomass gasification, using a lab- scale packed bed. In this experiment, pellets of black pine are gasified, using air as the gasification agent. The gasification tests were carried out under both updraft and downdraft conditions. The temperature distribution inside the gasifier and the compositions of gasified gas were measured and analyzed during gasification by thermo couples inserted from a furnace wall and a micro gas chromatograph, respectively. The produced gasses before cooling were also sampled to analyze amount of tar generation in the gasses. As a result, the lower heating value of the produced gas under the downdraft condition was higher than that under the updraft condition. It was easier to operate under the downdraft condition than under the updraft. Under the updraft condition, bridging phenomenon happened. Amount of tar generation under the downdraft condition was lower than that under the updraft. This is because tar passes through a partial combustion zone or higher temperature zone in the downdraft gasifier.

DOI： 10.1299/kikaib.75.752_810

No.64 燃焼灰付着挙動の炭種依存性(灰・微量金属(1))

燃焼プロセスにおける微量成分を含む微粒子の生成挙動と炉内吸収技術

成瀬一郎

工業加熱 46 頁： 31 - 37 2009年

界面反応を伴う石炭灰付着機構の解明査読有り

義家亮, 成瀬一郎

日本エネルギー学会誌 88,2 頁： 816 - 822 2009年

長沼宏, 池田信矢, 成瀬一郎, 義家亮, 植木保昭, 松浦幹夫, 伊藤正, 佐竹英

石炭科学会議発表論文集 46 巻 ( 0 ) 頁： 126 - 127 2009年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In pulverized coal fired boilers, molten ash particles generated during combustion have possibility of adhesion on surface of heat exchanger tubes. This causes problems of heat transfer inhibition such as slagging and fouling as well as boiler trouble on operation. In order to solve this problem, surface treatment technology of the heat exchanger tubes is developed in this study. This paper describes dependence of the adhesive force between the deposition layer and the tube surface on the coal types.

DOI： 10.20550/jiesekitanronbun.46.0_126

膜分離を伴う溶媒抽出による廃潤滑油の再生処理

三輪高裕, 義家亮, 植木保昭, 成瀬一郎

廃棄物資源循環学会研究発表会講演集 20 巻 ( 0 ) 頁： 125 - 125 2009年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

現在，潤滑油は多岐にわたって使用されており，国内で年間105万kLの廃潤滑油が発生している[1]．発生した廃潤滑油の大部分は再生重油等燃料などへサーマルリサイクルされており，再生潤滑油としての再生割合は約７％に留まる．今日において白土処理，硫酸処理などの廃潤滑油再生処理方法が実用化されているが，簡便さ，経済性，環境性を考慮するといずれも多くの課題を抱えている．本研究で提案する膜分離を伴う溶媒抽出による廃潤滑油再生処理は，溶媒抽出の際に使用する有機溶媒のほぼ100％がプロセス内で循環するため省資源であり，残渣は廃油中の不純物成分のみであることから廃棄物を低減できる．さらに有機溶媒の沸点（100℃未満）程度の低温プロセスで運転可能である．このような利点を持ち合わせた提案プロセスの実現のため，本研究では廃潤滑油の膜分離を伴う溶媒抽出に関する不純物除去特性を実験的に検討した．

DOI： 10.14912/jsmcwm.20.0.125.0

No.73 石炭燃焼に伴うホウ素の揮発特性(灰・微量金属(3))

野田直希, 松田裕光, 伊藤茂男, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 46 巻 ( 0 ) 頁： 144 - 145 2009年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Boron contained in coal are partly released to the flue gas during combustion. Boron are captured in flue gas cleaning systems and the emissions of these elements are generally low. However, it is important to understand the behavior of boron to improve the reliability of the gas cleaning systems. Though a lot of researches examined the behavior of boron, the behavior of these elements in coal combustion has not been clarified in detail yet. In this research, the release behavior of boron from coal was investigated using a drop tube furnace (DTF). As a result, it is thought that a part of the boron would be absorbed in molten slag during combustion.

DOI： 10.20550/jiesekitanronbun.46.0_144

環境化学工学

竹下健二, 江頭靖幸, 下ヶ橋雅樹, 成瀬一郎

化学工学 = CHEMICAL ENGINEERING OF JAPAN 72 巻 ( 10 ) 頁： 570 - 574 2008年10月

灰付着防止用溶射ワイヤの開発 (第1報)

伊藤正, 斉藤貞一郎, 長沼宏, 池田信矢, 成瀬一郎, 五十嵐義昭

溶接学会全国大会講演概要 83 巻頁： 206 - 207 2008年8月

灰付着防止用溶射ワイヤの開発（第１報）

伊藤正, 斉藤貞一郎, 長沼宏, 池田信矢, 成瀬一郎, 五十嵐義昭

溶接学会全国大会講演概要 2008f 巻 ( 0 ) 頁： 311 - 311 2008年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人溶接学会

灰付着メカニズムの研究に基づいた成分系の溶射用メタルタイプフラックス入りワイヤについて、溶射皮膜の性質及び実機ボイラへの適用結果の報告。

DOI： 10.14920/jwstaikai.2008f.0.311.0

Role of Methanol in Supercritical Water Oxidation of Ammonia

大気環境

成瀬一郎

化学工学 = CHEMICAL ENGINEERING OF JAPAN 71 巻 ( 10 ) 頁： 702 - 703 2007年10月

Taro Oe, Hiroshi Suzugaki, Ichiro Naruse, Armando T. Quitain, Hiroyuki Daimon, Koichi Fujie

Industrial & Engineering Chemistry Research 46 巻 ( 11 ) 頁： 3566 - 3573 2007年4月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：American Chemical Society (ACS)

The role of methanol (MeOH) in the supercritical water oxidation (SCWO) of ammonia (NHs) was investigated near the typical operating conditions of a commercial plant at 560-620°C and 25 MPa using a tubular reactor. It was found that the presence of MeOH strongly affected the reaction behavior of nitrogen. With the addition of MeOH, at concentrations more than twice the initial concentrations of NH3 (1.4-5.7 mmol/mol of the feed mixture), the conversion of NH3 to N2O increased by about four times to 0.5-0.6 compared to that with no MeOH addition. The production of NO3- from NH3 increased in the liquid effluent with a conversion of up to 0.2. The productions of NO2-, NO, and NO2 from NH3 had similar behavior under the presence of MeOH at the tested conditions, and significant effects were observed at MeOH concentrations more than 2-6 times of the initial concentrations of NH3. The experimental results made it clear that NO and NO 2 were produced under the SCWO conditions. Methods for the reduction of N2O and NO3- were also investigated. Results showed that SCWO is not suitable for the decomposition of N2O. Other post-treatment methods such as catalytic decomposition should be applied to reduce N2O in the gas effluent. NO3- reduction methods (e.g., two-step reaction) proposed in this study should also be considered to prevent corrosion of the reactor material. © 2007 American Chemical Society.

DOI： 10.1021/ie070168u

P224 バイオマス充填層ガス化炉による基礎ガス化実験(ポスター発表)

鳥越隆志, 成瀬一郎

バイオマス科学会議発表論文集 2 巻 ( 0 ) 頁： 88 - 89 2007年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

The biomass gasification has recently been recognized as one of the candidate technologies to utilize the biomass effectively. In this study, pellets of black pine are gasified in a packed-bed gasifier, using air as gasification agent. In the gasification tests, the temperature distribution in the gasifier and the compositions in the gasified gas are measured and analyzed during gasification by thermo-couples and a micro gas chromatograph, respectively. Fundamental gasification characteristics in the packed-bed were discussed by those results obtained.

DOI： 10.20550/jiebiomassronbun.2.0_88

O211 電気加熱式ドロップチューブ反応炉によるCO_2および水蒸気を用いた木質バイオマスの基礎ガス化特性(セッション4:技術～基礎～,口頭発表)

榛葉貴紀, 成瀬一郎

バイオマス科学会議発表論文集 2 巻 ( 0 ) 頁： 36 - 37 2007年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Fundamental gasification characteristics in CO_2 and H_2O atmospheres at high temperature are experimentally studied, using an electric heated drop tube furnace. The gasification experiments are performed, changing temperature at the furnace wall, gasification agents and residence time. Hinoki sawdust is selected as a fuel. In the experiments, the gas composition and the elemental compositions in the residual reaction particles are analyzed. The result shows that co-existence of CO_2 with H_2O can enhance the gasification performance, compared with the individual gasification characteristics.

DOI： 10.20550/jiebiomassronbun.2.0_36

Twenty-first annual international pittsburgh coal conference

燃焼プロセスにおける微量金属成分の挙動と制御

成瀬一郎

Ｊｏｕｒｎａｌ　ｏｆ　ｔｈｅ　Ｓｏｃｉｅｔｙ　ｏｆ　Ｉｎｏｒｇａｎｉｃ　Ｍａｔｅｒｉａｌｓ，　Ｊａｐａｎ 14 巻 ( 328 ) 頁： 177 - 183 2007年

大気環境

成瀬一郎

化学工学 = CHEMICAL ENGINEERING OF JAPAN 70 巻 ( 10 ) 頁： 575 - 576 2006年10月

Suzuki T., Naruse I.

Fuel 85 巻 ( 2 ) 2006年1月

P227 電気加熱式ドロップチューブ反応炉による木質バイオマスの基礎ガス化特性

榛葉貴紀, 成瀬一郎

バイオマス科学会議発表論文集 1 巻 ( 0 ) 頁： 110 - 111 2006年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Gasification and pyrolysis characteristics of woody biomass were studied, using an electrically heated drop tube furnace, at 1173K and in CO_2 and N_2 atmospheres, respectively. Hinoki sawdust was selected as one of samples of woody biomass. Under this experimental condition, the gasification conversion and cold gas efficiency attained about 18% and 39%, respectively. The main components of the gaseous species were CO, H_2 and CH_4. The concentrations of those gaseous species in gasification were higher than that in pyrolysis. The main composition of the residue for gasification was fixed carbon. These results suggested that volatile matter in the biomass is easily gasified. The fixed carbon in the biomass was hard to be gasified.

DOI： 10.20550/jiebiomassronbun.1.0_110

脱硫プロセスにおける石灰石焼成のアルカリ金属化合物の効果 : 分子動力学シミュレーション

村上高広, 栗田典之, 成瀬一郎

Journal of the Ceramic Society of Japan (日本セラミックス協会学術論文誌) 114 巻 ( 1332 ) 頁： 676 - 680 2006年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人日本セラミックス協会

In this study, the change in the desulfurization characteristics of limestone induced by adding some alkali metal compounds and chlorides to limestone was investigated by thermobalance experiments. In addition, molecular dynamics (MD) simulations were performed to elucidate the effect of alkali-metal chloride additions on the CaO calcination for the desulfurization process. The experimental results obtained show that the addition of NaCl into the limestone is the most effective in improving the desulfurization efficiency. The X-ray diffraction analyses of the calcined seashell, limestone and NaCl-doped limestone found that the calcined seashell, as well as the calcined NaCl-doped limestone, have a similar structure as the CaO crystal. These two materials also show a high desulfurization efficiency. The MD simulations show that NaCl doping into the CaO contributes to the crystallization of CaO, while KCl and LiCl dopings have a small contribution. Therefore, the NaCl doping has a predominant effect on the CaO crystallization leading to a high desulfurization efficiency.

DOI： 10.2109/jcersj.114.676

P223 低品位炭とバイオマスの混焼場におけるNOおよびN_2O挙動

ガニアスリ, 成瀬一郎

バイオマス科学会議発表論文集 1 巻 ( 0 ) 頁： 102 - 103 2006年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In considering effective utilization of low-grade coals with high fixed carbon content, it is necessary to enhance ignition and burnout characteristics by means of adding the supplemental fuels. Co-combustion technologies for low-grade coals with biomass are generally recognized as one of the candidate technologies to enhance these characteristics. Although the biomass addition will affect NO_x emission, the precise NO and N_2O behaviors during co-combustion have not always been elucidated yet. Therefore, this report studies fundamental NO and N_2O formation/decomposition behaviors and their mechanisms experimentally and theoretically. In the simulation, the homogeneous and heterogeneous reaction schemes are considered to elucidate the NO and N_2O formation/decomposition mechanisms precisely. As a result, concentrations of NO and N_2O during co-combustion become almost similar to those during coal combustion, even if the input fuel nitrogen in co-combustion is half of that in coal combustion. The NO and N_2O formation/decomposition mechanisms relate to the heterogeneous reaction scheme. The main elemental reaction is the reaction of NO with char-C to produce CN, which reacts with OH to form NCO. Consequently, the simulation results agree well with the experimental results obtained.

DOI： 10.20550/jiebiomassronbun.1.0_102

模擬廃油燃焼場における微粒子の生成特性

金岡俊樹, 村松健志, 成瀬一郎

廃棄物学会研究発表会講演論文集 17 巻 ( 0 ) 頁： 241 - 241 2006年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

本研究では、廃油燃焼場における微粒子の生成特性を基礎的観点から明確にするために、２流体噴霧ノズルバーナを有するドロップチューブ燃焼炉を用いて、軽油ベースの模擬廃油燃料の燃焼実験を行った。ここでは、燃料中の残留炭素分ならびに芳香族炭化水素の種類と含有量に注目し、ベース燃料に残留炭素を多く含むC重油および各種芳香族炭化水素を添加した燃料を燃焼させ、燃焼排ガス中に存在する微粒子の粒径分布や濃度の比較を行った。主な結果として、空気比0.8の軽油燃焼場における微粒子は、粒径0.08_から_0.24mmに単一ピークを有するタール状のすす前駆体であり、排ガス中に約0.15g/m3の濃度で存在する。燃料中の残留炭素および芳香族炭化水素は、すす前駆体の濃度ならびに0.08_から_0.24mmのサブミクロン粒子の生成に影響を及ぼす。すす前駆体中におけるPAH濃度は、３_から_４環の化合物濃度が高い。

DOI： 10.14912/jswmepac.17.0.241.0

固体燃焼プロセスにおける微量金属を含む微粒子の生成機構解明とその制御

成瀬一郎

日本燃焼学会誌 48 巻 ( 144 ) 頁： 174 - 179 2006年

Screening of sorbents and capture of lead and cadmium compounds during sewage sludge combustion

Yao H., Mkilaha I., Naruse I.

Fuel 83 巻 ( 7-8 ) 頁： 1001 - 1007 2004年5月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Fuel

Current understanding has shown that aluminosilicate- and calcium-based sorbents could be applied to control trace metals emission from combustion and incineration processes. However, the use of industrial commercial sorbents is not always appropriate. The present study dwells on the use of natural and waste materials as sorbents to capture lead and cadmium compounds during combustion. The main task is to optimize the use of those materials by screening them, using a thermobalance. Then, the determined optimum sorbent was tested on an electrically heated drop tube furnace, burning sewage sludge at temperatures ranging from 1073 to 1223 K. The results showed that some of aluminosilicate-based sorbent were more effective than calcium-based sorbents. Kaolin was found to be a relatively effective sorbent for Pb and Cd capturing. The results further showed that the capture ability depended on chemical compositions and specific surface area of the sorbents. Presence of HCl caused a little decrease in the capture ability, using aluminosilicate-based sorbents, while significant effect on the capture processes was noted when calcium-based sorbents were used. Furthermore, when kaolin was added into the sewage sludge, kaolin was an appropriate sorbent to control lead and cadmium emissions. Temperature increase enhances the capture ability under our experimental conditions. Kaolin addition played a role for low leachability of the trace metals. © 2003 Elsevier Ltd. All rights reserved.

DOI： 10.1016/j.fuel.2003.10.022

燃焼プロセスにおける微量金属成分の生成挙動解明とその制御に関する研究(進歩賞(学術部門),平成15年度日本エネルギー学会)

成瀬一郎

日本エネルギー学会誌 83 巻 ( 4 ) 頁： 3 2004年4月

製鋼用電炉における熱源・炭素源としての廃プラスチックスの適応

亀嶋保, 堀田雅也, 成瀬一郎, 大森浩志

材料とプロセス : 日本鉄鋼協会講演論文集 = Current advances in materials and processes : report of the ISIJ meeting 17 巻 ( 1 ) 頁： 94 2004年3月

Methodology to construct material circulatory network in a local community

Naruse, I; Hotta, M; Goto, T; Funatsu, K

SUSTAINABLE DEVELOPMENT OF ENERGY, WATER AND ENVIRONMENT SYSTEMS 頁： 29 - 36 2004年

地域における物質循環型社会ネットワーク

成瀬一郎

化学工学 67 巻 ( 5 ) 頁： 267 - 268 2003年5月

Sorbent control of trace metals in sewage sludge combustion and incineration

Naruse I., Yao H., Mkilaha I.

Journal De Physique. IV : JP 107 巻 ( II ) 頁： 917 - 920 2003年5月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Journal De Physique. IV : JP

Coal and wastes combustion have become an important issue not only in terms of energy generation but also environmental conservation. The need for alternative fuels and wastes management has made the two energy sources of importance. However, the utilization of the two is faced with problems of impurity trace metals in the fuel. These metals usually speciate during combustion or incineration leading to generation of fumes and subsequently particles. This paper reports on the study aimed at understanding the speciation of trace metals and their emission from combustion systems as particulates. Experiments carried out using a down-flow furnace and theoretical study carried out using lead, chromium and cadmium as basic metals had shown that their speciation and subsequent emission is controlled by both chemical composition and physical properties of the fuel. The physical and chemical and physical properties of the fuel and their respective compounds and the operating conditions of the incineration and combustion system control the enrichment of the particles with trace metals.

DOI： 10.1051/jp4:20030448

Optimization and utilization of sorbents to control trace metal emissions in combustion processes

Yao, H; Naruse, I

COAL COMBUSTION FACING THE 21ST CENTURY 頁： 427 - 431 2003年

Trace-metal speciation during sludge combustion and incineration

Mkilaha I., Yao H., Naruse I.

Combustion Science and Technology 174 巻 ( 11-12 ) 頁： 325 - 344 2002年11月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Combustion Science and Technology

Municipal waste combustion has been opted as a method for reducing the size of the volume, and consequently, for reducing the necessary requirement of areas for direct disposal. However, the emission of the conventional gaseous pollutants are not the only problem; traces of metal fumes emanate from the metallic compounds that are in the wastes. Efforts to control these metal fumes have not been so successful because of the complicated mechanisms of the metallic compounds during combustion. Failure of the conventional systems to trap the trace elements is due to their appearance with the submicron particles from the combustion and incineration systems. In this work, a thermomechanical equilibrium approach is employed to study the combustion and gasification behavior of trace metals with a case of lead, cadmium, and chromium during the incineration of sewage sludge. In this work, sulfur and chlorine have been found to play a key role in the speciation of the trace metals. However, these elements are only active when oxygen is present. A test on alkali metals mixed with trace metals showed that at low concentrations of S and Cl, the alkali metals react first with these elements before other metals. Chlorine assists in retaining most of the trace metals in the vapor phase while sulfur keeps them in the condensed form. The presence of iron, as is the case with most sorbents, hinders the reaction of Cl with the metals, thus suppressing the formation of volatile compounds.

DOI： 10.1080/713712965

Thermodynamic analysis of the role of chlorine and sulfur environments during combustion and incineration processes

MKILAHA Iddi S. N., YAO Hong, NARUSE Ichiro

Journal of material cycles and waste management 4 巻 ( 2 ) 頁： 143 - 149 2002年10月

固体の燃焼

成瀬一郎

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 81 巻 ( 7 ) 頁： 606 - 607 2002年7月

燃焼プロセスにおける水銀の挙動と制御

成瀬一郎

化学工学 66 巻 ( 4 ) 頁： 247 - 248 2002年4月

固体の燃焼

成瀬一郎

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 80 巻 ( 7 ) 頁： 605 - 606 2001年7月

Prediction of evolution characteristics of alkali metal compounds in coal combustion/gasification from coal properties

Murakami T., Naruse I.

Journal of Chemical Engineering of Japan 34 巻 ( 7 ) 頁： 899 - 905 2001年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

Fundamental evolution characteristics of alkali metal compounds, especially sodium compounds in coal combustion/gasification were experimentally studied using a rapidly heated batch reactor under a wide range of temperature conditions. Six types of coal with different properties were reacted in the reactor. The evolution characteristics of sodium compounds obtained experimentally were compared with those predicted using both coal properties of cross-correlation coefficient between sodium and silicon in the raw coal and the fraction of condensed sodium aluminosilicates in the residue, calculated by the thermochemical equilibrium theory. The reason why the two indices were selected is that the sodium aluminosilicates was detected by X-ray diffraction analysis in the residue. The cross-correlation coefficient between sodium and silicon in the raw coal is calculated using two digital images of sodium and silicon distributions obtained by the Energy dispersed X-ray (EDX) analysis at the cross-section of raw coals. On the other hand, the chemical equilibrium calculation is performed by prescribing the experimental conditions and ultimate analysis data and ash compositions of the coal. The results predicted correlated well with the experimental data even when the evolution characteristics of sodium was dependent on the coal type and when the experimental conditions were varied widely. The coal with low cross-correlation coefficient between sodium and silicon and low fraction of condensed sodium aluminosilicates in the residue was found to release sodium compounds. Both of the two indices proposed can contribute to the prediction of fundamental evolution characteristics of alkali metal compounds in the coal combustion/gasification.

DOI： 10.1252/jcej.34.899

個別生産プロセスにおけるアウトプット‐インプット，インプット‐アウトプットデータベース

吉田弘之, 今岡務, 棚田成紀, 梶内俊夫, 成瀬一郎, 大野勝久, 室山勝彦, 沢田達郎, 石井幹太, 播手泰雄, 船造俊孝, 白井義人, 後藤元信, 永井實, 平尾雅彦, 片山裕之, 水野哲孝, 後藤繁雄

環境科学会誌 14 巻 ( 4 ) 頁： 333 - 343 2001年

都市ごみ固形燃料の排ガス特性と基礎脱塩特性

成瀬一郎, 樋口篤志, 柳野秀朗

化学工学論文集 27 巻 ( 5 ) 頁： 604 - 609 2001年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

都市ごみのサーマルリサイクル技術の1つとして開発されたRDFの基礎的な脱塩特性に関する知見を得るために，実際の廃棄物から作られたRDFと塩素源とその含有率が可変できる模擬RDF単一ペレットを用いて塩素源（ポリ塩化ビニルおよび塩化ナトリウム）の差異による脱塩特性の違いを実験および化学平衡計算により明らかにした． 結果として，RDFの燃焼に伴う塩化水素ガスは，主に，揮発分放出段階で放出する．脱塩特性は，塩素源の差異に依存する．塩素源が有機系塩素の場合，脱塩率は温度に依存し最適脱塩温度が存在する．この理由は，低温域では脱塩速度が塩化水素ガス放出速度より遅くなること，逆に高温域ではチャー燃焼過程中に脱塩反応によって生成した塩化カルシウムが分解してしまうことに依る．一方，塩素源が無機系塩素であるNaClの場合，NaClの融点付近で融解し，ガス状のNaClまたはNa2Cl2として蒸発するので，塩化水素ガスの生成はほとんど無い．

DOI： 10.1252/kakoronbunshu.27.604

地域における物質循環ネットワーク構築のための方法論

成瀬一郎, 後藤知行, 山内健二, 船津公人

環境科学会誌 14 巻 ( 2 ) 頁： 231 - 237 2001年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：社団法人環境科学会

現状の社会構造を持続発展可能なものへと転換させるためには,物質循環を機軸とする社会システムの構築が必要不可欠である。本研究ではその具現化方策の一つとして,各種産業から発生する廃棄物を未利用物質と位置付け,必要であれば最適な再資源化技術を適用することにより,それを他の産業における原料として利用するという異業種間ネットワークの構築によって,地域におけるゼロエミッション化を実現する方法論を提案する。具体的には,アンケート調査によって各事業所および廃棄物中間・最終処理業者における原料,製品,廃棄物の量と質に関するデータベース化や未利用物質を原料へ転換する再資源化技術に関するデータベース化を行い,これらを入力情報としてネットワークシミュレータにより解析を行う。本報では,豊橋市および東三河地域を対象地域として,農業・漁業・鉱業・建設業・製造業の各事業所1,139社,廃棄物中間・最終処理業者64社についてアンケート調査を行い,それぞれ236社(回収率:20.7%),32社(回収率:50%)の回答結果からデータベースを作成した。また,文献調査等により,総数383件の再資源化技術情報に関するデータベースも作成した。さらに一例として,作成したデータベースより廃ポリエチレンと燃え殻を入力情報としてネットワークシミュレータによる現状での地域内物質循環について解析を行った。次に得られた結果から,適当な再資源化技術をデータベースより抽出し,仮想的に組み入れた場合の物質循環についても検討した。結果として,各種データベース作成とそれを利用したネットワークシミュレー夕による解析は,最適な地域物質循環ネットワーク構築のための有効なツールになるものと考える。

DOI： 10.11353/sesj1988.14.231

Reaction behavior of coke lump in raceway of blast furnace with pulverized coal injection

Naruse I., Nakayama K., Higuchi A., Khairil

ＩＳＩＪ　Ｉｎｔｅｒｎａｔｉｏｎａｌ 40 巻 ( 8 ) 頁： 744 - 748 2000年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

Reaction behaviors of a coke lump in raceway of blast furnaces which pulverized coal injection technology was adopted were studied by using a horizontal pulverized coal reactor. In the experiments two types of coke lump were used as samples. In the experiments, the reaction behaviors of coke lump were continuously observed by an 8 mm video camera system. Mass change of the coke lump was weighed at each exposure time, and surface temperature of the coke lump was also continuously measured by a two-color pyrometer. Additionally, both the reacting coal particles and gas were sampled and analyzed, and the deposition on the coke surface was also analyzed. In order to elucidate the effect of ash particles in coal on the coke reaction, LPG was also supplied as a fuel into the reactor instead of coal. As a result, mass loss of coke in the coal combustion is larger than that in the LPG combustion. When the coal particles collide with the coke at the surface, the ash particles easily stick there and spherical molten ash is formed on the surface. For the LPG combustion, only small spherical molten ash resulted from the coke is formed. Those results suggest that ash particles of the coal may enhance coke degradation due to chemical interactions between coal ash and coke.

DOI： 10.2355/isijinternational.40.744

69.石炭ガス化における生成灰粒子の高温付着挙動(石炭利用における科学と工学の融合)

山下亨, 富永浩章, 成瀬一郎, 朝廣紀夫

石炭科学会議発表論文集 37 巻 ( 0 ) 頁： 281 - 284 2000年

7-4.都市ごみ固形燃料の基礎燃焼・脱塩挙動(Session 4.7.8 燃焼・環境対策技術・エネルギー評価/経済)

樋口篤志, 柳野秀郎, 成瀬一郎

日本エネルギー学会大会講演要旨集 9 巻 ( 0 ) 頁： 285 - 288 2000年

貝殻の脱硫特性に及ぼすアルカリ金属化合物の影響 Open Access

村上高広, 齋藤克宏, 成瀬一郎

日本エネルギー学会誌 79 巻 ( 11 ) 頁： 1070 - 1077 2000年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Influence of alkali metal compounds on desulfurization characteristics of sea-shell and limestone was elucidated quantitatively by using a thermobalance in this study. Scallop removed alkali metals and chlorine and Tsukumi limestone added several alkali metal compounds and chlorides were used as a sample. In order to elucidate additive effect of sodium chloride into the limestone on the desulfurization characteristics, the mean pore size by a pore sizer, the sulfur distribution within a reacting particle by an EDX system and the crystal structure of particles by a XRD system were measured. As a result, the desulfurization efficiency for the scallop even after removing the alkali metals and chlorine little changed. The addition of sodium chloride into the limestone can increase the desulfurization efficiency best. Both the mean pore size and the crystal structure of the calcined limestone, into which sodium chloride was added, was similar to those of the calcined scallop. Thus the desulfurization reaction produced over the whole of a particle. However, even if sodium chloride was added into the calcined limestone (CaO), the desulfurization efficiency was not promoted.

DOI： 10.3775/jie.79.1070

石炭バイオブリケットの燃焼特性と硫黄固定効果に関する研究

王青躍, 呂国慶, 坂本和彦, 丸山敏彦, 金熙濬, 成瀬一郎, 畠山史郎, 溝口次夫, 羅仁学, 上出光志

エアロゾル研究 15 巻 ( 4 ) 頁： 364 - 371 2000年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：日本エアロゾル学会

In order to utilize low-grade coals, which contain high concentrations of sulfur (2-6 wt. %) and ash (>15 wt. %, dry basis), controlling pollutant emissions during combustion in domestic stoves and small-capacity industrial boilers, a composite solid fuel “coal-biomass briquette” with sulfur fixation function was produced in a pilot plant in Chongqing city, China. It was composed of 80 wt. % of low-grade coal and 20 wt. % of biomass (e. g., wood chips and agricultural wastes) with a small fraction of sulfur-fixation additives. In this study, we investigated the ignition and combustion characteristics of the coal-biomass briquettes, and developed a new sulfur fixation additive made from sub-product in gas welding industries. It was found that the coal-biomass briquette has the lower ignition temperature and higher combustion efficiency than the usual coal briquettes, and that the newly developed additive was superior to limestone or scallop shells in sulfur fixation capability. This method is simple, economical, and efficient, in terms of emission control of SO2, CO and other particulate pollutants from the combustion of low-grade coals using the conventional domestic stoves and boilers without modification. The coal-biomass briquette can be applicable for pollution control of coal combustion in some developing countries.

DOI： 10.11203/jar.15.364

Effects of air dilution on highly preheated air combustion in a regenerative furnace

高温微粉炭反応場におけるコークス反応挙動の解明

樋口篤志, 中山勝也, 成瀬一郎

材料とプロセス : 日本鉄鋼協会講演論文集 = Current advances in materials and processes : report of the ISIJ meeting 12 巻 ( 1 ) 頁： 70 - 72 1999年3月

Yuan, JW; Naruse, I

ENERGY & FUELS 13 巻 ( 1 ) 頁： 99 - 104 1999年1月

石炭燃焼場におけるアルカリ金属化合物の基礎放出特性

村上高広, 野田玲治, 成瀬一郎, 大竹一友

化学工学論文集 25 巻 ( 3 ) 頁： 389 - 394 1999年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

次世代石炭火力複合発電システムでは, 石炭中に含有しているアルカリ金属化合物が蒸発し, ガスタービン翼を高温腐食させる可能性が指摘されている.本研究では, 燃焼場におけるアルカリ金属化合物, とくにNaの基礎放出特性に及ぼす炭種依存性をバッチ式急速加熱燃焼炉を使用して実験的に明らかにした。その際, Na放出特性の炭種依存性を定量評価するために, 原炭中のNa化合物の存在形態分析および2元素イメージ相関法で得られるNa元素と他の元素との相互相関係数による定量化を行った. 結果として, Naの放出挙動は炭種により依存すること, 放出するNaは水溶性成分がほとんどであること, 原炭中のNa化合物がNaClとして存在すると放出し易いことなどを明らかにした.また, 2元素イメージ相関法により, 原炭中のNaとSiおよびAlとの相互相関係数が高いほどNaは放出されにくいことを定量的に明らかにした.

DOI： 10.1252/kakoronbunshu.25.389

2F1130 ピロー形状のバイオブリケット燃焼速度の解析

王青躍, 呂国慶, 金熙濬, 成瀬一郎

大気環境学会年会講演要旨集頁： 371 1998年9月

高温場の非接触温度計測法

成瀬一郎

化学工学 62 巻 ( 1 ) 頁： 47 - 48 1998年1月

パルプ黒液を添加したバイオコールブリケットによる自動脱硝挙動

金煕濬, 成瀬一郎, 呂国慶, 大竹一友, 上出光志

化学工学論文集 24 巻 ( 5 ) 頁： 779 - 783 1998年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

低品位炭の清浄燃焼のため, 劣質炭にバイオマスおよび脱硝剤としてパルプ黒液を添加して高圧成型し, 自己脱硝機能付バイオブリケットを開発した.バイオブリケットの窒素分の放出特性, 窒素酸化物の生成特性, 脱硝特性を明らかにするため, 電気加熱反応炉を用いて様々な実験条件で, 熱分解実験, 燃焼実験を行った. 主な結果として, 熱分解実験では石炭およびバイオマスの窒素分放出率は炉壁温度の増加に共に増加すること, 同一温度条件ではバイオマスの窒素分放出率が石炭より高いこと, 燃焼実験では窒素酸化物の総放出量は炉壁温度に対して変化していないが, 炉壁温度の増加とともにNOへの転化率は増加すること, 一方, その分N2Oへの転化率は減少していること等を明らかにした.パルプ黒液の添加により脱硝効果は, 揮発分放出・燃焼段階及びチャー燃焼段階で現れ, 添加量が10質量%以上で40%の脱硝率が得られることを示した.以上の結果から, パルプ黒液を添加したバイオブリケットは優れた自動脱硝能力をもっていることを世界で初めて明らかにした.

DOI： 10.1252/kakoronbunshu.24.779

Study on characteristics of self-desulfurization and self-denitrification in biobriquette combustion

Naruse I., Kim H., Lu G., Yuan J., Ohtake K.

Symposium (International) on Combustion 27 巻 ( 2 ) 頁： 2973 - 2979 1998年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Symposium (International) on Combustion

The characteristics of self-desulfurization and self-denitrification in biobriquettes were studied experimentally and numerically in this paper. The biobriquette was produced by mixing coal, biomass, desulfurizer, and/or denitrificater under a high-compression pressure condition. The combustion process of biobriquette appears in two stages, namely the volatile combustion stage and the char combustion stage. It was proved that limestone, wasted scallop shell, and calcium hydroxide have effective self-desulfurization capability in biobriquette combustion and that desulfurization mainly happens in the char combustion stage. Comparatively among the three desulfurizers used, calcium hydroxide has the highest desulfurization capability because of its lower calcination temperature, and scallop shell the second because of the larger porosity after calcination. A desulfurization efficiency as high as about 80% can be reached for some kinds of coals using scallop shell as desulfurizer with Ca/S over 3. A modified shrinking-core model was developed to predict the desulfurization efficiency in the char combustion stage, and an approximate agreement was obtained between the predictions and the experiments. It was also found that pulp black liquid, an industrial waste to roll as binder in the biobriquetting process, has both self-denitrification and self-desulfurization capabilities in biobriquette combustion. A denitrification efficiency of about 40% can be obtained by adding the pulp black liquid into biobriquette with about 15% in mass.

DOI： 10.1016/S0082-0784(98)80157-4

Reduction of pollutants from diesel exhaust by high pressure gas injection

Kawai D., Mkilaha I., Osawa T., Naruse I., Ohtake K.

JSAE Review 18 巻 ( 3 ) 頁： 241 - 245 1997年7月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：JSAE Review

In order to reduce the pollutants from diesel exhaust, high-pressure gas was injected during combustion into a modified pre-chamber of an IDI diesel engine at a varied load and gas injection timing. The result shows that high-pressure gas injection can reduce the particulates and NOx simultaneously, with little influence on the engine performance. The combustion process in the pre-chamber was visualized by means of an ultra high-speed video system and image analysis of the pictures obtained. The results of the visualization show that by injecting gas, the flame is first quenched, followed by the reduction of NOx in the pre-chamber by hydrocarbon. Although high-pressure gas injection could have caused a substantial increase in HC as a result of temperature quenching, this seems to be controlled by the consumed portion of HC during the recycling of NOx. Chemical analysis of polycyclic aromatics compounds was carried out for the purpose of establishing its variations with gas injection. It was established that gas injection not only reduces PM by oxidation of solid carbon, but also the PAH component. © 1997 Society of Automotive Engineers of Japan, Inc. and Elsevier Science B.V.

DOI： 10.1016/S0389-4304(97)00013-1

Simultaneous reduction of particulate matter and NO<inf>x</inf> in a diesel engine by compressed gas injection: Macroscopic study at residual load

Reduction of pollutants from diesel exhaust by high pressure gas injection

KAWAI Daizaburo, MKILAHA Iddi S. N., OSAWA Takuya, NARUSE Ichiro, OHTAKE Kazutomo

18 巻 ( 3 ) 頁： 241 - 245 1997年7月

Mkilaha I.S.N., Inoue M., Kawai D., Naruse I., Ohtake K.

Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering 211 巻 ( 3 ) 頁： 227 - 236 1997年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering

A modified pre-chamber of an indirect injection (IDI) diesel engine was used to elucidate the influence on emissions of compressed air injection into the pre-chamber during combustion. The test parameters were air injection timing and arrangements of gas injection. This paper presents the experimental results for two types of injection arrangements; I- and Y-type. The I-type is arranged such that the gas injection jet and fuel injection nozzle are in opposite directions, while the Y-type is such that it forms a 'Y' shape with the nozzle and the passageway. Results obtained reveal that the Y-type arrangement is superior in combustion characteristics and emissions reduction to the I-type. A remarkable reduction in both particulate matter (PM) and NOx is realized at air injection timings during 35° and 65° after top dead centre (ATDC). The reduction mechanism can be explained as due to the induced turbulence which improves mixing and heat transfer. The effect of the modifications on the performance of the engine was evaluated based on the fuel economy and efficiency. This evaluation has shown that the test cylinder approximates closely to the normal cylinder of the original engine. © IMechE 1997.

DOI： 10.1243/0954407971526380

燃焼プロセスにおける有害金属の生成機構とその制御 : アメリカにおける研究動向

成瀬一郎

日本機械学会誌 100 巻 ( 947 ) 頁： 1108 1997年

バイオブリケットの基礎燃焼特性

呂国慶, 外山哲也, 金煕濬, 成瀬一郎, 大竹一友, 上出光志

化学工学論文集 23 巻 ( 3 ) 頁： 404 - 412 1997年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

低品位炭の清浄燃焼のために開発された石炭とバイオマスを高圧成型した複合燃料であるバイオブリケットの熱分解と燃焼特性を基礎的に解明することを目的に, 単一バイオブリケットの熱分解, 燃焼特性に及ぼすバイオマスの種類と添加率などの影響をバッチ式電子天秤付電気加熱反応炉を用いて実験的に明らかにした. 主な結果として, バイオブリケット中の揮発成分量はバイオマス添加率と正比例の関係があること, バイオマス添加により石炭ブリケットよりも着火性と燃え切り性が良好になること, バイオブリケットの燃焼は揮発成分放出・燃焼とチャーの燃焼の二段階で進行すること, 揮発成分放出・燃焼段階では体積モデルが適用でき, 反応次数と反応速度定数ともバイオマス添加量との間に直線関係が存在すること, チャーの燃焼段階は未反応核モデル的に進行し, 外部からの酸素の拡散律速であることなどを明らかにした.ガス境膜における酸素の移動係数並びに灰層における酸素有効拡散係数から, 両拡散現象の寄与がほとんど同オーダであることを示した.

DOI： 10.1252/kakoronbunshu.23.404

アルカリ金属化合物の基礎蒸発特性

野田玲治, 高野剛志, 成瀬一郎, 大竹一友

化学工学論文集 23 巻 ( 5 ) 頁： 635 - 643 1997年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

石炭からのアルカリ金属の蒸発速度を予測するために, 石炭中に存在する無機アルカリ (Na, K) 化合物のうち塩化物および硫酸塩について不活性, 酸化性および還元性雰囲気下で熱天秤を用いて蒸発速度を測定した.実測値について蒸発経路および律速段階を同定するために拡散モデルによる検討を行った.その結果, 塩化物は単体および2量体として蒸発し, その蒸発速度は飽和蒸気圧を用いて拡散モデルから計算した値によって説明することができた.硫酸塩は単体の蒸発に加え, 不活性および酸化性雰囲気では以下の分解反応が生じることを示した. M2SO4⇒2M+SO2+O2 不活性雰囲気などで, 上記の分解反応が顕著になる場合, 分解速度によって蒸発速度が律速されることを明らかにした.還元性雰囲気では予想された以下の反応 M2SO4+2CO⇒2M+SO2+2CO2 は平衡に達しておらず, 以下の2つの反応速度が蒸発速度を律速している可能性を示した. M2SO4+4CO⇒2M+COS+5CO2 COS+2CO2⇒SO2+3CO

DOI： 10.1252/kakoronbunshu.23.635

流れの数値解析と化学装置のモデリング　　バイオブリケットの燃焼速度に及ぼす炭種・成型条件の影響

呂国慶, 金煕濬, 成瀬一郎, 大竹一友, 上出光志

化学工学論文集 23 巻 ( 6 ) 頁： 954 - 961 1997年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

バイオブリケットの燃焼に対して, 揮発成分放出・燃焼段階では体積モデルを, チャーの燃焼段階では未反応核モデルを用いて, バイオブリケットの燃焼性に及ぼす成型形状, 成型圧力および炭種などの影響を解明した. 主な結果として, 同一直径の球状および円柱状 (柱の高さと直径は同一) のバイオブリケットの燃焼では, 形状による燃焼性の影響がほぼないこと, 成型圧力は揮発成分放出・燃焼には影響を与えないが, チャーの燃焼では約245MPa以下で試料密度を介して燃焼性に影響を与えること, 石炭ブリケットの揮発成分放出・燃焼段階での反応次数と反応速度定数は石炭の燃料比と直線関係があること, 炭種と成型条件は灰層の気孔率を介してチャーの燃焼に影響を与えることなどを明らかにした.石炭・バイオマスの工業・元素分析, 灰の真密度と本論文で提案したモデルと半経験式からバイオブリケットの燃焼速度を精度良く解析できることを示した.

DOI： 10.1252/kakoronbunshu.23.954

2. 燃焼・燃料 : 2・5 固体燃料 (機械工学年鑑(1994年)熱工学)

成瀬一郎

日本機械学會論文集. B編 61 巻 ( 588 ) 頁： 2780 - 2781 1995年8月

4-1.バイオブリケットの燃焼特性と高性能脱硫剤の探索(研究・研究者間ネットワーク…,Session(4)若手の会)

成瀬一郎

日本エネルギー学会大会講演要旨集 4 巻 ( 0 ) 頁： 103 - 106 1995年

貝殻による脱硫反応特性

成瀬一郎, 西村喜芳, 大竹一友, 川部庭資

化学工学論文集 21 巻 ( 5 ) 頁： 904 - 909 1995年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

熱天秤を用いて, 3種類の貝殻 (ホタテ, アサリおよびカキ) の脱硫特性を明らかにした.また, 比較のために, 津久見産および船尾産石灰石も使用し同様な実験を行った.実験にあたり, まず, 各試料の物性として粒子比表面積, 細孔径分布および元素組成を測定した.実験方法は, 窒素中で試料を焼成しその後N2ベースのSO2+O2ガスに切り替えて脱硫実験を行った.その際, 試料粒径 (297～420μm) は固定し, 焼成温度, それに至るまでの昇温速度および脱硫温度を変化させた.脱硫後の粒子については, その断面の硫黄分布を2次元XMAで計測した.結果として, 脱硫効率と粒子比表面積には相関はなく, 粒子内の細孔径分布に依存すること, ならびに同一条件での貝殻と石灰石の脱硫効率は, どの貝殻も石灰石を上回っていることが明らかとなった.このような差異が生じた理由は, 石灰石の場合, 細孔径が小さいために反応生成物であるCaSO4により細孔が閉塞し, 粒子表面近傍しか脱硫に寄与しないのに対して, 貝殻の場合は, 大きな細孔が内部まで存在しているため, 粒子内部も脱硫反応に寄与することによる.

DOI： 10.1252/kakoronbunshu.21.904

チャー燃焼場におけるＮ２０生成特性

倉本浩司, 小泉一博, 成瀬一郎, 大竹一友

化学工学論文集 20 巻 ( 4 ) 頁： 482 - 488 1994年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

気泡流動層石炭燃焼から排出される亜酸化窒素 (N2O) に関して, チャー燃焼場からの生成・消滅特性をチャー粒子単層充填反応管を用いて実験的に検討した.実験は, 層温度, 供給酸素濃度およびチャー炭種を変化させて, 燃焼過程中の生成ガスならびに固体成分の変化を分析することにより考察した. 結果として, 燃焼過程中のNOおよびN2O濃度変化より, チャー燃焼過程の初期において, NO濃度は急激に増加するがN2O濃度は緩やかに増加した。これは, COが酸化される際に生成するHラジカルがN2O分解に寄与することによる.しかし, 燃焼後半になると, Hラジカルの供給が減少して生成N2O濃度は増加する.排出されるN2O濃度は, 層温度の低下および供給酸素濃度の増加に伴って増加し, 揮発分燃焼場において得られた知見と一致した.また, 固体側の分析結果より, チャーの違いを検討したところ, 燃焼過程におけるチャーの表面あるいは内部構造の差異 (網目構造あるいはバルーン構造) が, チャー中のN分の放出挙動に影響を与えることが明らかとなった.

DOI： 10.1252/kakoronbunshu.20.482

特集　化石エネルギー利用技術　低温微粉炭燃焼場におけるＮ２Ｏ生成消滅特性の解明

成瀬一郎, 山本康之, 伊藤嘉文, 大竹一友

化学工学論文集 20 巻 ( 6 ) 頁： 843 - 848 1994年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

石炭燃焼から排出される窒素酸化物の中でとくにN2Oに着目し, 電気加熱式1次元層流石炭燃焼炉を用いて多種類の石炭の低温場における燃焼実験を行った.実験は, 燃焼過程における粒子およびガスを採集・分析して, 石炭中窒素分の放出形態 (HCNおよびNH3) およびそれらの燃焼過程における転換形態を粒子およびガス側の両情報を関連付けながら詳細に検討した. 結果として, N2Oは主として揮発分燃焼領域で生成されること, NH3よりもHCNを放出する石炭の方が生成N2O濃度が高くなること, 揮発分燃焼がほぼ完了した後流領域では, NO濃度は緩やかに減少するがN2O濃度は増加する傾向を示すことを明らかにした.この領域でのN2O生成は, ガスおよび粒子中の窒素分析から, NOがチャー中の炭素と反応してNCOになり, これがNOと反応しN2Oになる経路およびNOとチャー中の窒素が反応して生成する経路による.N2Oの転換率は, 燃焼率の増加および高燃料比炭ほど増加する.これは, 粒子周りの温度ならびに燃焼雰囲気の還元性の違いによる.

DOI： 10.1252/kakoronbunshu.20.843

気泡流動層石炭燃焼場におけるＮ２Ｏの生成特性とその機構

成瀬一郎, 今成正雄, 小泉一博, 袁建偉, 大竹一友

化学工学論文集 20 巻 ( 2 ) 頁： 178 - 185 1994年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

低温場での石炭燃焼法の一つである気泡流動層において, そこから生成されるN2Oの生成特性およびその生成・消滅機構を実験ならびに反応速度論によって明らかにした.燃焼実験は, 層温度, 空気比, 炭種ならびに石炭供給方式を変化させて行った.反応速度論計算では, 流動層フリーボードでの気相反応に着目して, 温度, 空気比および揮発分含有窒素化学種をそれぞれ変化させて計算した. 結果として燃焼実験および理論計算から, 生成N2O濃度は層温度の減少および空気比の増加にともなって増加し, 一方, NO濃度は層温度にあまり影響されず空気比の増加にともなって増加した.石炭供給方式の変化により, N2Oは主として揮発分燃焼によって生成していることを明らかにした.石炭中の水素と窒素含有量の比が小さい石炭ほどN2O生成量は増大した.本結果は, 反応速度論計算より得られたHCNがNH3よりN2O生成に寄与することを裏付けている.N2Oの消滅は, COの酸化によって生ずるHラジカルにより促進されている.

DOI： 10.1252/kakoronbunshu.20.178

循環流動層石炭燃焼装置からのＮ２Ｏの発生特性

平間利昌, 細田英雄, 守富寛, 鈴木善三, 原田道昭, 清水忠明, 成瀬一郎

日本エネルギー学会誌 72 巻 ( 4 ) 頁： 252 - 262 1993年

未燃分を含有する石炭灰の燃焼反応速度解析

陳勇, 松田仁樹, 架谷昌信, 近藤聖, 成瀬一郎

化学工学論文集 19 巻 ( 1 ) 頁： 48 - 54 1993年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

熱天秤を用いた非等温熱分析法によってそれぞれ炉温1673Kの微粉炭燃焼器ならびに1123Kの流動層燃焼器より排出された約10%の未燃分を含むfly ash Aならびにfly ashBの燃焼性を検討した.実験は, 加熱速度1～1000K/min, 燃焼温度1173Kまで, 粒径37μm以下の条件下で空気流通系で行った.その結果, 次のような知見が得られた. 1) 燃焼過程を以下のように分離できた.加熱速度2K/min以下では, 燃焼反応律速となる.加熱速度700K/min以上では, 酸素の灰中における拡散が律速となる. 2) fly ashAとfly ash Bの燃焼反応速度パラメータと酸素の灰中の有効拡散係数はfly ash Aについて, E=70.1 (kJ/mol), A=0.71 (1/s kPa), Dc=1.66×10-5 (cm2/s) fly ash Bについて, E=82.0 (kJ/mol), A=13.3 (1/skPa), Dc=1.94×10-5 (cm2/s) である. 3) 1673Kの微粉炭ボイラより排出されたfly ash Aでは.未燃炭素の一部が黒鉛化しており, 燃焼性は同種炭チャーのものより劣る. 4) 1123Kの流動層ボイラより排出されたfly ash Bでは, フライアッシュ中の未燃炭は気孔の生成によって比表面積が増大しており, そのため, フライアッシュの燃焼性は同種炭チャーのものよりも若干良くなる.

DOI： 10.1252/kakoronbunshu.19.48

Study on N<inf>2</inf>O formation/destruction characteristics in coal combustion under a wide temperature range

Naruse I., Yamamoto Y., Imanari M., Yuan J., Ohtake K.

Symposium (International) on Combustion 24 巻 ( 1 ) 頁： 1415 - 1421 1992年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Symposium (International) on Combustion

Characteristics of N2O formation/destruction in coal combustion are studied experimentally and theoretically over a wide range of combustion temperature. The combustion experiments are carried out in pulverized (1200-1700 K) and bubbling fluidized bed (1000-1200 K) coal combustors to find the influence of combustion temperature, combustion air ratio and coal type on N2O formation. The effect of catalytic reactions by char, CaO and stainless steel particles on the N2O destruction reaction are also tested by using a packed bed reactor. In order to get a deeper understanding of the mechanisms of N2O formation/destruction, numerical simulations are carried out for homogeneous volatile combustion and for combustion of single coal particles. The controlling reactions of N2O formation/destruction are analyzed. The experimental and numerical study found that N2O was mainly formed from the volatiles combustion. The low temperature and oxidizing atmosphere favor N2O formation. N2O concentration increases with decreasing temperature and with increasing air ratio. HCN and NH3, evolved as volatile-N species, make important contributions to the formation of N2O as well as NO. Especially, HCN contributes more to the formation of N2O than NH3 in the low temperature range. On the other hand, H radicals produced by the oxidation reactions of CO and H2 promote the destruction of N2O. Char, CaO and stainless steel particles also act as N2O destruction catalysts. © 1992 Combustion Institute.

DOI： 10.1016/S0082-0784(06)80165-7

循環流動層における粒子‐流体間伝熱

渡辺智秀, 陳勇, 成瀬一郎, 架谷昌信

化学工学論文集 18 巻 ( 5 ) 頁： 600 - 606 1992年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

循環流動層における粒子-流体間伝熱実験を行い, 局所ならびに平均熱伝達率を求めて, 粒子-流体間伝熱特性に及ぼす諸因子について考察した.その結果として, 局所熱伝達率は, 分散板直上部で高い値を示すが, その後は減少して, 一定値に漸近した.つまり, 局所熱伝達率は, 粒子-流体間のスリップ速度の変化によって影響される.また, 平均熱伝達率を用いた粒子ヌッセルト数をスリップ速度を用いた粒子レイノルズ数で整理したところ比較的よい相関が認められたが, 本結果は, 希薄輸送層ならびに気泡流動層の結果よりも小さい値となった.さらに, 層内全粒子ホールドアップの増大に伴い粒子ヌッセルト数は減少した.これらの結果から, 徳環流動層内の粒子-流体間伝熱は, 粒子-粒子間内の空間の流動状態に依存することが明らかとなった.

DOI： 10.1252/kakoronbunshu.18.600

微粉炭燃焼場における粒子およびガス温度の光学的同時分離測定

山本康之, 後藤勝治, 市丸広志, 成瀬一郎, 大竹一友

化学工学論文集 18 巻 ( 5 ) 頁： 643 - 651 1992年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

微粉炭燃焼機構を解明するための基本的なパラメータである粒子ならびにガス温度の光学的同時分離測定法を開発した.粒子温度は, 高速2色高温計, ガス温度はNa-D線反転法の原理を用いてそれぞれ検出し, 乱流炉内の断面瞬時粒子およびガス温度分布をCT手法を適用して推算した.計算に際して, 光路に沿う放射の粒子による減衰を考慮した.CT手法による算出誤差を予めシミュレーション実験により見積った.粒子減衰係数, 粒子温度およびガス温度の断面分布をそれぞれ仮定して投影データを求め, それを逆投影して仮定した分布と比較した. 結果として, CT手法による算出誤差はわずかであり, 実験投影データから正確に炉内温度分布が算出できた.実験で得られた炉内瞬時粒子およびガス温度分布の結果から, 粒子温度とガス温度には明らかな差が存在していることが示された.つまり, 上流の揮発分燃焼領域では粒子温度がガス温度よりも高く, 瞬間温度の変動も粒子の方が大きくなった.しかし, 下流のチャー燃焼領域では, ガス温度の方が高くなることが明らかになった.

DOI： 10.1252/kakoronbunshu.18.643

発変電機器における漏油検知シートの開発

成瀬一郎, 井上俊夫, 堺松成, 安井潔, 架谷昌信

化学工学論文集 18 巻 ( 5 ) 頁： 562 - 569 1992年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

発変電機器における保守点検中の漏油の有無の確認作業において, 直接的かつ簡易的な漏油検知方法を提案した.そこでまず, 検知シートを実際に試作し, 絶縁油, 潤滑油および制御油を用いて実験室レベルの基礎実験を行った.つぎに, 基礎実験の結果を基に, 実機における実証試験も行った.さらに, 漏油検知機構を明らかにするために, FIDガスクロマトグラフ, 質量分析計および核磁気共鳴分析計を用いて漏油検知に関与する化学種を同定した. 基礎実験結果から, 油溶性の発色剤とこれを発色させる顕色剤とをそれぞれシート上に2層塗布するという化学反応を利用する方法が, 簡便でしかも水などの妨害成分による影響が皆無であり有効であった.本検知シートの発色反応には各種油中に含まれている微量の芳香族水素が寄与していた.実証試験を行う前に, 本検知シートの安全性について確認したところ, 電気抵抗, 絶縁破壊電圧ならびに温度特性とも使用上問題はなかった.実機における暴露試験結果から, 本検知シートが実用上支障なく使用可能であることが検証できた.

DOI： 10.1252/kakoronbunshu.18.562

熱循環式ＣＦＭ層型２段燃焼装置における石炭の燃焼限界

成瀬一郎, 松田仁樹, 架谷昌信

化学工学論文集 15 巻 ( 1 ) 頁： 105 - 112 1989年

記述言語：日本語掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

高効率燃焼と同時に環境対策をも具備する石炭燃焼装置を開発するために, 高速流動層と移動層とを装置内で組み合わせたCFM層型固気接触装置を提案し, 本装置における石炭粒子の燃焼特性を実験的に検討した.本装置の構造は2重管型であり, 燃焼方式は, 内管部において高速流動層あるいは気流層を形成しつつ石炭の部分燃焼を行い, 環状部出口付近の移動層部においてチャー燃焼を行う方法を採用している. 本報では, Loy Yang炭およびコークスを試料として用い, 特にそれらの過濃ならびに希薄燃焼限界に着目した検討を行った.その結果, 1次空気比が0.3から2.4を越える領域まで連続的に安定燃焼が可能であり, 本装置が広い空気比で操作可能であることが明らかになった.さらにこれらの結果から, 本装置の着火機構は内管部での粒子循環効果のみならず環状部から内管部への熱循環効果も寄与することが明らかになった.

DOI： 10.1252/kakoronbunshu.15.105

1-01　微粉炭のガス化挙動に及ぼすチャー構造の影響

Ash deposition mechanisms in Waste-to-Energy plants 招待有り査読有り

Hiroshi NAGANUMA, Takehito MORI, Sho WATANABE, Akihiro SAWADA, Taeko GOTO, Yasuaki UEKI, Ryo YOSHIIE, Ichiro NARUSE

J-STAGE Mechanical Engineering Journal 2022年5月

Ash deposition mechanisms in Waste-to-Energy plants, 査読有り

Hiroshi NAGANUMA, Takehito MORI, Sho WATANABE, Akihiro SAWADA, Taeko GOTO, Yasuaki UEKI, Ryo YOSHIIE, Ichiro NARUSE

J-STAGE Mechanical Engineering Journal, Article ID: 21-00435 2022年5月

Ash Particle Behaviors during Combustion and Gasification of Coke 査読有り

Ueki Yasuaki, Teshima Koki, Yoshiie Ryo, Naruse Ichiro

ISIJ INTERNATIONAL 60 巻 ( 7 ) 頁： 1427 - 1433 2021年

根岸孝征, 植木保昭, 義家亮, 成瀬一郎, 中野薫

石炭科学会議発表論文集 57 巻 ( 0 ) 頁： 2 - 3 2020年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Currently, pulverized coal is blown into blast furnaces to reduce the amount of coke used in the steelmaking process. On the other hand, in recent years, the grade of coal has been declining due to the increase in the use of coal, and the company has been forced to respond to the diversification of coal types. Therefore, in this study, we used a batch furnace to prepare three types of coal char, and then the cross-sectional observation of the char by SEM and specific surface area analysis by BET method using N2 were carried out. Coal with porous particles and high specific surface area values was found to have very high gasification reactivity for both CO2 and H2, while coal with balloon-type particles with large cavities inside the particles and low specific surface area values was found to have lower gasification reactivity.

DOI： 10.20550/jiesekitanronbun.57.0_2

4-11　微量炭化水素による固体酸化物燃料電池の劣化挙動

張慧, 義家亮, 成瀬一郎, 植木保昭

日本エネルギー学会大会講演要旨集 29 巻 ( 0 ) 頁： 130 - 131 2020年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In this study, effects of tar-containing fuel gas on the SOFC with Ni-YSZ as anode electrode are evaluated. The simulated gas was hydrogen contaminated with toluene as model substance of tar. Electrochemical behaviors were investigated under several toluene concentrations in wet (2.3vol% H2O) H2 at 850°C during 30h using constant current measurement and impedance analysis in order to assess the SOFC's stability. Constant current measurements were conducted under 200mA/cm2 mainly and impedance analysis was conducted under OCV conditions. Experimental results show that the presence of tar dramatically reduces the electrochemical performance of SOFC even under a low concentration of 100ppm. It was also indicated this reduction tend to be serious when concentration of toluene increase.

DOI： 10.20550/jietaikaiyoushi.29.0_130

1-02　流動層におけるOxy石炭燃焼挙動の解明

山中建人, 義家亮, 植木保昭, 成瀬一郎

石炭科学会議発表論文集 57 巻 ( 0 ) 頁： 4 - 5 2020年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Oxy-Fuel combustion is one of the techniques to achieve carbon dioxide capture and storage (CCS). Meanwhile, fluidized bed combustion has the advantage of increasing combustion efficiency due to particle flow. Oxy-fuel coal combustion in a fluidized bed is a relatively new study, so the combustion behavior remains unclear. In this study, we investigated Oxy-fuel coal combustion behavior by comparing three combustion atmospheres, air, CO2-O2 and Oxy-Fuel using bubbling fluidized bed reactor. Especially in this research, we focused on the production of SOx, and in Oxy-fuel combustion, the concentration of SO2 increased due to the effect of recirculation. Regarding SO3 generation in Oxy-fuel combustion, the concentration became high due to the influence of SO2 circulation and H2O circulation.

DOI： 10.20550/jiesekitanronbun.57.0_4

Direct analysis of saturated hydrocarbons using glow discharge plasma ionization source for mass spectrometry 査読有り

Nunome Yoko, Kodama Kenji, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro, Wagatsuma Kazuaki

TALANTA 204 巻頁： 310 - 319 2019年11月

Generation behavior of tar from ABS, PC, and PE during pyrolysis and steam gasification by mass spectrometry 査読有り

Nunome Yoko, Suzuki Toshiya, Nedjalkov Ivan, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

JOURNAL OF MATERIAL CYCLES AND WASTE MANAGEMENT 21 巻 ( 6 ) 頁： 1300 - 1310 2019年11月

Characteristics of Biomass Devolatilization and in Situ Char Gasification Tested by the Non-Isothermal Method 査読有り

Zeng Xi, Kahara Kaito, Ueki Yasuaki, Yoshiie Ryo, Xu Guangwen, Naruse Ichiro

ENERGY & FUELS 33 巻 ( 10 ) 頁： 9805 - 9817 2019年10月

Removal of gaseous elemental mercury by hydrogen chloride non-thermal plasma modified biochar

Luo Jinjing, Jin Mingchang, Ye Lurong, Cao Yinan, Yan Yonggui, Du Rupeng, Yoshiie Ryo, Ueki Yasuaki, Naruse Ichiro, Lin ChinJung, Lee YiYuan

JOURNAL OF HAZARDOUS MATERIALS 377 巻頁： 132 - 141 2019年9月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Journal of Hazardous Materials

Hydrogen chloride (HCl)non-thermal plasma was applied to introduce Cl active sites on biochar prepared from sorghum straw in this study. Surface modified biochar was then placed in flue gas with typical components to investigate its elemental mercury (Hg0)capture ability. To elucidate the adsorption mechanism & binding properties, samples were characterized by N2 adsorption, scanning electron microscopy with energy dispersive spectrometer (SEM-EDS)and X-ray absorption near edge structure (XANES)analysis of Hg LIII-edge, Cl K-edge and S K-edge. Experimental results showed that HCl plasma modification successfully increased Cl active sites on biochar and greatly increased its mercury removal efficiency. Both HCl treatments (w/without plasma involvement)altered biochar's surface structure and layered structure generated. XANES spectra revealed that adsorbed-Hg on HCl-treated biochars mainly in the form of Hg+. Gaseous Hg0 was believed to heterogeneously react with chlorinated sites through electron-transfer and formed Hg2Cl2 compounds. With the presence of NO or SO2 in the system, adsorbed mercury existed on biochar mainly as Hg+. SO2 competed and inhibited the adsorption of Hg0; while NO promoted Hg0 removal capacity by increasing the active sites and enhancing the adsorption kinetics of adjacent Cl-containing sites.

DOI： 10.1016/j.jhazmat.2019.05.045

Oxygen chemisorption and low-temperature oxidation behaviors of sub-bituminous coal

PubMed

Development of a Heating Process of a Slag-Tapping Hole by Syngas Burning in a 150 t/d Entrained-Bed Coal Gasifier 査読有り

Ishiga Takuya, Kumagai Takeshi, Utano Masakazu, Yamashita Hiroshi, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

ENERGY & FUELS 33 巻 ( 4 ) 頁： 3557 - 3564 2019年4月

A novel CO2-water leaching method for AAEM removal from Zhundong coal 査読有り

Ding Lizhi, Gao Yaxin, Li Xian, Wang Wenhui, Xue Yi, Zhu Xianqing, Xu Kai, Hu Hongyun, Luo Guangqian, Naruse Ichiro, Yao Hong

FUEL 237 巻頁： 786 - 792 2019年2月

Effects of mechanical stresses around single tube on ash shedding in pulverized coal combustor 査読有り

Sato Naoki, Ueno Shun-ichiro, Ohno Emi, Tamura Masato, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

PROCEEDINGS OF THE COMBUSTION INSTITUTE 37 巻 ( 3 ) 頁： 2875 - 2882 2019年

Yoshiie Ryo, Onda Masaomi, Ueki Yasuaki, Naruse Ichiro

JOURNAL OF THERMAL SCIENCE AND TECHNOLOGY 14 巻 ( 1 ) 頁： JTST0005 - JTST0005 2019年

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会・社団法人日本伝熱学会

The effective utilization of sub-bituminous coals should be extended as an energy source for power generation because of their low cost and long minable years. However, sub-bituminous coal may undergo spontaneous combustion owing to high reactivity with oxygen in low-temperature air compared with bituminous coal. Therefore, the objective of this study is to elucidate the low-temperature oxidation behaviors of sub-bituminous coal. In particular, transition from oxygen chemisorption to low-temperature oxidation of sub-bituminous coal has been experimentally examined in detail. Isothermal gravimetric analyses are conducted for several bituminous and sub-bituminous coal samples at temperatures varying between 356 K and 476 K in oxygen-enriched air. The chemical compositions of emission gas are continuously monitored under low-temperature oxidation conditions. The changes in the chemical structure of the coals are analyzed using Fourier transform infrared (FTIR) spectrometry. The experimental results show that the mass of all tested coals, including those of bituminous and sub-bituminous coals, increases at temperatures below 426 K as a result of oxygen chemisorption. At 476 K, the mass of sub-bituminous coal increases slightly with low H 2 and CO 2 emissions at the beginning and subsequently decreases with high CO and CO 2 emissions. This mass change indicates that the transition from oxygen chemisorption to low-temperature oxidation occurs during this period. In addition, the FTIR spectra of sub-bituminous coals show the existence of carbonyl groups even in raw coal samples. These carbonyl groups are considered to contribute to the formation of CO 2 and H 2 from the beginning of reactions, triggering the transition from oxygen chemisorption to low-temperature oxidation.

DOI： 10.1299/jtst.2019jtst0005

Examination of the reduced combustion reaction mechanism for NOx concentration prediction in a waste incinerator

1-14　微粉炭および木質バイオマスの混焼挙動

永田淳, 植木保昭, 義家亮, 成瀬一郎, 成川公史, 森井一彦

石炭科学会議発表論文集 56 巻 ( 0 ) 頁： 28 - 29 2019年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Currently, the proportion of fossil fuel in the primary energy supply in Japan is very high. So, the use of renewable energy is collecting a lot of attention as an alternative to fossil fuel. Biomass, a type of renewable energy, has the advantage of carbon neutral. On the other hand, Biomass has the disadvantage of low power generation efficiency when using power generation because of the low energy density. From these backgrounds, biomass co-combustion for coal fired power generation has been focused on. In this study, co-combustion experiments of pulverized coal and biomass samples were carried out, in order to investigate the effect of mixture ratios and types of biomass samples on co-combustion behaviors.

DOI： 10.20550/jiesekitanronbun.56.0_28

1-5　脱硝触媒におけるSi化合物付着特性

中西浩太, 義家亮, 植木保昭, 成瀬一郎, 岡高憲, 吉田拓也, 田中丈晴, 秋山勝哉

石炭科学会議発表論文集 56 巻 ( 0 ) 頁： 10 - 11 2019年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In coal-fired power generation, De NOx catalysts are known to deteriorate over time, but its mechanism has not been clarified yet. According to the previous research, it has been found that amorphous silica forms a thin layer on the catalyst surface, which composition are much different from those of coal ash. It implies that coal ash itself does not adhere on the surface of the catalyst, but Si compounds in the gas deposits to the catalyst. In order to confirm this consideration, deposition behaviors of vapor Si compounds to the catalyst surface were examined, and its effect on the catalyst performance was investig ated. High volatile siloxane was selected to simulate vapor Si compounds in exhaust gas. Two kinds of experiments are conducted, such as exposure and immersion tests. In the former, test pieces of the catalyst were exposed to siloxane vapor. In the latter, test pieces were immersed in liquid siloxane and calcined afterward. The amount of silica deposition on the surface of the catalyst was analyzed by SEM / EDX. In the catalyst performance evaluation test, dete rioration of the catalyst by silica adhesion wa s confirmed.

DOI： 10.20550/jiesekitanronbun.56.0_10

1-2-1 微粉炭燃焼ボイラ内における灰付着制御

塚原恭平, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 28 巻 ( 0 ) 頁： 8 - 9 2019年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Coal combustion process discharges a large amount of ash, compared with petroleum and natural gas combustions. Coal ash particles melt and partially volatilizes at high temperature zones, causing many problems. In this study, ash deposition experiment was carried out, using simulated heat transfer tubes made of thermal spraying material. Coal ash was injected into the furnace via high penetrance at a high temperature. The molten slag formation ratio of their chemical composition in a single coal was estimated by the thermodynamic equilibrium calculation and the change of ash deposition characteristics was quantitatively discussed.

DOI： 10.20550/jietaikaiyoushi.28.0_8

Denda T.

12th Asia-Pacific Conference on Combustion, ASPACC 2019 2019年

Insight of arsenic transformation behavior during high-arsenic coal combustion

Yang Y.

Proceedings of the Combustion Institute 37 巻 ( 4 ) 頁： 4443 - 4450 2019年

A deep insight into carbon conversion during Zhundong coal molten salt gasification

Xu Mian, Hu Hongyun, Yang Yuhan, Huang Yongda, Xie Kang, Liu Huan, Li Xian, Yao Hong, Naruse Ichiro

FUEL 220 巻頁： 890 - 897 2018年5月

Development of soft ionization using direct current pulse glow discharge plasma source in mass spectrometry for volatile organic compounds analysis

Nunome Yoko, Kodama Kenji, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro, Wagatsuma Kazuaki

SPECTROCHIMICA ACTA PART B-ATOMIC SPECTROSCOPY 139 巻頁： 44 - 49 2018年1月

Combustion behaviors of wasted plastics coated around electric cables in electrically heated drop tube furnaces

Nunome Yoko, Matsumoto Hiroshi, Nedjalkov Ivan, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

JOURNAL OF MATERIAL CYCLES AND WASTE MANAGEMENT 20 巻 ( 1 ) 頁： 543 - 551 2018年1月

Case study on removal of heavy metals from waste incineration fly ash by acid leaching method

Yoshiie Ryo, Luo Jinjing, Cao Yinan, Sun Shiqiang, Ueki Yasuaki, Naruse Ichiro

廃棄物資源循環学会研究発表会講演集 29 巻 ( 0 ) 2018年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人廃棄物資源循環学会

Four kinds of fly ash from three municipal solid incinerators in southern China were examined in this study. The characteristics of fly ash were examined and acid leaching treatment was used to remove heavy metals from samples. The toxicity characteristic leaching procedure (TCLP) was executed to assess the effect of acid leaching method to fly ash samples. The experiment results showed that the contents of Cd and Pb in the original fly ash were higher, which classified them into the hazardous waste list. With the treatment of water washing and acid leaching, all fly ash samples removed heavy metals efficiently and the contents of heavy metals in treated fly ash met the admittance criterion of sanitary landfill.

DOI： 10.14912/jsmcwm.29.0_603

No.1-18 コークスの反応過程における灰粒子特性に及ぼす温度の影響

手島光基, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 55 巻 ( 0 ) 頁： 36 - 37 2018年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

One of the important purposes of the coke in the blast furnace is the spacer to ensure the gas and liquid permeability. In other hands, ash particles in coke became slags inside the furnace and these are one of the causes that significantly worsen the permeability. In this study, combustion and gasification experiments of coke were conducted at each experimental temperature. Ash particles in the coke samples were analyzed by using SEM in order to clarify effect of temperatures on ash particles characteristics during combustion and gasification of coke.

DOI： 10.20550/jiesekitanronbun.55.0_36

Na & Ca removal from Zhundong coal by a novel CO2-water leaching method and the ashing behavior of the leached coal

Gao Yaxin, Ding Lizhi, Li Xian, Wang Wenhui, Xue Yi, Zhu Xianqing, Hu Hongyun, Luo Guangqian, Naruse Ichiro, Bai Zongqing, Yao Hong

FUEL 210 巻頁： 8 - 14 2017年12月

Interactions between molten salts and ash components during Zhundong coal gasification in eutectic carbonates

Shen Junhao, Hu Hongyun, Xu Mian, Liu Huan, Xu Kai, Zhang Xiuju, Yao Hong, Naruse Ichiro

FUEL 207 巻頁： 365 - 372 2017年11月

Effect of hydrogen gas addition on combustion characteristics of pulverized coal

Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro, Matsuzaki Shinroku

FUEL PROCESSING TECHNOLOGY 161 巻頁： 289 - 294 2017年6月

Investigation of fragmentation and coalescence behavior of ash particles in simulated coal combustion

Yoshiie Ryo, Nishimura Hitoshi, Ueki Yasuaki, Naruse Ichiro, Sato Naoki, Ito Takamasa, Choi Wonyoung, Ueno Shunichiro

FUEL PROCESSING TECHNOLOGY 161 巻頁： 101 - 106 2017年6月

Fundamental Combustion Behaviors of Solid Industrial Wastes

Asai Toshihiko, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro, Terasaki Junichi, Ueno Naoki

JOURNAL OF THE JAPAN INSTITUTE OF ENERGY 96 巻 ( 6 ) 頁： 167-175 2017年6月

固形産業廃棄物の基礎燃焼挙動

Asai Toshihiko, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro, Terasaki Junichi, Ueno Naoki

日本エネルギー学会誌 96 巻 ( 6 ) 頁： 167-175 2017年6月

Energy system simulation of regenerable Molten Alkali Carbonates for gasification of carbonaceous resources

Raharjo S.

ARPN Journal of Engineering and Applied Sciences 12 巻 ( 7 ) 頁： 2306 - 2312 2017年4月

Tar and soot generation behaviors from ABS, PC and PE pyrolysis

Nedjalkov Ivan, Yoshiie Ryo, Ueki Yasuaki, Naruse Ichiro

JOURNAL OF MATERIAL CYCLES AND WASTE MANAGEMENT 19 巻 ( 2 ) 頁： 682 - 693 2017年4月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Journal of Material Cycles and Waste Management

In this study we performed a non-isothermal thermogravimetric analysis on three thermoplastics—ABS, PC and PE. The Coats and Redfern method (Nature 201:68–69, 1964) was then used to approximate the kinetic parameters of each material. In addition, we performed a series of pyrolysis experiments in a batch reactor, for each plastic. The experiments were performed over the temperature range of 600–1000 °C at a constant residence time. The liquid and solid products of the pyrolysis, were collected, separated and weighted. Those products were categorized as soot, tar and char (PC only), and their relative weight to initial sample weight (DAF) was plotted against the temperature. The tar measured was exclusively medium to high molecular weight (>80 g/mol). Results revealed that relative tar and soot production, for all three materials, first increases and then decreases with temperature increase. The maximum achieved tar yields for ABS, PC and PE were at 700, 650 and 800 °C, respectively; and the maximum soot yields were at 1000, 1000, 950 °C, respectively.

DOI： 10.1007/s10163-016-0470-7

1-4-1 石炭の低温酸化挙動に及ぼす石炭性状の影響

義家亮, 恩田雅臣, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 26 巻 ( 0 ) 頁： 24 - 25 2017年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Consumption of subbituminous coal will be expanded due to its low cost and long minable years around the world. However, a control of spontaneous firing at the stock yard is one of outstanding issues for the utilization of subbituminous coal. Therefore, an objective of this study is the elucidation of low-temperature oxidation behaviors of subbituminous coals. Several subbituminous and bituminous coals were selected as experimental samples for low-temperature oxidation. Mass changes of coal samples were measured by thermos-balance at the temperature between 356K and 476K in 50%N2-50%O2 atmosphere. Differences of molecular structures of coals between before and after low-temperature oxidation were analyzed by FTIR As a result, the aliphatic carbon in the coal was confirmed to react with oxygen, forming carbonyl group.

DOI： 10.20550/jietaikaiyoushi.26.0_24

5-2-1 等温条件における可燃性廃棄物の燃焼挙動

植木保昭, 浅井俊比古, 義家亮, 成瀬一郎, 寺崎淳一, 上野直樹

日本エネルギー学会大会講演要旨集 26 巻 ( 0 ) 頁： 186 - 187 2017年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

To elucidate fundamental combustion behaviors of some solid combustible wastes under isothermal conditions, the isothermal combustion experiments are carried out, using an electrically heated vertical batch furnace. The effects of the furnace temperature and the oxygen partial pressure in the reaction atmosphere on the combustion behaviors are studied experimentally and kinetically. As a result, the completion period of the overall combustion decreases with increases of both the furnace temperature and the oxygen partial pressure.

DOI： 10.20550/jietaikaiyoushi.26.0_186

No.1-1 石炭ガス化プロセスにおける微量成分の分配挙動の解明

渥美翔太, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 54 巻 ( 0 ) 頁： 2 - 3 2017年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

DOI： 10.20550/jiesekitanronbun.54.0_2

CO2 Regeneration of Used Alkali Carbonates for High-Temperature Desulfurization in Gasification

Raharjo Slamet, Nedjalkov Ivan, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

ENERGY & FUELS 30 巻 ( 10 ) 頁： 8556 - 8560 2016年10月

Effects of Coal Type on Growth and Shedding of Ash Deposit in Pulverized Coal Combustors

Sato Naoki, Ueno Shunichiro, Priyanto Dedy E., Ohno Emi, Matsuzawa Yoshiaki, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

ENERGY & FUELS 30 巻 ( 7 ) 頁： 6059 - 6069 2016年7月

Capture of Gaseous Mercury by Waste-Derived Particles as Sorbents

Yoshiie Ryo, Ueki Yasuaki, Naruse Ichiro

JOURNAL OF CHEMICAL ENGINEERING OF JAPAN 49 巻 ( 3 ) 頁： 312 - 316 2016年3月

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

Flue gases contain elemental mercury formed by combustion/incineration processes, and it is difficult to remove them by conventional gas cleaning devices. Researchers have developed a few sorbent materials to capture gaseous elemental mercury. Our study also found two candidate sorbent materials using low-cost waste derived particles, a paper sludge incineration ash and a carbonized municipal solid waste char. The main objective of this study is to elucidate the capturing mechanisms of gaseous elemental mercury in these two sorbents. In order to analyze the chemical states of the mercury adsorbed on the sorbents, X-ray absorption near edge structure (XANES) analyses of the mercury captured by sorbents are conducted. The XANES spectra of the two sorbents were found to be similar to those of Hg2Cl2 and HgS standard chemicals, while the XANES spectrum of the commercialized activated carbon for mercury capture was similar to that of elemental mercury. These results suggest that the gaseous mercury is captured and fixed on the sorbents via oxidation by chlorine and sulfur present in the sorbents.

DOI： 10.1252/jcej.14we339

Gasification Characteristics of Woody Biomass with Mixture Gas of CO2 with H2O

Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

JOURNAL OF CHEMICAL ENGINEERING OF JAPAN 49 巻 ( 3 ) 頁： 287 - 293 2016年3月

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

The objectives in the present study are to elucidate the fundamental gasification characteristics of woody biomass with a mixture gas of CO2 and H2O. The effects of temperature and gasification agents on the gasification characteristics of woody biomass were experimentally studied using an electrically heated drop tube furnace. The co-gasification performance of CO2 with H2O was compared with the CO2 or H2O gasification performance alone. As a result, H2 and CO concentrations increased with an increase of temperature under both the co- and single-gasification conditions. CO under the co-gasification condition was produced more than under the single-gasification condition. The H2 formation showed the opposite tendency to the CO formation during the co-gasification. This synergistic effect is caused by the difference of the surface structure of the woody biomass particles by CO2 from H2O.

DOI： 10.1252/jcej.14we338

Preface to the Special Issue for Energy Engineering

Naruse Ichiro, Ohtomo Junichiro, Qian Eika W., Yoshiie Ryo

JOURNAL OF CHEMICAL ENGINEERING OF JAPAN 49 巻 ( 3 ) 頁： 235 - 235 2016年3月

Development of thermal spraying materials through several corrosion tests for heat exchanger tube of incinerators 査読有り

Juan Chen, Yoshihiko Ninomiya, Hiroshi Naganuma, Yoriaki Sasaki, Manabu Noguchi, Hiromitsu Cho, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel Processing Technology 141 巻 ( 2 ) 頁： 216-224 2016年1月

Development of thermal spraying materials through several corrosion tests for heat exchanger tube of incinerators 査読有り

Juan Chen, Yoshihiko Ninomiya, Hiroshi Naganuma, Yoriaki Sasaki, Manabu Noguchi, Hiromitsu Cho, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel Processing Technology 141 巻 ( 2 ) 頁： 216-224 2016年1月

Development of thermal spraying materials through several corrosion tests for heat exchanger tube of incinerators

Chen Juan, Ninomiya Yoshihiko, Naganuma Hiroshi, Sasaki Yoriaki, Noguchi Manabu, Cho Hiromitsu, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

FUEL PROCESSING TECHNOLOGY 141 巻頁： 216 - 224 2016年1月

Performance indicators for air and air-steam auto-thermal updraft gasification of biomass in packed bed reactor 査読有り

Kihedu Joseph H., Yoshiie Ryo, Naruse Ichiro

FUEL PROCESSING TECHNOLOGY 141 巻頁： 93 - 98 2016年1月

記述言語：英語掲載種別：研究論文（学術雑誌）出版者・発行元：Fuel Processing Technology

Auto-thermal updraft gasification of biomass pellets in a packed bed reactor was conducted by using air and air-steam mixture. Air-steam gasification produced syngas with slightly improved lower heating value of 4.5 MJ/mN3 in comparison to 4.4 MJ/mN3 produced during air gasification. The corresponding tar generation for air gasification and air-steam gasification was 21.2 g/mN3 and 26.2 g/mN3, respectively. Cold gas efficiency for air gasification and air-steam gasification was realized to be 91% and 91.4%, respectively. Carbon conversion during air-steam gasification reached about 91.5% while carbon conversion during air gasification was limited to 84.3%.

DOI： 10.1016/j.fuproc.2015.07.015

519 捕捉剤を用いた石炭ガス化雰囲気での微量元素の除去(OS5-2 燃焼技術の基礎と応用研究(1)(燃焼技術と計測),OS5 燃焼技術の基礎と応用研究)

Performance indicators for air and air–steam auto-thermal updraftgasification of biomass in packed bed reactor 査読有り

141 巻頁： 93–98 2016年

ポリ硫酸第二鉄の熱分解特性に関する研究査読有り

義家亮，坂下基，植木保昭，成瀬一郎

硫酸と工業 69 巻 ( 6 ) 頁： 1-9 2016年

膜分離溶媒抽出を用いた廃潤滑油再生手法の開発査読有り

義家亮，片岡直也，植木保昭，成瀬一郎

廃棄物資源循環学会論文誌 27 巻頁： 37-43 2016年

廃棄物系炭化物による空気および還元性雰囲気中の元素水銀の捕捉特性査読有り

植木保昭，義家亮，澤浩明，成瀬一郎

鉄と鋼 102 巻 ( 1 ) 頁： 56-60 2016年

Effects of Coal Type on Growth and Shedding of Ash Deposit in Pulverized Coal Combustors 査読有り

Naoki Sato, Shunichiro Ueno, Dedy E. Priyanto, Emi Ohno, Yoshiaki Matsuzawa, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Enargy Fuels 頁： in press 2016年

ar and soot generation behaviors from ABS, PC and PE pyrolysis 査読有り

Ivan Nedjalkov, Ryo Yoshiie, Yasuaki Ueki, Ichiro Naruse

J Mater Cycles Waste Manag 頁： , in press 2016年

Sintering characteristics of CaO-rich municipal solid waste incineration fly ash through the addition of Si/Al-rich ash residues Authors 査読有り

Hong-Yun Hu,Huan Liu,Qiang Zhang,Ping-An Zhang,Ai-Jun Li,Hong Yao,Ichiro Naruse

Journal of Material Cycles and Waste Management 18 巻 ( 2 ) 頁： 340–347 2016年

Gasification Characteristics of Woody Biomass with Mixture Gas of CO2 with H2O

Yasuaki UEKI, Ryo YOSHIIE, Ichiro NARUSE

Jornal of Chemical Engineering of Japan 49 巻 ( 3 ) 頁： 287-293 2016年

義家亮, 水野祐太, 植木保昭, 成瀬一郎

東海支部総会講演会講演論文集 2016 巻 ( 0 ) 頁： _519 - 1_-_519-2_ 2016年

Capture Characteristics of Gaseous Elemental Mercury by Carbonized Waste in Air and Reducing Atmospheres

Ueki Yasuaki, Yoshiie Ryo, Sawa Hiroaki, Naruse Ichiro

TETSU TO HAGANE-JOURNAL OF THE IRON AND STEEL INSTITUTE OF JAPAN 102 巻 ( 1 ) 頁： 56 - 60 2016年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

Coal contains harmful trace elements. Especially, mercury has high volatility. Mercury of approximately 27% in coals used in coal fired power plants is released as gaseous elemental mercury in a flue gas to the atmosphere. In an ironmaking system, since large amounts of coal are used as a reducing agent and heat source, there is a possibility that the gaseous elemental mercury emits from some processes. Therefore, an objective in this work is to develop adsorbents that are able to capture the gaseous elemental mercury in an air atmosphere and a reducing atmosphere. In this work, carbonized wastes (sewage sludge, paper sludge, woody biomass and municipal solid waste) were used as experimental samples. As a result, the municipal solid waste char has the highest property to capture the elemental mercury in the air atmosphere at 423 K. From results of X-ray Absorption Near Edge Structure (XANES) analyses, the mercury captured in the municipal solid waste char was mainly captured as mercury sulfide (HgS) on the char. On the other hand, a mercury capture ratio of the municipal solid waste char in the reducing atmosphere was lower than that in the air atmosphere.

DOI： 10.2355/tetsutohagane.TETSU-2015-046

No.1-3 微粉炭燃焼場における灰粒子の凝集・脱離挙動の評価

ar and soot generation behaviors from ABS, PC and PE pyrolysis 査読有り

Ivan Nedjalkov, Ryo Yoshiie, Yasuaki Ueki, Ichiro Naruse

J Mater Cycles Waste Manag 頁： , in press 2016年

Effects of Coal Type on Growth and Shedding of Ash Deposit in Pulverized Coal Combustors 査読有り

Naoki Sato, Shunichiro Ueno, Dedy E. Priyanto, Emi Ohno, Yoshiaki Matsuzawa, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Enargy Fuels 頁： in press 2016年

Gasification Characteristics of Woody Biomass with Mixture Gas of CO2 with H2O

Yasuaki UEKI, Ryo YOSHIIE, Ichiro NARUSE

Jornal of Chemical Engineering of Japan 49 巻 ( 3 ) 頁： 287-293 2016年

松山達也, 義家亮, 植木保昭, 成瀬一郎

石炭科学会議発表論文集 53 巻 ( 0 ) 頁： 6 - 7 2016年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

One of the major problems in pulverized coal combustion process is ash deposit phenomena such as slagging and fouling. The behaviors of Included Minerals (IM) and Excluded Minerals (EM) are an important factor to predict and control such ash deposit phenomena. Then, we sampled pulverized coal particles in different carbon conversion and coal types using Drop Tube Furnace (DTF) and analyzed ash particles by Computer Controlled Scanning Electric Microscope (CCSEM) in previous study3). In this study, we made the models of single pulverized coal particle in combustion process using data gotten by CCSEM analysis and evaluated IM/EM particle properties such as particle number, particle diameter and composition in different carbon conversion and coal types through the simulation.

DOI： 10.20550/jiesekitanronbun.53.0_6

No.1-2 石炭燃焼排ガス中水銀の捕捉・酸化機構

坂井田雅哉, 義家亮, 植木保昭, 成瀬一郎

石炭科学会議発表論文集 53 巻 ( 0 ) 頁： 4 - 5 2016年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Coal combustion is one of the major mercury emission sources. The majority of mercury emissions from coal combustion is an elemental mercury. This is because oxidized mercury is water-soluble and easily captured, but on the other hand elemental mercury is water-insoluble and difficult to capture. In this study, we expected the De-NOx catalyst to have a mercury capture/oxidation performance and performed mercury capture/oxidation experiment using the De-NOx catalyst as a sorbent. In the result, when HCl is present in the atmosphere, the De-NOx catalyst oxidized mercury and when HCl is not present in the atmosphere, the De-NOx catalyst showed high mercury capture performance. Furthermore, De-NOx catalyst maintained high mercury capture performance at a relatively high temperature (673 K).

DOI： 10.20550/jiesekitanronbun.53.0_4

No.1-1 流動層を用いた石炭のOxy-Fuel 燃焼挙動の解明

浅井良介, 義家亮, 植木保昭, 成瀬一郎

石炭科学会議発表論文集 53 巻 ( 0 ) 頁： 2 - 3 2016年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Oxy-Fuel coal combustion has drawn attention in the world as useful technique to achieve carbon dioxide capture and storage (CCS). It is a technology to enrich CO2 in exhaust gas by the flue gas recirculation with additional pure O2 to combustion atmosphere, which makes easy to capture CO2. Meanwhile, bubbling fluidized bed coal combustion has advantages of direct sulfur capturing in bed material and decreasing of thermal NOX in low combustion temperature. Objectives of this paper are to understand hazardous emission behaviors during the oxy-coal fluidized bed combustion under the actual flue gas recirculation condition, compared with those under the air and CO2-O2 combustion conditions. A lab-scale fluidized bed reactor was utilized as the experimental equipment. Dusts were separated from flue gas via cyclone downstream, and carbon contents in them were analyzed to estimate carbon balances through the reactor.

DOI： 10.20550/jiesekitanronbun.53.0_2

Sintering characteristics of CaO-rich municipal solid waste incineration fly ash through the addition of Si/Al-rich ash residues Authors 査読有り

Hong-Yun Hu, Huan Liu, Qiang Zhang, Ping-An Zhang,Ai-Jun Li, Hong Yao, Ichiro Naruse

Journal of Material Cycles and Waste Management 18 巻 ( 2 ) 頁： 340–347 2016年

ポリ硫酸第二鉄の熱分解特性に関する研究査読有り

義家亮, 坂下基, 植木保昭, 成瀬一郎

硫酸と工業 69 巻 ( 6 ) 頁： 1-9 2016年

廃棄物系炭化物による空気および還元性雰囲気中の元素水銀の捕捉特性査読有り

植木保昭, 義家亮, 澤浩明, 成瀬一郎

鉄と鋼 102 巻 ( 1 ) 頁： 56-60 2016年

膜分離溶媒抽出を用いた廃潤滑油再生手法の開発査読有り

義家亮, 片岡直也, 植木保昭, 成瀬一郎

廃棄物資源循環学会論文誌 27 巻頁： 37-43 2016年

Heating technique of slag-tapping hole in high-temperature coal gasifier 査読有り

Takuya Ishiga,Fumihiko Kiso,Akinori Suetsugu,Masakazu Utano, Hiroshi Yamashita, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

, Fuel Processing Technology 138 巻頁： 100-108 2015年10月

微粉炭燃焼ボイラー内における灰挙動の解明査読有り

成瀬一郎，義家亮，植木保昭，佐藤直樹

ボイラ研究 ( 393 ) 頁： 27-33 2015年10月

Heating technique of slag-tapping hole in high-temperature coal gasifier 査読有り

Takuya Ishiga, Fumihiko Kiso, Akinori Suetsugu, Masakazu Utano, Hiroshi Yamashita, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

, Fuel Processing Technology 138 巻頁： 100-108 2015年10月

Heating technique of slag-tapping hole in high-temperature coal gasifier

Ishiga Takuya, Kiso Fumihiko, Suetsugu Akinori, Utano Masakazu, Yamashita Hiroshi, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

FUEL PROCESSING TECHNOLOGY 138 巻頁： 100 - 108 2015年10月

微粉炭燃焼ボイラー内における灰挙動の解明査読有り

成瀬一郎, 義家亮, 植木保昭, 佐藤直樹

ボイラ研究 ( 393 ) 頁： 27-33 2015年10月

Effects of flue gas re-circulation and nitrogen contents in coal on NOX emissions under oxy-fuel coal combustion

Yoshiie Ryo, Hikosaka Naoki, Nunome Yoko, Ueki Yasuaki, Naruse Ichiro

FUEL PROCESSING TECHNOLOGY 136 巻頁： 106 - 111 2015年8月

Growth and gravity shedding of ash deposition layer in pulverized coal combustors

Sato Naoki, Priyanto Dedy Eka, Ueno Shunichiro, Matsuzawa Yoshiaki, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

FUEL PROCESSING TECHNOLOGY 134 巻頁： 1 - 10 2015年6月

Growth and gravity shedding of ash deposition layer in pulverized 査読有り

Naoki Sato, Dedy Eka Priyanto, Shunichiro Ueno, YoshiakiMatsuzawa, Yasuaki Ueki, Ryo Yoshiie , Ichiro Naruse

coal combustors Fuel Processing Technology 134 巻頁： 1-10 2015年

Effects of flue gas re-circulation and nitrogen contents in coal on NOX emissions under oxy-fuel coal combustion 査読有り

Ryo Yoshiie , Naoki Hikosaka , Yoko Nunome , Yasuaki Ueki , Ichiro Naruse

Fuel Processing Technology 136 巻頁： 106-111 2015年

Mechanism of chromium oxidation by alkali and alkaline earth metals during municipal solid waste incineration 査読有り

Hongyun Hu, Zhang Xu, Huan Lin, Dunkui Chen, Aijun Li, Hong Yao, Ichiro Naruse

Proceedings of the Combustion Institute 35 巻頁： 2397-2403 2015年

213 廃プラスチックスの水蒸気ガス化場におけるタールの生成・消滅挙動

義家亮, 鈴木敏矢, 植木保昭, 成瀬一郎

東海支部総会講演会講演論文集 2015 巻 ( 0 ) 頁： _213 - 1_-_213-2_ 2015年

Combustion Behavior of Pulverized Coal and Ash Particle Properties during Combustion

Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

ISIJ INTERNATIONAL 55 巻 ( 6 ) 頁： 1305 - 1312 2015年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

CO2 emissions from blast furnaces should be reduced to curtail the impact of global warming. A promising solution is the low reducing agent rate (RAR) operation of blast furnaces. Char and ash particles derived from pulverized coal affect permeability in the furnace during low RAR operation. In our study, the combustion behavior and ash particle properties of pulverized coal during combustion were investigated. Char particles formed during combustion were sampled using a drop tube furnace, and then analyzed for their combustion ratio and ash particle properties. As a result, the combustion behavior of pulverized coal and properties of ash particles in raw coal were different by a coal type. Moreover, the combustibility of pulverized coal and the variation in ash particle properties during combustion were affected by the structure of the char particles.

DOI： 10.2355/isijinternational.55.1305

5-2-4 微粉炭ボイラにおける混炭燃焼時の灰付着特性評価に関する研究(Session 5-2 燃焼・熱利用II)

成川公史, 稲垣浩伸, 東祐一, 布目陽子, 植木保昭, 義家亮, 成瀬一郎

日本エネルギー学会大会講演要旨集 24 巻 ( 0 ) 頁： 192 - 193 2015年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In order to use the low-grade coals which are out of the power station requirement, blending of high-grade coals have been carried out in pulverized coal power station. However, for ash adhesion such as slagging and fouling, which is one of the important evaluation items of the coal, improvement of coal characteristics by the blending of coal does not become clear. It is necessary to establish the ash adhesion evaluation technology on the blending of the coal to reduce the cost of generation and increase availability of coal because most of low-grade coals are low ash fusion temperature. The purpose of this work is elucidation of ash deposition behavior at blended coal combustion. Ash deposits were collected on a heat transfer tube with an ash deposit experiment at some blend condition. In addition, we calculated the molten fraction of each blending condition by chemical equilibrium theory, using FactSage Ver.6.3.1 software.

DOI： 10.20550/jietaikaiyoushi.24.0_192

3-1-4 充填層ガス化炉における木質バイオマスのガス化挙動とタール低減(Session 3-1 ガス化I)

山田淳司, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 24 巻 ( 0 ) 頁： 70 - 71 2015年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

The purpose of this study is the gasification behavior of biomass in the packed-bed, carrying out gasification experiment (updraft and downdraft gasification). In this study, pellets of black pine (φ6.5 mm × 8.5 mm) were fed intermittently and using air as the gasification agent. In the gasification tests, the temperature distribution and the gas compositions in the gasifier were measured during gasification, and the amount of tar in the gasified gas was measured. In addition, the steam was injected in the gasifier in order to reduce the amount of tar.

DOI： 10.20550/jietaikaiyoushi.24.0_70

Effects of flue gas re-circulation and nitrogen contents in coal on NOX emissions under oxy-fuel coal combustion 査読有り

Ryo Yoshiie, Naoki Hikosaka, Yoko Nunome, Yasuaki Ueki, Ichiro Naruse

Fuel Processing Technology 136 巻頁： 106-111 2015年

Growth and gravity shedding of ash deposition layer in pulverized 査読有り

Naoki Sato, Dedy Eka Priyanto, Shunichiro Ueno, YoshiakiMatsuzawa, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

coal combustors Fuel Processing Technology 134 巻頁： 1-10 2015年

No.50 石炭の酸素吸着特性の解明(改質・処理・クリーン化(3)、構造・物性(1))

恩田雅臣, 植木保昭, 義家亮, 成瀬一郎, 長谷川雅一, 服部雅典, 稲垣浩伸

石炭科学会議発表論文集 52 巻 ( 0 ) 頁： 100 - 101 2015年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Coal has better stability of price and supply compared to other fossil fuels. In particular, subbituminous coal is expected effective utilization because that has low cost and long minable years. However, subbituminous coal has the self-ignition risk that caused by reacting with oxygen in the air. Therefore, an objective of this study is the elucidation of oxygen adsorption properties of coal. Experimental samples are some kinds of the subbituminous coal and bituminous coal. In the oxygen adsorption experiments between 356K and 476K in 50%N_2-50%O_2 atmosphere, the amount of oxygen adsorption on the coal was determined by thermobalance. As a result, it is found that the oxygen adsorption amount of bituminous coal is larger than those of subbituminous coal and oxygen adsorption amount is correlated with the carbon content of the coal.

DOI： 10.20550/jiesekitanronbun.52.0_100

No.28 微粉炭燃焼ボイラでの混炭燃焼時における灰付着挙動の解明(灰・微量元素(3))

森下順風, 義家亮, 植木保昭, 成瀬一郎

石炭科学会議発表論文集 52 巻 ( 0 ) 頁： 56 - 57 2015年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Ash deposition behaviors on heat transfer tubes under blended coal combustion condition have been becoming one of important issues associated to recent pulverized coal-fired boilers. In this study, ash deposition experiments, using two ash samples from bituminous and subbituminous coals, at two different temperatures, 1050℃ and 1250℃, were carried out and the mass of ash deposition was measured. Deposited ash samples were solidified by epoxy resin, and then analyzed by Scanning Electron Microscope (SEM) and Energy Dispersive X-ray spectrometer (EDX). In addition, fractions of liquid slag in ash were estimated by Thermo-equilibrium calculation to analyze ash melting characteristics.

DOI： 10.20550/jiesekitanronbun.52.0_56

No.26 バイオマス燃焼炉用灰付着低減表面改質材料に関する耐食性・灰付着性評価(重質油・バイオマス・コプロセッシング(4)、灰・微量元素(2))

佐々木頼明, 長沼宏, 野口学, 長洋光, 二宮善彦, CHEN Juan, 成瀬一郎, 義家亮, 植木保昭

石炭科学会議発表論文集 52 巻 ( 0 ) 頁： 52 - 53 2015年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Some ash particles of biomass fuels adhere to heat exchanger tube surfaces, which causes some troubles such as heat transfer inhibition, operational problems and hot corrosion in incineration plants. In this study, the authors have developed a surface treatment technology of tubes via a thermal spraying technology and a corrosion-resistant coating to reduce the ash deposition and the hot corrosion. Both the results of 'High-temperature Corrosion Test' and 'Electrochemical Impedance Spectroscopy (EIS)' are exhibited in this paper. The major conclusions are drawn as follows: Polarization conductance of specimens can be evaluated by means of equivalent circuits which are assumed on the interface between specimens and simulated ash. Moreover, it is clear that EIS is available for evaluating the corrosion resistance.

DOI： 10.20550/jiesekitanronbun.52.0_52

Mechanism of chromium oxidation by alkali and alkaline earth metals during municipal solid waste incineration

Hu Hongyun, Xu Zhang, Liu Huan, Chen Dunkui, Li Aijun, Yao Hong, Naruse Ichiro

PROCEEDINGS OF THE COMBUSTION INSTITUTE 35 巻 ( 2 ) 頁： 2397 - 2403 2015年

Mechanism of chromium oxidation by alkali and alkaline earth metals during municipal solid waste incineration 査読有り

Hongyun Hu, Zhang Xu, Huan Lin, Dunkui Chen, Aijun Li, Hong Yao, Ichiro Naruse

Proceedings of the Combustion Institute 35 巻頁： 2397-2403 2015年

Dual role of conditioner CaO in product distributions and sulfur transformation during sewage sludge pyrolysis

Liu Huan, Zhang Qiang, Hu Hongyun, Xiao Ruxi, Li Aijun, Qiao Yu, Yao Hong, Naruse Ichiro

FUEL 134 巻頁： 514 - 520 2014年10月

Counter-flow air gasification of woody biomass pellets in the auto-thermal packed bed reactor

Kihedu Joseph H., Yoshiie Ryo, Nunome Yoko, Ueki Yasuaki, Naruse Ichiro

FUEL 117 巻 ( PARTB ) 頁： 1242 - 1247 2014年1月

Mechanism of chromium Oxidation by alkali and alkaline earth metals during municipal solid waste incineration 査読有り

Hongyun Hu, Zhang Xu, Huan Liu, Dunkui Chen, Aijun Li, Hong Yao, Ichiro Naruse

Proceedings of the Combustion Institute 頁： 0 2014年

Using sorbents to control heavy metals and particulate matter emission during solid fuel combustion 査読有り

Hong Yao, Ichiro Naruse

Particuology 7 巻頁： 477-482 2014年

Dual role of conditioner CaO in product distributions and sulfur transformation during sewage sludge pyrolysis 査読有り

Huan Liu, Quang Zhang, Hongyun Hu, Ruxi Xiao, Aijun Li, Yu Qiao, Hong Yao, Ichiro Naruse

Fuel 134 巻頁： 514-520 2014年

Counter-flow air gasification of woody biomass pellets in the auto-thermal packed bed reactor 査読有り

Joseph H. Kihedu, Ryo Yoshiie, Yoko Nunome, Yasuaki Ueki, Ichiro Naruse

Fuel 117 巻頁： 1242-1247 2014年

Use of Soft Plasma Ionization Source at Evacuated Air Atmospheres in Time-of-Flight Mass Spectrometry to Suppress Fragmentation of Volatile Organic Compounds, 査読有り

Nunome Yoko, Park Hyunkook, Kodama Kenji, Ueki Yasuaki, Yoshiie Ryo, Lee Sang C., Kitagawa Kuniyuki, Wagatsuma Kazuaki, Naruse Ichiro

SPECTROSCOPY LETTERS 48 巻 ( 6 ) 頁： 436-440 2014年

Effect of Woody Biomass Addition on Coke Properties. 査読有り

Yasuaki Ueki, Yoko Nunome, Ryo Yoshiie, Ichiro Naruse, Yuko Nishibata and Sadayoshi Aizawa

ISIJ International 54 巻頁： 2454-2460 2014年

328 低品位炭の基礎燃焼挙動の評価(OS15-3 燃焼技術の基礎と応用研究(3),OS15 燃焼技術の基礎と応用研究)

義家亮, 前田康平, 布目陽子, 植木保昭, 成瀬一郎, 朴海洋, 秋山勝哉

東海支部総会講演会講演論文集 2014 巻 ( 0 ) 頁： _328 - 1_-_328-2_ 2014年

7-4-2 廃プラスチックスの熱分解時に生成するタールの分析(Session 7-4 リサイクル2)

鈴木敏夫, 義家亮, 植木保昭, 成瀬一郎

日本エネルギー学会大会講演要旨集 23 巻 ( 0 ) 頁： 276 - 277 2014年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Currently, one methods of recycling waste plastics include gasification. Gasification is carrying out thermal decomposition of the carbon resources, such as coal and the biomass for generating combustible gas. However, gasification will generate tar which is a mixture of polycyclic aromatic hydrocarbon. It generate as a by-product. If the amount of generation of tar can be reduced, failure of a gas engine can be prevented, and also generation gas can also be increased. So, in this research, by adding vapor as a gasifying agent, when gasifying a plastic, reduction of tar was aimed at and the gasification behavior was inquired using the Time of Flight Mass Spectrometry (TOFMS).

DOI： 10.20550/jietaikaiyoushi.23.0_276

7-2-1 廃棄物発電プラントにおける灰付着低減溶射材料の耐食性評価(Session 7-2 環境対策)

佐々木頼明, 長沼宏, 野口学, 長洋光, 二宮善彦, CHEN Juan, 成瀬一郎, 義家亮, 植木保昭

日本エネルギー学会大会講演要旨集 23 巻 ( 0 ) 頁： 260 - 261 2014年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Some ash particles of solid fuels adhere to heat exchanger tube surfaces, which causes some troubles such as heat transfer inhibition, operational problems and hot corrosion in incineration plants. The authors have developed a surface treatment technology of tubes via a thermal spraying technique (TST) to reduce the ash deposition. Both the results of 'High-temperature corrosion test' and 'Alternating current impedance testing' were exhibited in this paper. The corrosion resistance of TST was evaluated by measuring the polarization conductance and weight loss in corrosive conditions. As a result, it was clear that some materials of TST have high corrosion resistance and the AC impedance testing is available for evaluating the corrosion resistance.

DOI： 10.20550/jietaikaiyoushi.23.0_260

Counter-flow air gasification of woody biomass pellets in the auto-thermal packed bed reactor 査読有り

Joseph H. Kihedu, Ryo Yoshiie, Yoko Nunome, Yasuaki Ueki, Ichiro Naruse

Fuel 117 巻頁： 1242-1247 2014年

Effect of Woody Biomass Addition on Coke Properties. 査読有り

Yasuaki Ueki, Yoko Nunome, Ryo Yoshiie, Ichiro Naruse, Yuko Nishibata, Sadayoshi Aizawa

ISIJ International 54 巻頁： 2454-2460 2014年

Effect of Woody Biomass Addition on Coke Properties

Ueki Yasuaki, Nunome Yoko, Yoshiie Ryo, Naruse Ichiro, Nishibata Yuko, Aizawa Sadayoshi

ISIJ INTERNATIONAL 54 巻 ( 11 ) 頁： 2454 - 2460 2014年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

The price of caking coal, which is used in the production of metallurgical coke, has risen in recent years. Also of concern is the amount of CO2 emitted from steel industries, comprising approximately 15% of total CO2 emissions in Japan. Therefore, CO2 emissions from the ironmaking process should be reduced to avoid global warming. In this work, fundamental research is conducted on the effect of adding woody biomass to the properties of coke, with the aim of possibly using woody biomass, which is carbon neutral, as a raw material in coke-making. Experimental results showed that the connectivity between coal particles in the coke sample during carbonization and coke strength drastically decrease by adding woody biomass to caking coal. However, the coke properties of the coke sample with added woody biomass could be improved by removing the partly volatile matter of woody biomass before mixing with caking coal, and as a result, the possibility of using woody biomass as a raw material for coke-making with prior carbonization at temperatures of more than 500°C was found.

DOI： 10.2355/isijinternational.54.2454

No.59 燃料ガス中微量ヒ素、およびセレンによるSOFCアノード劣化反応の評価(ガス化・燃焼・液化(2))

Dual role of conditioner CaO in product distributions and sulfur transformation during sewage sludge pyrolysis 査読有り

Huan Liu, Quang Zhang, Hongyun Hu, Ruxi Xiao, Aijun Li, Yu Qiao, Hong Yao, Ichiro Naruse

Fuel 134 巻頁： 514-520 2014年

Dramatic Response of S-1 Administration to Chemorefractory Advanced Thymic Cancer.

Kaira K, Naruse I, Imai H, Sunaga N, Hisada T, Motegi M, Asao T, Yamada M

Chemotherapy 60 巻 ( 5-6 ) 頁： 356 - 9 2014年

Mechanism of chromium Oxidation by alkali and alkaline earth metals during municipal solid waste incineration 査読有り

Hongyun Hu, Zhang Xu, Huan Liu, Dunkui Chen, Aijun Li, Hong Yao, Ichiro Naruse

Proceedings of the Combustion Institute 頁： 0 2014年

藤田亮平, 義家亮, 成瀬一郎, 植木保昭, 倉本浩司

石炭科学会議発表論文集 51 巻 ( 0 ) 頁： 118 - 119 2014年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Recently, the efficient use of coal has been increasingly developed as technologies against global warming issues. One of the solutions is a triple combined cycle system with coal gasification, such as IGFC (Integrated coal Gasification Fuel Cell combined cycle). SOFC (Solid Oxide Fuel Cell) is a key device in the system. however, trace elements in syn gas damage anodes of the SOFC. In this study, thermodynamics equilibrium calculation and power generation experiment are conducted to elucidate the reaction between anode materials and trace elements, such as As and Se.

DOI： 10.20550/jiesekitanronbun.51.0_118

No.4 コークス燃焼過程における灰粒子挙動の解明(改質・処理・クリーン化(1)、熱分解・コークス(1))

若田俊輔, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 51 巻 ( 0 ) 頁： 8 - 9 2014年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

One of the important purposes of the coke in the blast furnace is the spacer to ensure the gas and liquid permeability. In other hands, Ash particles in coke became slags inside the furnace and these are one of the causes that significantly worsen the permeability. in this study, combustion experiments of coke were conducted and ash particles in the coke samples were analyzed by using SEM/EDX in order to clarify ash particles behavior during combustion of coke.

DOI： 10.20550/jiesekitanronbun.51.0_8

Use of Soft Plasma Ionization Source at Evacuated Air Atmospheres in Time-of-Flight Mass Spectrometry to Suppress Fragmentation of Volatile Organic Compounds, 査読有り

Nunome Yoko, Park Hyunkook, Kodama Kenji, Ueki Yasuaki, Yoshiie Ryo, Lee Sang C, Kitagawa Kuniyuki, Wagatsuma Kazuaki, Naruse Ichiro

SPECTROSCOPY LETTERS 48 巻 ( 6 ) 頁： 436-440 2014年

Using sorbents to control heavy metals and particulate matter emission during solid fuel combustion 査読有り

Hong Yao, Ichiro Naruse

Particuology 7 巻頁： 477-482 2014年

Emissions of particles and trace elements from coal gasification

Yoshiie Ryo, Taya Yukihiro, Ichiyanagi Taro, Ueki Yasuaki, Naruse Ichiro

FUEL 108 巻頁： 67 - 72 2013年6月

Control of ash deposition in solid fuel fired boiler

Naganuma Hiroshi, Ikeda Nobuya, Ito Tadashi, Satake Hideshi, Matsuura Mikio, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

FUEL PROCESSING TECHNOLOGY 105 巻頁： 77 - 81 2013年1月

Emissions of particles and trace elements from coal gasification 査読有り

Ryo YOSHIIE, Yukihiro TAYA, Taro ICHIYANAGI, Yasuaki UEKI, Ichiro NARUSE

Fuel 108 巻頁： 67-72 2013年

Reduction mechanisms of ash deposition in coal and/or biomass combustion boilers 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Tadashi Ito, Mikio Matsuura, Yoko Nunome, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel 106 巻頁： 303-309 2013年

Reaction behavior during heating biomass materials and iron oxide composites 査読有り

Y.Ueki, R.yoshiie, I.Naruse, K.-i.Ohno, T.Maeda, K.Nishioka and M.Shimizu

FUEL 104 巻頁： 58-61 2013年

Contribution of Volatile Interactions During Co-Gasification of Biomass with Coal 査読有り

Joseph H. Kihedu, Ryo Yoshiie, Yoko Nunome, Yasuaki Ueki and Ichiro Naruse

Journal of Technology Innovations in Renewable Energy 2 巻 ( 1 ) 頁： 39-46 2013年

Reduction mechanisms of ash deposition in coal and/or biomass combustion boilers 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Tadashi Ito, Mikio Matsuura, Yoko Nunome, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel 106 巻頁： 303–309 2013年

Control of ash deposition in solid fuel fired boiler 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Tadashi Ito, Mikio Matsuura, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel Processing Technology 105 巻頁： 77-81 2013年

Effects of coal types on ash fragmentation and coalescence behaviors in pulverized coal combustion 査読有り

Ryo YOSHIIE, Takuro TSUZUKI, Yasuaki UEKI, Yoko NUNOME, Ichiro NARUSE, Naoki SATO, Takamasa ITO, Yoshiaki MATSUZAWA, Toshiyuki SUDA

Proceedings of the Combustion Institute 34 巻 ( 2 ) 頁： 2895-2902 2013年

313 廃棄物系粒子材料による排ガス中水銀吸収(大気環境保全・改善技術(1))

義家亮, 澤浩明, 布目陽子, 植木保昭, 成瀬一郎

環境工学総合シンポジウム講演論文集 2013 巻 ( 0 ) 頁： 214 - 217 2013年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Atmospheric mercury emissions from coal combustion and waste incineration processes have been drawing attention as global pollutant. It has been reported that wet desulfurization process and/or absorbing bed of activated carbon, which are generally installed in domestic coal fired power plants, can control mercury emissions. However, considering the growing diversity of fuels including waste products and the overseas market development, a low-cost dry process for mercury removal from stack gas needs to be developed in near future. Objective in this study is to utilize particle materials derived from waste products to capture gaseous mercury. Mercury absorption experiments have bee n conducted using some mineral particles. As a result, calcined paper sludge showed the high performance for mercury absorption.

DOI： 10.1299/jsmeenv.2013.23.214

318 微粉炭のOxy-fuel燃焼場における窒素酸化物排出特性(OS5-4 燃焼技術の基礎と応用研究(4),OS5 燃焼技術の基礎と応用研究)

義家亮, 彦坂直樹, 布目陽子, 植木保昭, 成瀬一郎

東海支部総会講演会講演論文集 2013 巻 ( 0 ) 頁： 185 - 186 2013年

316 ソフトプラズマイオン化飛行時間型質量分析法を用いたばい煙中有機エアロゾルの直接分析(大気環境保全・改善技術(2))

布目陽子, 児玉憲治, 朴賢國, 植木保昭, 義家亮, Lee S.C., 北川邦行, 成瀬一郎

環境工学総合シンポジウム講演論文集 2013 巻 ( 0 ) 頁： 222 - 223 2013年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Nano-sized organic aerosols, nanoparticles (d_p < 50 nm), in the atmosphere have attracted a lot of attention in recent years because of adverse effects on human health. A new system combining a soft plasma ionization (SPI) source with a time-of-flight mass spectrometer (TOFMS) has been successfully developed and applied to direct and on-line analysis of smoke generated during combustion. The mass spectra of smoke were obtained in conjunction with the effects of gas species (air, Ar and He), pressure (1600-2600 Pa) and current (10-130 mA) of the SPI discharge. To investigate the ionization mechanism of the SPI, we also have studied spontaneous emission spectra from the SPI source. Considering the results from mass and emission s pectral data, we suppose an ionization mechanism of the SPI which can efficiently produce excitation ofN_2 in the presence o f the noble gas, leading to promote ionization of sample.

DOI： 10.1299/jsmeenv.2013.23.222

Contribution of Volatile Interactions During Co-Gasification of Biomass with Coal 査読有り

Joseph H. Kihedu, Ryo Yoshiie, Yoko Nunome, Yasuaki Ueki, Ichiro Naruse

Journal of Technology Innovations in Renewable Energy 2 巻 ( 1 ) 頁： 39-46 2013年

Emissions of particles and trace elements from coal gasification 査読有り

Ryo YOSHIIE, Yukihiro TAYA, Taro ICHIYANAGI, Yasuaki UEKI, Ichiro NARUSE

Fuel 108 巻頁： 67-72 2013年

Effects of coal types on ash fragmentation and coalescence behaviors in pulverized coal combustion

Yoshiie Ryo, Tsuzuki Takuro, Ueki Yasuaki, Nunome Yoko, Naruse Ichiro, Sato Naoki, Ito Takamasa, Matsuzawa Yoshiaki, Suda Toshiyuki

PROCEEDINGS OF THE COMBUSTION INSTITUTE 34 巻 ( 2 ) 頁： 2895 - 2902 2013年

Effects of coal types on ash fragmentation and coalescence behaviors in pulverized coal combustion 査読有り

Ryo YOSHIIE, Takuro TSUZUKI, Yasuaki UEKI, Yoko NUNOME, Ichiro NARUSE, Naoki SATO, Takamasa ITO, Yoshiaki MATSUZAWA, Toshiyuki SUDA

Proceedings of the Combustion Institute 34 巻 ( 2 ) 頁： 2895-2902 2013年

Control of ash deposition on the surface of heat transfer tube

Naruse I.

2013 International Symposium on Micro-NanoMechatronics and Human Science, MHS 2013 2013年

Control of Ash Deposition on the Surface of Heat Transfer Tube

Naruse Ichiro, Nunome Yoko, Ueki Yasuaki, Azuma Yuichi, Iwai Takanori, Yoshiie Ryo, Naganuma Hiroshi

2013 INTERNATIONAL SYMPOSIUM ON MICRO-NANOMECHATRONICS AND HUMAN SCIENCE (MHS) 2013年

Control of ash deposition in solid fuel fired boiler 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Tadashi Ito, Mikio Matsuura, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel Processing Technology 105 巻頁： 77-81 2013年

No.26 微粉炭燃焼ボイラにおける混炭時の灰付着特性の解明

東祐一, 布目陽子, 植木保昭, 義家亮, 成瀬一郎, 成川公史, 稲垣浩伸

石炭科学会議発表論文集 50 巻 ( 0 ) 頁： 52 - 53 2013年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In pulverized coal combustion boiler, ash deposits such as slagging and fouling prevent heat transfer. On the other hand, a reserve of high lank coal is limited. So co-combustion of low lank coal, that is inexpensive, and high lank coal has been carried out in pulverized coal combustion boiler. Generally, low lank coal includes ash of low melting point. However, in this situation, ash deposition behavior has not been clarified. The purpose of this work is elucidation of ash deposition behavior during co-combustion in pulverized coal combustion boiler. Ash deposits were collected on a heat transfer tube with an ash deposit experiment at some blend condition. Ash particles near the adhesion interface were analyzed about element distribution by a Scanning Electron Microscope and an Energy Dispersive X-ray (SEM/EDX). And ash particles are also analyzed about composition and particle size distribution by a Computer Control Scanning Electron Microscope (CCSEM). We calculated the molten fraction of each mix condition ash by chemical equilibrium theory, using FactSage Ver.6.3.1 software.

DOI： 10.20550/jiesekitanronbun.50.0_52

No.28 流動層を用いた石炭のOxy-fuel燃焼特性の解明

杉浦幸樹, 布目陽子, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 50 巻 ( 0 ) 頁： 56 - 57 2013年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Recently, oxy-fuel coal combustion has drawn attention as useful technique to achieve carbon dioxide capture and storage (CCS). This is the technique that enriches CO_2 in exhaust gas by the flue gas recirculation with additional pure O_2 to combustion atmosphere, which makes easy to capture CO_2. 0n the other hand, bubbling fluidized bed coal combustion has advantages of direct sulfur capturing in furnace by adding desulfurizing agents to bed material and decreasing of thermal NO_x as a result of low combustion temperature. However, oxy-fuel combustion behavior of coal in a bubbling fluidized bed is still unclear. In this study, we conducted the coal burning experiment under CO_2/O_2 using bubbling fluidized bed and compared oxy-fuel combustion behavior with air combustion behavior of coal. In addition, three coal samples having different nitrogen contents were tested to estimate the effect of raw coal properties on oxy-fuel combustion behaviors.

DOI： 10.20550/jiesekitanronbun.50.0_56

No.27 模擬石炭を用いた燃焼過程灰粒子の生成凝集挙動の解明

西村仁志, 布目陽子, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 50 巻 ( 0 ) 頁： 54 - 55 2013年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In general, the use of coal having different physical properties from those of design coal in a pulverized coal combustion plant causes ash deposit troubles, such as fouling and slagging. However, from the viewpoint of utilization of low rank coals, flexibilities for various coal types as fuel are going to be required in pulverized coal fired boilers before long. Then, it is important to preliminarily predict mineral particle behaviors in coal combustion process. In this study, their behaviors are studied by use of artificial coal samples which contains included minerals and excluded minerals. Coal samples are burned in a drop tube furnace to sample particles in different conversion ratio and residence time. Then included and excluded minerals are analyzed and classified in particles by CCSEM

DOI： 10.20550/jiesekitanronbun.50.0_54

Reaction behavior during heating biomass materials and iron oxide composites 査読有り

Y.Ueki, R.yoshiie, I.Naruse, K.-i.Ohno, T.Maeda, K.Nishioka, M.Shimizu

FUEL 104 巻頁： 58-61 2013年

Reduction mechanisms of ash deposition in coal and/or biomass combustion boilers 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Tadashi Ito, Mikio Matsuura, Yoko Nunome, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel 106 巻頁： 303-309 2013年

Reduction mechanisms of ash deposition in coal and/or biomass combustion boilers 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Tadashi Ito, Mikio Matsuura, Yoko Nunome, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Fuel 106 巻頁： 303–309 2013年

石炭燃焼排ガス中ガス状ホウ素の測定法開発

野田直希, 伊藤茂男, 植木保昭, 義家亮, 成瀬一郎

化学工学論文集 = Kagaku kogaku ronbunshu 38 巻 ( 3 ) 頁： 183 - 188 2012年7月

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

ホウ素化合物は一般的に揮発性が高いので，石炭燃焼排ガス中では，その一部がガス相へ移行する．しかし，ガス相への移行割合は炭種に依存し，その挙動は複雑である．よって，石炭燃焼場におけるホウ素の挙動を正確に解明するためには，ガス状ホウ素を高精度に測定する必要があり，本報では，石炭燃焼場を対象としたガス状ホウ素の測定法を開発した．実験は，ガス状ホウ素発生装置を試作し，模擬石炭燃焼排ガスや実際の石炭燃焼排ガスを用いて，吸収液の選定，配管材料などのサンプリング条件の最適化，ならびに確立した測定法の精度確認を行った．主な結果として，ガス状ホウ素の測定に最適な吸収液は硝酸酸性の過酸化水素水であり，また，ステンレス製のプローブやアルミナバインダを含むシリカ製フィルタ紙はガス状ホウ素を吸着するため，サンプリング流路や吸収液用のインピンジャーの最適な材質は石英ガラスあるいは四ふっ化エチレン樹脂であることならびにサンプリング流路は130℃以上に保温することにより高精度な測定が可能であることなどを明らかにした．

DOI： 10.1252/kakoronbunshu.38.183

203 廃棄物系炭化物による元素水銀蒸気の吸着特性(安定化・無害化,循環型廃棄物処理技術)

石炭燃焼排ガス中ガス状ホウ素の測定法開発査読有り

野田直希，伊藤茂男，植木保昭，義家亮，成瀬一郎

化学工学論文集 38 巻 ( 3 ) 頁： 183-188 2012年

膜分離を伴う溶媒抽出による廃潤滑油の再生処理査読有り

義家亮，植木保昭，三輪高裕，成瀬一郎

日本機械学会論文集B編 78 巻 ( 789 ) 頁： 1048-1052 2012年

Effects of coal types on ash fragmentation and coalescence behaviors in pulverized coal combustion 査読有り

Ryo Yoshiie, Takuro Tsuzuki, Yasuaki Ueki, Yoko Nunome, Ichiro Naruse, Naoki Sato, Takamasa Ito, Yoshiaki Matsuzawa, Toshiyuki Suda

Proceedings of Combustion Institute 34 巻頁： 2895-2902 2012年

Volatilization characteristics of boron compounds during coal combustion 査読有り

Naoki Noda, Shigeo Ito, Yoko Nunome, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Proceedings of Combustion Institute 34 巻頁： 2831-2838 2012年

Conversion synergies during steam co-gasification of lingno-cellulosic simulated biomass with coal 査読有り

Kihedu J.H, Yoshiie R, Nunome Y, Ueki Y, Naruse I

Jornal of Sustainable Bioenergy Systems 2 巻 ( 4 ) 頁： 97-103 2012年

植木保昭, 澤浩明, 義家亮, 成瀬一郎

環境工学総合シンポジウム講演論文集 2012 巻 ( 0 ) 頁： 131 - 132 2012年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Coal and solid fuels derived from industrial wastes sometimes contain a small amount of mercury compounds. In conmbustion processes, gaseous elemental mercury passes through the stack and releases into the atmosphere. Mercury emissions in the combustion processes have been focused as one of upcoming air pollutants. In this work, it is the purpose to use wastes (sewage sludge, woody biomass and municipal waste) as an adsorbent of elemental mercury. We conducted mercury adsorption experiment used carbonized sewage sludge, carbonized biomass and carbonized municipal waste as adsorbents. As a result, the mercury adsorption ratio of carbonized municipal waste was the largest.

DOI： 10.1299/jsmeenv.2012.22.131

403 微粉炭燃焼過程における灰粒子挙動の炭種依存性(OS6-1 燃焼現象の解明と高度利用技術1,OS6 燃焼現象の解明と高度利用技術)

義家亮, 都築拓朗, 植木保昭, 成瀬一郎, 佐藤直樹, 松澤克明, 伊藤隆政, 須田俊之

東海支部総会講演会講演論文集 2012 巻 ( 0 ) 頁： _403 - 1_-_403-2_ 2012年

Conversion synergies during steam co-gasification of lingno-cellulosic simulated biomass with coal 査読有り

Kihedu J.H, Yoshiie R, Nunome Y, Ueki Y, Naruse I

Jornal of Sustainable Bioenergy Systems 2 巻 ( 4 ) 頁： 97-103 2012年

Effects of coal types on ash fragmentation and coalescence behaviors in pulverized coal combustion 査読有り

Ryo Yoshiie, Takuro Tsuzuki, Yasuaki Ueki, Yoko Nunome, Ichiro Naruse, Naoki Sato, Takamasa Ito, Yoshiaki Matsuzawa, Toshiyuki Suda

Proceedings of Combustion Institute 34 巻頁： 2895-2902 2012年

Development of a Method for Measuring Gaseous Boron in Coal Combustion Flue Gas

Noda Naoki, Ito Shigeo, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

KAGAKU KOGAKU RONBUNSHU 38 巻 ( 3 ) 頁： 183 - 188 2012年

No.21 石炭燃焼場からの窒素酸化物放出に対する排ガス再循環の影響(ガス化・燃焼・液化(2))

彦坂直樹, 布目陽子, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 49 巻 ( 0 ) 頁： 42 - 43 2012年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Currently, it becomes increasingly necessary to decrease CO_2 emissions from fossil fuel combustion processes, because they are major contributors to the global warming. Oxy-fuel coal combustion has drawn attention as useful technique to achieve carbon dioxide capture and storage (CCS). This is the technique that enriches CO_2 in exhaust gas by the flue gas recirculation with additional pure O_2 to combustion atmosphere, which makes easy to capture and liquidize CO_2 downstream. However, there have been few reports about behaviors of various environmental pollutants in oxy-fuel coal combustion with the flue gas recirculation. In this study, we experimentally estimated effects of NO and N_2O recirculation with CO_2 by a drop tube furnace equipment. In addition, we simulated NO and N_2O formations under oxy-fuel coal combustion condition by elementary reaction analysis, and then we discussed mechanism for the formation of NOX.

DOI： 10.20550/jiesekitanronbun.49.0_42

Reduction of Ash Deposition in Pulverized Coal Fired Boilers

Naruse I., Yoshiie R., Ueki Y., Matsuura M., Naganuma H.

CLEANER COMBUSTION AND SUSTAINABLE WORLD 頁： 517 - 522 2012年

Volatilization characteristics of boron compounds during coal combustion 査読有り

Naoki Noda, Shigeo Ito, Yoko Nunome, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Proceedings of Combustion Institute 34 巻頁： 2831-2838 2012年

Slagging Behavior of Upgraded Brown Coal and Bituminous coal in 145MW Practical Coal Combustion Boiler

Akiyama Katsuya, Pak Haeyang, Takubo Yoji, Tada Toshiya, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

CLEANER COMBUSTION AND SUSTAINABLE WORLD 頁： 77 - 82 2012年

石炭燃焼排ガス中ガス状ホウ素の測定法開発査読有り

野田直希, 伊藤茂男, 植木保昭, 義家亮, 成瀬一郎

化学工学論文集 38 巻 ( 3 ) 頁： 183-188 2012年

膜分離を伴う溶媒抽出による廃潤滑油の再生処理査読有り

義家亮, 植木保昭, 三輪高裕, 成瀬一郎

日本機械学会論文集B編 78 巻 ( 789 ) 頁： 1048-1052 2012年

Effect of MgO addition to upgraded brown coal on ash-deposition behavior during combustion

Akiyama Katsuya, Pak Haeyang, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

FUEL 90 巻 ( 11 ) 頁： 3230 - 3236 2011年11月

微粉炭燃焼場における灰付着挙動の解明とその低減

成瀬一郎, 義家亮, 植木保昭, 長沼宏

ボイラ研究 ( 369 ) 頁： 8 - 15 2011年10月

Normal location of thumb/big toe may be related to programmed cell death in the preaxial area of embryonic limb.

Kimura S, Yamada S, Naruse I

Anatomical record (Hoboken, N.J. : 2007) 294 巻 ( 8 ) 頁： 1352 - 9 2011年8月

Ash deposition behavior of upgraded brown coal in pulverized coal combustion boiler

Akiyama Katsuya, Pak Haeyang, Takubo Yoji, Tada Toshiya, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

FUEL PROCESSING TECHNOLOGY 92 巻 ( 7 ) 頁： 1355 - 1361 2011年7月

Gas-Phase Reaction of NOX Formation in Oxyfuel Coal Combustion at Low Temperature

Yoshiie Ryo, Kawamoto Takuya, Hasegawa Daisuke, Ueki Yasuaki, Naruse Ichiro

ENERGY & FUELS 25 巻 ( 6 ) 頁： 2481 - 2486 2011年6月

Gasification characteristics of woody biomass in the packed bed reactor 査読有り

Yasuaki Ueki, Takashi Torigoe, Hirofumi Ono, Ryo Yoshiie, Joseph H. Kihedu, Ichiro Naruse

Proceedings of the Combustion Institute 33 巻 ( 2 ) 頁： 1795-1800 2011年

Gas-Phase Reaction of NOX Formation in Oxyfuel Coal Combustion at Low Temperature 査読有り

Ryo YOSHIIE, Takuya KAQAMOTO, Daisuke HASEGAWA, Yasuaki UEKI, Ichiro NARUSE

2011 ENERGY & FUELS 25 巻頁： 2481-2486 2011年

202 廃棄物由来の炭素系材料による酸化鉄の還元特性(循環型廃棄物処理技術(1))

土井淳生, 植木保昭, 義家亮, 成瀬一郎

環境工学総合シンポジウム講演論文集 2011 巻 ( 0 ) 頁： 109 - 111 2011年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

It is important for environmental protection to use waste materials effectively. In this work, we conducted fundamental researches on the application of carbonaceous materials from waste as a reductant for iron oxide. Carbonaceous materials from waste (carbonized municipal waste, carbonized biomass, canbonized sewage sludge) were mixtured with hematite reagent The mixtures were heated up at the temperatures of 1000-1200℃ in N_2 gas by using thermo gravimetric analysis (TG) or batch furnace. In the reduction experiments, weight changes and concentrations of generated gases from samples were measured by electric balance and micro gas chromatograph, respectively. Weight changes ratio was calculated to compare reaction rate and reactive character.

DOI： 10.1299/jsmeenv.2011.21.109

659 二酸化炭素および水蒸気による木質バイオマスのガス化特性(OS6-2 燃焼技術の高度化と現象解明(2),OS6 燃焼技術の高度化と現象解明)

植木保昭, 秋本浩孝, 義家亮, 成瀬一郎

東海支部総会講演会講演論文集 2011 巻 ( 0 ) 頁： _659 - 1_-_659-2_ 2011年

658 排ガス再循環をともなう石炭燃焼における窒素酸化物生成(OS6-2 燃焼技術の高度化と現象解明(2),OS6 燃焼技術の高度化と現象解明)

義家亮, 河本卓也, 植木保昭, 成瀬一郎

東海支部総会講演会講演論文集 2011 巻 ( 0 ) 頁： _658 - 1_-_658-2_ 2011年

3-7-2 石炭・バイオマスの水蒸気・CO_2共ガス化(3-7 ガス化1,Session3 バイオマス等,研究発表)

キヘドゥジョセフ, 義家亮, 成瀬一郎, 植木保昭

日本エネルギー学会大会講演要旨集 20 巻 ( 0 ) 頁： 110 - 111 2011年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Improved steam co-gasification characteristics of coal and cedar (biomass) blend was observed against additive average behavior for separate gasification of coal and biomass. Similar effect was less pronounced during CO_2 co-gasification. Blends gasified to 800℃ reveal hastened pore development and physical cracking on coal particles. Co-pyrolysis char has higher H/C ratio and exhibits higher reactivity than chars mixed after separate pyrolysis of coal and cedar.

DOI： 10.20550/jietaikaiyoushi.20.0_110

204 膜分離を伴う溶媒抽出による廃潤滑油の再生処理(循環型廃棄物処理技術(2))

義家亮, 植木保昭, 三輪高裕, 成瀬一郎

環境工学総合シンポジウム講演論文集 2011 巻 ( 0 ) 頁： 115 - 118 2011年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

A novel low temperature process to recover base oil from waste lubricating oil is proposed in this study, which is based on solvent extraction with membrane. In this process, organic solvent is circulated in a closed loop, representing a resource saving technology. Residue consists of only impurities in waste lubricating oil, such as suspended particles, aqueous droplets, soot and tar, representing a waste reducing technology. This process includes a fractional distillation, too, but it is for separating out organic solvent from oils. Then, temperature for fractional distillation is lower than 100 degC, representing energy saving technology. Rubber film is utilized as membrane in this process. Rubber film has swelling property when it is immersed in organic solvent. Expanded polymer network structure works as filter to separate impurities from oil dissolved in solvent. Objective in this paper is to verify the feasibility of solvent extraction with rubber membrane to recover base oil from waste lubricating oil. Effect of extraction period, solvent volume and extraction temperature on both yield and quality of the extracted oil was experimentally estimated. Quality of extracted oil was evaluated through measurement of sulfur, carbon residue and carbon number distribution in oil molecules.

DOI： 10.1299/jsmeenv.2011.21.115

Gas-Phase Reaction of NOX Formation in Oxyfuel Coal Combustion at Low Temperature 査読有り

Ryo YOSHIIE, Takuya KAQAMOTO, Daisuke HASEGAWA, Yasuaki UEKI, Ichiro NARUSE

2011 ENERGY & FUELS 25 巻頁： 2481-2486 2011年

No.53 炭種に依存した石炭燃焼過程における無機成分粒子挙動の解明(研究発表)

都築拓朗, 植木保昭, 義家亮, 成瀬一郎, 佐藤直樹, 松澤克明, 伊藤隆政, 須田俊之

石炭科学会議発表論文集 48 巻 ( 0 ) 頁： 106 - 107 2011年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

From a standpoint of utilization of low rank coals, flexibility to a variety of coal types as fuel is increasingly needed in pulverized coal fired boilers. If coal which physical properties are far from those of the design coal is used in the boiler, ash deposit troubles called fouling and slagging become much more severe. Therefore mineral particle behaviors in coal combustion are studied for different types of coal samples in this study. Coals having low, middle and high melting points of ash are burned in a drop tube furnace to sample char particle in different conversion ratios. Then included and excluded minerals are analyzed in char particles via CCSEM.

DOI： 10.20550/jiesekitanronbun.48.0_106

No.18 低融点灰を有する低品位炭の微粉炭ボイラ利用技術の開発(研究発表)

朴海洋, 秋山勝哉, 田窪陽司, 多田俊哉, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 48 巻 ( 0 ) 頁： 36 - 37 2011年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

The main purpose of this study is to develop the combustion technology for low-rank coals with low melting point of ash. Various kinds of coals with different melting temperatures and ash compositions were used as the samples for the chemical equilibrium calculations and the pilot-scale combustion experiment. It was confirmed that the deposition fraction of ash obtained by the experiment rapidly increased when the molten slag fraction obtained by the calculation became over 60%. Finally, the combustion tests of the blended coal of low rank coal with bituminous coal were conducted using a 145 MW pulverized coal-fired boiler. The blending mass ratio of low rank coal to bituminous coal was decided, using the coal blending method developed. As a result, the mass of the deposited ash for the blended coal did not greatly increase and no slagging problems occurred for 11 days of boiler operation.

DOI： 10.20550/jiesekitanronbun.48.0_36

Gasification characteristics of woody biomass in the packed bed reactor

Ueki Yasuaki, Torigoe Takashi, Ono Hirofumi, Yoshiie Ryo, Kihedu Joseph H., Naruse Ichiro

PROCEEDINGS OF THE COMBUSTION INSTITUTE 33 巻 ( 2 ) 頁： 1795 - 1800 2011年

Gasification characteristics of woody biomass in the packed bed reactor 査読有り

Yasuaki Ueki, Takashi Torigoe, Hirofumi Ono, Ryo Yoshiie, Joseph H. Kihedu, Ichiro Naruse

Proceedings of the Combustion Institute 33 巻 ( 2 ) 頁： 1795-1800 2011年

Control of Ash Deposition in Pulverized Coal Combustor

Naruse Ichiro, Yoshiie Ryo, Matsuura Mikio, UEKI Yasuaki, NAGANUMA Hiroshi, ITO Tadashi

Journal of chemical engineering of Japan 43 巻 ( 8 ) 頁： 872 - 879 2010年12月

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

A thermal spraying technique was adopted to change the surface properties of heat exchanger tubes in pulverized coal fired boilers in order to reduce ash deposition. Initially, four types of coal ash with different melting points were tested as samples for ash deposition experiments. As a result, ash particles with higher fouling factor selectively adhered on the tube surface. Even for the ash particles with lower melting point, Ni alloy as a thermal spraying material played an effective role in reducing deposition. Ni alloy can reduce the ash deposition by limiting formation of molten slag at high temperature. In addition, long-term ash adhesion experiments were also carried out using a precise tension tester at high temperature. The effectiveness of the Ni alloy was also proved after long term contact between an ash pellet and a rod thermally sprayed Ni alloy at high temperature. This is because the Ni alloy can control the diffusion of Fe compounds from the tube rod to the ash deposition layer.

DOI： 10.1252/jcej.10we129

Effect of MgO additive on the reduction of ash deposition of upgraded brown coal

Akiyama K.

27th Annual International Pittsburgh Coal Conference 2010, PCC 2010 3 巻頁： 1955 - 1967 2010年12月

Effects of various gaseous agents on gasification of woody biomass

Ueki Y.

International Conference on Thermal Treatment Technologies and Hazardous Waste Combustors 2010 頁： 151 - 168 2010年9月

Ash Deposition Behavior of Upgraded Brown Coal and Bituminous Coal

Akiyama Katsuya, Pak Haeyang, Tada Toshiya, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

ENERGY & FUELS 24 巻 ( 8 ) 頁： 4138 - 4143 2010年8月

Gaseous mercury oxidation behavior in homogeneous reaction with chlorine compounds 査読有り

Ichiro Naruse, Ryo Yoshiie, Tsutomu Kameshima, Tsuyoshi Takuwa

Journal of Material Cycles and Waste Management 12 巻 ( 2 ) 頁： E1090101 2010年6月

Ash Deposition Behavior of Upgraded Brown Coal and Bituminous Coal 査読有り

Katsuya Akiyama, Haeyang Pak, Toshiya Tada, Yasuaki Ueki, Ryo Yoshiie, and Ichiro Naruse

Energy Fuels 24 巻頁： 4138-4143 2010年6月

Hot Gas Desulfurization and Regeneration Characteristics with Molten Alkali Carbonates 査読有り

S.Raharjo, U.Yasuaki, R.Yoshiie and I. Naruse

International Journal of Chemical Engineering and Applications 1 巻 ( 1 ) 頁： 96-102 2010年6月

Ash Deposition Behavior of Upgraded Brown Coal and Bituminous Coal 査読有り

Katsuya Akiyama, Haeyang Pak, Toshiya Tada, Yasuaki Ueki, Ryo Yoshiie, Ichiro Naruse

Energy Fuels 24 巻頁： 4138-4143 2010年6月

Gaseous mercury oxidation behavior in homogeneous reaction with chlorine compounds 査読有り

Ichiro Naruse, Ryo Yoshiie, Tsutomu Kameshima, Tsuyoshi Takuwa

Journal of Material Cycles and Waste Management 12 巻 ( 2 ) 頁： E1090101 2010年6月

Hot Gas Desulfurization and Regeneration Characteristics with Molten Alkali Carbonates 査読有り

S.Raharjo, U.Yasuaki, R.Yoshiie, I. Naruse

International Journal of Chemical Engineering and Applications 1 巻 ( 1 ) 頁： 96-102 2010年6月

Gaseous mercury oxidation behavior in homogeneous reaction with chlorine compounds

Naruse Ichiro, Yoshiie Ryo, Kameshima Tsutomu, Takuwa Tsuyoshi

JOURNAL OF MATERIAL CYCLES AND WASTE MANAGEMENT 12 巻 ( 2 ) 頁： 154 - 160 2010年6月

Reaction Characteristic of Woody Biomass with CO2 and H2O

Naruse Ichiro, Ueki Yasuaki, Isayama Tsutomu, Shinba Takanori, Kihedu Joseph H., Yoshiie Ryo

TETSU TO HAGANE-JOURNAL OF THE IRON AND STEEL INSTITUTE OF JAPAN 96 巻 ( 4 ) 頁： B10 - B15 2010年4月

Birth defects caused by mutations in human GLI3 and mouse Gli3 genes.

Naruse I, Ueta E, Sumino Y, Ogawa M, Ishikiriyama S

Congenital anomalies 50 巻 ( 1 ) 頁： 1 - 7 2010年3月

Gender-dependent differences in the incidence of ochratoxin A-induced neural tube defects in the Pdn/Pdn mouse.

Ueta E, Kodama M, Sumino Y, Kurome M, Ohta K, Katagiri R, Naruse I

Congenital anomalies 50 巻 ( 1 ) 頁： 29 - 39 2010年3月

流動層燃焼炉における炉内脱硫特性の理論的考察

村上高広, 栗田典之, 成瀬一郎

高温学会誌 36 巻 ( 1 ) 頁： 41 - 46 2010年1月

木質バイオマスのCO2およびH2Oとの反応特性査読有り

成瀬一郎、植木保昭、伊佐山勉、榛葉貴紀、Joseph H.Kihedu、義家亮

鉄と鋼 96 巻 ( 4 ) 頁： 150-155 2010年

流動層燃焼炉における炉内脱硫特性の理論的考察査読有り

村上高広、栗田典之、成瀬一郎

高温学会誌 36 巻 ( 1 ) 頁： 14-46 2010年

乾燥下水汚泥燃焼域における窒素酸化物の生成・消滅特性とその機構査読有り

成瀬一郎、平林美和、義家亮、植木保昭

廃棄物資源循環学会論文誌 21 巻 ( 6 ) 頁： 193-201 2010年

264 燃焼排ガス中の希薄未燃炭化水素の分解特性(OS4-2 燃焼現象の計測,予測,応用2,OS4 燃焼現象の計測,予測,応用)

義家亮, 林壮哉, 植木保昭, 成瀬一郎

東海支部総会講演会講演論文集 2010 巻 ( 0 ) 頁： 127 - 128 2010年

Control of Ash Deposition in Pulverized Coal Combustor

Naruse Ichiro, Yoshiie Ryo, Matsuura Mikio, Ueki Yasuaki, Naganuma Hiroshi, Ito Tadashi

JOURNAL OF CHEMICAL ENGINEERING OF JAPAN 43 巻 ( 10 ) 頁： 872 - 879 2010年

Desulfurization and Regeneration Process by Using Molten Alkali Carbonates at High Temperature

Raharjo Slamet, Ueki Yasuaki, Yoshiie Ryo, Naruse Ichiro

PROCEEDINGS OF 2010 INTERNATIONAL CONFERENCE ON CHEMICAL ENGINEERING AND APPLICATIONS 頁： 45 - 51 2010年

No.25 微粉炭燃焼における灰付着および伝熱管損傷機構(灰・微量元素(3))

長沼宏, 池田信矢, 成瀬一郎, 義家亮, 植木保昭, 松浦幹夫, 伊藤正, 佐竹英

石炭科学会議発表論文集 47 巻 ( 0 ) 頁： 50 - 51 2010年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In pulverized coal fired boilers, molten ash particles generated during combustion have possibility of adhesion on surface of heat exchanger tubes. This causes problems of heat transfer inhibition such as slagging and fouling as well as erosion and/or corrosion of the tubes. In order to solve those problems, surface treatment technology on the heat exchanger tubes has been developed in this study. In this paper, the ash deposition and tube damage mechanisms were discussed by observing and analyzing the interface between the tube and ash deposition in the practical boiler.

DOI： 10.20550/jiesekitanronbun.47.0_50

No.29 改質褐炭の基礎燃焼挙動(燃焼,NOx)

嶋村倫生, 植木保昭, 義家亮, 成瀬一郎, 秋山勝哉

石炭科学会議発表論文集 47 巻 ( 0 ) 頁： 58 - 59 2010年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

To preserve fossil fuel resources, it is important to develop the efficient use of low rank coals like brown coal and lignite all over the world. Upgraded Brown Coal(UBC), which is the coal dewatered and stabilized in heated oil, is the promising way to use low rank coals as well as bituminous coals. In this paper, fundamental combustion characteristics and kinetics of UBC are examined via thermo-gravimetric(TG)analyses and Drop Tube Furnace(DTF)experiments. They are compared with those of bituminous coal. The UBC seemed to have higher reactivity during combustion than bituminous coal. There is a difference in the volatile evolution process between the UBC and bituminous coals.

DOI： 10.20550/jiesekitanronbun.47.0_58

No.27 CCSEMによる詳細解析法を用いた石炭灰の高度有効利用に関する研究(灰・微量元素(3))

赤堀有記, 植木保昭, 義家亮, 成瀬一郎

石炭科学会議発表論文集 47 巻 ( 0 ) 頁： 54 - 55 2010年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In Japan, electricity is mainly produced by means of thermal power generation with combustion of fossil fuels, such as oil and coal. On the other hand, large amount of coal is used as material of cement by mixing with limestone, too. Therefore, the purpose is to develop high efficiency energy cycle which product electric power and cement material called clinker simalutaneously to save the usage of raw materials. In this paper, the prediction of how to create clinker is examined by means of Factsage which is thermal equilibrium calculation software. The results obtained are compared how much mix ratio is more efficiency to product clinker. The results of CCSEM analyses show what components created in from experiment.

DOI： 10.20550/jiesekitanronbun.47.0_54

乾燥下水汚泥燃焼域における窒素酸化物の生成・消滅特性とその機構査読有り

成瀬一郎, 平林美和, 義家亮, 植木保昭

廃棄物資源循環学会論文誌 21 巻 ( 6 ) 頁： 193-201 2010年

木質バイオマスのCO2およびH2Oとの反応特性査読有り

成瀬一郎, 植木保昭, 伊佐山勉, 榛葉貴紀, Joseph, H.Kihedu, 義家亮

鉄と鋼 96 巻 ( 4 ) 頁： 150-155 2010年

流動層燃焼炉における炉内脱硫特性の理論的考察査読有り

村上高広, 栗田典之, 成瀬一郎

高温学会誌 36 巻 ( 1 ) 頁： 14-46 2010年

Introduction of Research Group 名古屋大学大学院工学研究科機械理工学専攻機械科学分野環境・エネルギー工学講座高温エネルギー変換工学研究グループ(成瀬・義家研究室)

成瀬一郎

日本エネルギ-学会誌 88 巻 ( 1 ) 頁： 81 - 84 2009年1月

*Behavior of lead compounds during municipal solid waste incineration 査読有り

Hong Yao, Ichiro Naruse

Proceedings of Combustion Institute 32 巻頁： 2685-2691 2009年

Control of ash deposition in pulverized coal-fired boiler 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Takayuki Kawai,suyoshi Takuwa, Tadashi Ito, Yoshiaki Igarashi, Ryo Yoshiie, Ichiro Naruse

Proceedings of Combustion Institute 32 巻頁： 2709-2716 2009年

*充填層式木質バイオマスガス化炉の反応挙動解明査読有り

多久和穀志、鳥越隆志、義家亮、成瀬一郎

日本機械学会論文集B編 75 巻 ( 752 ) 頁： 242-248 2009年

*界面反応を伴う石炭灰付着機構の解明査読有り

長田宏、池田信矢、伊藤正、佐藤文夫、浦島一晃、多久和毅志、義家亮、成瀬一郎

日本エネルギー学会誌 88 巻 ( 9 ) 頁： 816-822 2009年

*Behavior of lead compounds during municipal solid waste incineration 査読有り

Hong Yao, Ichiro Naruse

Proceedings of Combustion Institute 32 巻頁： 2685-2691 2009年

Behavior of lead compounds during municipal solid waste incineration

Yao Hong, Naruse Ichiro

PROCEEDINGS OF THE COMBUSTION INSTITUTE 32 巻頁： 2685 - 2691 2009年

*界面反応を伴う石炭灰付着機構の解明査読有り

長田宏, 池田信矢, 伊藤正, 佐藤文夫, 浦島一晃, 多久和毅志, 義家亮, 成瀬一郎

日本エネルギー学会誌 88 巻 ( 9 ) 頁： 816-822 2009年

*充填層式木質バイオマスガス化炉の反応挙動解明査読有り

多久和穀志, 鳥越隆志, 義家亮, 成瀬一郎

日本機械学会論文集B編 75 巻 ( 752 ) 頁： 242-248 2009年

Control of ash deposition in pulverized coal fired boiler

Naganuma Hiroshi, Ikeda Nobuya, Kawai Takayuki, Takuwa Tsuyoshi, Ito Tadashi, Igarashi Yoshiaki, Yoshiie Ryo, Naruse Ichiro

PROCEEDINGS OF THE COMBUSTION INSTITUTE 32 巻頁： 2709 - 2716 2009年

Control of ash deposition in pulverized coal-fired boiler 査読有り

Hiroshi Naganuma, Nobuya Ikeda, Takayuki Kawai, suyoshi Takuwa, Tadashi Ito, Yoshiaki Igarashi, Ryo Yoshiie, Ichiro Naruse

Proceedings of Combustion Institute 32 巻頁： 2709-2716 2009年

Gasification characteristics of woody biomass in the packed bed reactor

Yoshiie R.

7th Asia-Pacific Conference on Combustion, ASPACC 2009 2009年

228 充填層式ガス化炉による木質バイオマスのガス化挙動(廃棄物発電・バイオマス発電・熱利用技術)

小野浩史, 義家亮, 成瀬一郎, 鳥越隆志

環境工学総合シンポジウム講演論文集 2009 巻 ( 0 ) 頁： 216 - 219 2009年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

The purpose of this study is to investigate the behavior of biomass gasification in the packed-bed, conducting gasification experiment and analysis of syn-gas in the reactor. In this study, pellets of black pine (ψ6.5mm×8.5mm) are fed intermittently with air as the gasification agent. The gasification experiments were carried out by two type gasification methods, such as updraft and downdraft setups. In the gasification tests, the temperature distribution in the gasification reactor and the gas compositions are measured and analyzed during gasification by thermo-couples inserted from a furnace wall and a micro gas chromatograph, respectively. Product gas before cooling were sampled for determine the amount of tar generation.

DOI： 10.1299/jsmeenv.2009.19.216

606 石炭ガス化条件における微量金属を含む微粒子の放出過程の解明(OS8-2燃焼現象及び燃焼技術の基礎と応用2)

義家亮, 田谷幸洋, 成瀬一郎

東海支部総会講演会講演論文集 2009 巻 ( 0 ) 頁： 375 - 376 2009年

Gasification and Desulfurization Characteristics of Carbonaceous Materials in Molten Alkali Carbonates

RAHARJO Slamet, TAKUWA Tsuyoshi, IWASAKI Shin, YOSHIIE Ryo, NARUSE Ichiro

Journal of Environment and Engineering 4 巻 ( 2 ) 頁： 386 - 394 2009年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

This study focuses on gasification technology of carbonaceous materials in molten carbonates since this gasifier can gasify those fuels catalytically and in-situ clean up the gasified gas at high temperature simultaneously. This gasification system has such advantages that alkali metal compounds have catalytic function for the gasification reactions, the molten alkali compounds can absorb sulfur compounds and the molten media can capture ash and un-reacted particles produced. The molten carbonate employed in this study is an eutectic salt with the compositions of 43 mol% Na2CO3 and 57 mol% K2CO3. CO2 is selected as a gasification agent. Before the gasification experiments, the optimum gasification and desulfurization temperature is evaluated by the chemical equilibrium calculations. Fundamental gasification and desulfurization experiments were conducted, by using an electrically heated reactor. As a result, the main compositions of the gasified gas are CO, H2 and CH4. H2S and COS gases in the product can be absorbed almost completely by the molten alkali carbonates. These results suggest that this gasifier can gasify the carbonaceous materials and desulfurize even at high temperature inside the furnace simultaneously.

DOI： 10.1299/jee.4.386

溶融アルカリ炭酸塩を用いた炭素系物質のガス化・脱硫特性

成瀬一郎, Raharjo Slamet, 岩崎伸, 多久和毅志, 義家亮

日本機械学會論文集. B編 = Transactions of the Japan Society of Mechanical Engineers. B 74 巻 ( 748 ) 頁： 2636 - 2641 2008年12月

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

This study focuses on gasification technology of carbonaceous materials in molten carbonates since this gasifier can gasify those fuels catalytically and in-situ clean up the gasified gas at high temperature simultaneously. This gasification system has such advantages that alkali metal compounds show catalytic function for the gasification reactions, the molten alkali compounds can absorb sulfur compounds and the molten media can capture ash and unreacted particles produced. The molten carbonate employed in this study is an eutectic salt with the compositions of 43mol% Na_2CO_3 and 57mol% K_2CO_3. CO_2 is selected as a gasification agent. Before the gasification experiments, the optimum gasification and desulfurization temperature is evaluated by the chemical equilibrium calculations. Fundamental gasification and desulfurization experiments were conducted, by using an electrically heated reactor. As a result, the main compositions of the gasified gas are CO, H_2 and CH_4. H_2S and COS gases in the product can be absorbed almost completely by the molten alkali carbonates. These results suggest that this gasifier can gasify the carbonaceous materials and desulfurize even at high temperature inside the furnace simultaneously.

Altered signaling pathway in the dysmorphogenesis of telencephalon in the Gli3 depressed mouse embryo, Pdn/Pdn.

Ueta E, Kurome M, Teshima Y, Kodama M, Otsuka Y, Naruse I

Congenital anomalies 48 巻 ( 2 ) 頁： 74 - 80 2008年6月

*溶融アルカリ炭酸塩を用いた炭素系物質のガス化・脱硫特性査読有り

成瀬一郎、Slamet RAHARJO、岩崎伸、多久和穀志、義家亮

日本機械学会論文集B編 74 巻 ( 748 ) 頁： 2636-2641 2008年

*溶融アルカリ炭酸塩を用いた炭素系物質のガス化・脱硫特性査読有り

成瀬一郎, Slamet RAHARJO, 岩崎伸, 多久和穀志, 義家亮

日本機械学会論文集B編 74 巻 ( 748 ) 頁： 2636-2641 2008年

溶融アルカリ炭酸塩を用いた炭素系物質のガス化・脱硫特性

成瀬一郎, RAHARJO Slamet, 岩崎伸, 多久和毅志, 義家亮

日本機械学会論文集 B編 74 巻 ( 748 ) 頁： 2636 - 2641 2008年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

This study focuses on gasification technology of carbonaceous materials in molten carbonates since this gasifier can gasify those fuels catalytically and in-situ clean up the gasified gas at high temperature simultaneously. This gasification system has such advantages that alkali metal compounds show catalytic function for the gasification reactions, the molten alkali compounds can absorb sulfur compounds and the molten media can capture ash and unreacted particles produced. The molten carbonate employed in this study is an eutectic salt with the compositions of 43 mol% Na2CO3 and 57 mol% K2CO3. CO2, is selected as a gasification agent. Before the gasification experiments, the optimum gasification and desulfurization temperature is evaluated by the chemical equilibrium calculations. Fundamental gasification and desulfurization experiments were conducted, by using an electrically heated reactor. As a result, the main compositions of the gasified gas are CO, H2 and CH4. H2S and COS gases in the product can be absorbed almost completely by the molten alkali carbonates. These results suggest that this gasifier can gasify the carbonaceous materials and desulfurize even at high temperature inside the furnace simultaneously.

DOI： 10.1299/kikaib.74.2636

22 改質褐炭の燃焼特性と速度論(改質・利用技術)

西尾健太郎, 多久和毅志, 義家亮, 成瀬一郎

石炭科学会議発表論文集 45 巻 ( 0 ) 頁： 44 - 45 2008年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

To preserve fossil fuels all over the world, it is important to develop the efficient use of low rank coals like brown coal and lignite. Upgraded Brown Coal (UBC), which is the coal dewatered and stabilized in heated oil, is the promising way to use low rank coals as sophisticatedly as bituminous coals. In this paper, fundamental combustion characteristics and kinetics of UBCs are examined via thermo-gravimetric analyses. The results obtained are compared with those of some kinds of bituminous coal. The UBC seemed to have higher reactivity during combustion. There is a little difference in the volatile evolution process between the UBC and bituminous coals.

DOI： 10.20550/jiesekitanronbun.45.0_44

554 廃油燃焼場における微量金属成分の濃縮挙動(OS4-5 バイオマス等)

金岡俊樹, 村松健志, 成瀬一郎

東海支部総会講演会講演論文集 2008 巻 ( 0 ) 頁： 387 - 388 2008年

552 充填層式バイオマスガス化炉の反応挙動解明(OS4-5 バイオマス等)

鳥越隆志, 成瀬一郎

東海支部総会講演会講演論文集 2008 巻 ( 0 ) 頁： 383 - 384 2008年

47 石炭ガス化プロセスにおける微量金属成分の挙動解明(灰・微量金属(2))

田谷幸洋, 多久和毅志, 朝倉榮次, 義家亮, 成瀬一郎

石炭科学会議発表論文集 45 巻 ( 0 ) 頁： 94 - 95 2008年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Some trace metal compounds in coal easily vaporize and form fumes during coal gasification. The fumes subsequently cause some problems such as corrosion of the gas turbine blades and material deterioration of the fuel cell. Therefore, it is necessary to understand and control the volatilization of those compounds. In this paper, the evolution behavior of trace heavy metal compounds, especially for Pb and Cd has been studied by thermodynamic equilibrium calculation under combustion and gasification conditions.

DOI： 10.20550/jiesekitanronbun.45.0_94

45 伝熱管表面改質による燃焼灰付着低減効果(灰・微量金属(2))

長沼宏, 池田信矢, 成瀬一郎, 義家亮, 多久和毅志, 浦島一晃, 伊藤正, 五十嵐義昭

石炭科学会議発表論文集 45 巻 ( 0 ) 頁： 90 - 91 2008年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In pulverized coal fired boilers, molten ash particles generated during combustion have possibility of adhesion on surface of heat exchanger tubes. This ash deposition layer formed plays a role for insulation surrounding the tubes. In order to solve this problem, surface treatment technology of the heat exchanger tubes is developed in this study. Surface treatment technology adopted in this study could reduce the ash deposition during coal combustion. The adhesive bond between the deposition layer and the tube surface related to percentage of content of alkali sulfate in ash.

DOI： 10.20550/jiesekitanronbun.45.0_90

Detailed kinetic and control of alkali metal compounds during coal combustion

Takuwa T.

Fuel Processing Technology 88 巻 ( 11-12 ) 頁： 1029 - 1034 2007年12月

Experiments and thermodynamic equilibrium of homogenous oxidation of mercury

Luo G.

Kung Cheng Je Wu Li Hsueh Pao/Journal of Engineering Thermophysics 28 巻 ( 6 ) 頁： 1039 - 1042 2007年11月

Prevention of ochratoxin A-induced neural tube defects by folic acid in the genetic polydactyly/arhinencephaly mouse, Pdn/Pdn.

Katagiri R, Kurome M, Teshima Y, Ueta E, Naruse I

Congenital anomalies 47 巻 ( 3 ) 頁： 90 - 6 2007年9月

燃焼プロセスにおける微量金属成分の挙動と制御

成瀬一郎

Journal of the Society of Inorganic Materials, Japan : セッコウ・石灰・セメント・地球環境の科学 14 巻 ( 328 ) 頁： 177 - 183 2007年5月

Effect of cellulose and lignin content on pyrolysis and combustion characteristics for several types of biomass 査読有り

Asri Gani and Ichiro Naruse

Renewable Energy 32 巻 ( 4 ) 頁： 649-661 2007年4月

Effect of cellulose and lignin content on pyrolysis and combustion characteristics for several types of biomass 査読有り

Asri Gani, Ichiro Naruse

Renewable Energy 32 巻 ( 4 ) 頁： 649-661 2007年4月

Effect of cellulose and lignin content on pyrolysis and combustion characteristics for several types of biomass

Gani A.

Renewable Energy 32 巻 ( 4 ) 頁： 649 - 661 2007年4月

石炭灰の付着挙動に及ぼす液相成分の影響

長沼宏, 成瀬一郎, 宮内良樹, 河合隆之, 伊藤正, 三木良治, 相澤威一郎, 狩野勝広

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 86 巻 ( 2 ) 頁： 102 - 108 2007年2月

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In order to prevent adhesion of molten ash particles on the surface of heat exchanger tubes in coal combustion boilers, surface treatment of the tubes, using a thermal spray coating techniaue, is conducted in this study. As one of the important mechanisms of ash adhesion relates to liquid-bridge force between the tube surface and the molten ash particles, contact angle of the liquid-phase on the surface for the simulated molten ash particles was measured, varying types of coating metal species. The ash deposition experiments on the coated tubes were also conducted, using a ertical furnace under the high-temperature condition. The result showed that the two values of the wettability and the slagging factor of the ash particles deposited could evaluate the ash adhesion characteristics. The wettablity could be controlled by changing types of the coating metal species. The amount of ash deposition increased with an increase of the slagging factor. Especially, sodium and potassium compounds were concentrated in the position apart from 60 egrees from the stagnation point. These results suggest that the surface treatment of the tubes, using a thermal spray coating technique, can control the ash deposition behaviors.

Emission control of sodium compounds and their formation mechanisms during coal combustion 査読有り

T. Takuwa and I. Naruse

Proceedings of the Combustion Institute 31 巻頁： 2863-2870 2007年

Role of Methanol on Supercritical Water Oxidation of Ammonia, 査読有り

Suzugaki H.,Naruse I.Quitain,A.T.,Daimon,H.,Fujie,K.

Ind.Eng.Chem.Res. 46 巻頁： 3566-3573 2007年

Detailed kinetic and control of alkali metal compounds during coal combustion 査読有り

Tsuyoshi Takuwa and Ichiro Naruse

Fuel Processing Technology 88 巻 ( 11-12 ) 頁： 1029-1034 2007年

Detailed kinetic and control of alkali metal compounds during coal combustion 査読有り

Tsuyoshi Takuwa, Ichiro Naruse

Fuel Processing Technology 88 巻 ( 11-12 ) 頁： 1029-1034 2007年

Emission control of sodium compounds and their formation mechanisms during coal combustion

Takuwa T.

Proceedings of the Combustion Institute 31 II 巻頁： 2863 - 2870 2007年

Emission control of sodium compounds and their formation mechanisms during coal combustion 査読有り

T. Takuwa, I. Naruse

Proceedings of the Combustion Institute 31 巻頁： 2863-2870 2007年

石炭灰の付着挙動に及ぼす液相成分の影響

長沼宏, 成瀬一郎, 宮内良樹, 河合隆之, 伊藤正, 三木良治, 相澤威一郎, 狩野勝広

日本エネルギー学会誌 86 巻 ( 2 ) 頁： 102 - 108 2007年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In order to prevent adhesion of molten ash particles on the surface of heat exchanger tubes in coal combustion boilers, surface treatment of the tubes, using a thermal spray coating technique, is conducted in this study. As one of the important mechanisms of ash adhesion relates to liquid-bridge force between the tube surface and the molten ash particles, contact angle of the liquid-phase on the surface for the simulated molten ash particles was measured, varying types of coating metal species. The ash deposition experiments on the coated tubes were also conducted, using a vertical furnace under the high-temperature condition. The result showed that the two values of the wettability and the slagging factor of the ash particles deposited could evaluate the ash adhesion characteristics. The wettablity could be controlled by changing types of the coating metal species. The amount of ash deposition increased with an increase of the slagging factor. Especially, sodium and potassium compounds were concentrated in the position apart from 60 degrees from the stagnation point. These results suggest that the surface treatment of the tubes, using a thermal spray coating technique, can control the ash deposition behaviors.

DOI： 10.3775/jie.86.102

1-18 石炭灰と金属との付着力温度依存性((6)石炭灰,金属,Session 1 石炭・重質油等,研究発表(口頭発表))

Role of coal utilization technologies for suatainable society

Naruse Ichiro

PROCEEDINGS OF THE 6TH INTERNATIONAL SYMPOSIUM ON COAL COMBUSTION 頁： 23 - 29 2007年

Role of Methanol on Supercritical Water Oxidation of Ammonia, 査読有り

Suzugaki H, Naruse I.Quitain,A.T, Daimon,H, Fujie,K

Ind.Eng.Chem.Res. 46 巻頁： 3566-3573 2007年

長沼宏, 池田信矢, 成瀬一郎, 河合隆之, 伊藤正, 五十嵐義昭

日本エネルギー学会大会講演要旨集 16 巻 ( 0 ) 頁： 36 - 37 2007年

37 微粉炭燃焼場における灰付着特性の予測(灰付着,アルカリ金属)

成瀬一郎, 河合隆之

石炭科学会議発表論文集 44 巻 ( 0 ) 頁： 74 - 75 2007年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In pulverized coal combustors, molten ash particles generated during combustion have possibility of adhesion on surface of heat exchanger tubes. This ash deposition layer formed plays a role for insulation surrounding the tubes. In order to prevent this problem, it is, first, necessary to predict ash deposition characteristics. In this paper, not only amount of the ash deposition was measured experimentally, but also that amount was compared with amount of the slag-liquid phase calculated by the thermal equilibrium theory. As a result, the amount of slag-liquid phase calculated could be correlated with the amount of ash deposition obtained experimentally.

DOI： 10.20550/jiesekitanronbun.44.0_74

Genetic susceptibility in the neural tube defects induced by ochratoxin A in the genetic arhinencephaly mouse, Pdn/Pdn.

Ohta K, Maekawa M, Katagiri R, Ueta E, Naruse I

Congenital anomalies 46 巻 ( 3 ) 頁： 144 - 8 2006年9月

Mercury emissions and species during combustion of coal and waste

Yao H.

Energy and Fuels 20 巻 ( 5 ) 頁： 1946 - 1950 2006年9月

プロセス内の微量金属の収支と生成機構

二宮善彦, 成瀬一郎

化学工学 = CHEMICAL ENGINEERING OF JAPAN 70 巻 ( 7 ) 頁： 329 - 334 2006年7月

Mechanisms of fine particulates formation with alkali metal compounds during coal combustion

Takuwa T.

Fuel 85 巻 ( 5-6 ) 頁： 671 - 678 2006年3月

石炭のガス化過程における灰挙動と付着現象

成瀬一郎, 山下亨, 秋本明光

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 85 巻 ( 1 ) 頁： 20 - 27 2006年1月

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

This report deals with comprehensive studies on ash formation, ash deposition and growth of the deposition layer during gasification. For the ash formation, both the coagulation model for the included mineral particles and the splitting model for the excluded mineral particles are developed, based on the experimental and analytical results obtained. For the ash deposition process, the ash deposition characteristics depend on properties of ash in raw coals, especially for the melting temperature. The fine ash particles selectively adhere at the initial stage of deposition. The ash compositions of the depositing particles differ from those of the ash particles in the char particles before deposition. For growth of the ash deposition layer, both the melting tests for several types of coal ash and the chemical equilibrium calculations on the molten phases of some ash compositions contribute to modeling the growth behaviors of ash deposition layer during gasification. Finally, the actual coal gasification tests are conducted at atmospheric pressure, using a bench-scale coal gasifier, to confirm the validity of some models developed in these studies.

Ash behaviors and deposition phenomena in coal gasification

Naruse I.

Nihon Enerugi Gakkaishi/Journal of the Japan Institute of Energy 85 巻 ( 1 ) 頁： 20 - 27 2006年1月

Mechanisms of Fine Particulates Formation with Alkali Metal Compounds during Coal Combustion 査読有り

T. Takuwa, I. S. N. Mkilaha and I. Naruse

Fuel 85 巻頁： 671-678 2006年

Effect of alkali metal compounds on limestone calcination in desulfurization process: Molecilar dynamic simulatioms 査読有り

Takahiro Murakani, Noriyuki Kurita and Ichiro Naruse

Journal of the Ceramic Society of Japan 114 巻 ( 8 ) 頁： 676-680 2006年

Mercury Emissions and Species during Combustion of Coal and Waste 査読有り

Hong Yao, Guangqian Luo, Minghou Xu, Tamotsu Kameshima and Ichiro Naruse

Energy & Fuels 20 巻頁： 1946-1950 2006年

Effect of alkali metal compounds on limestone calcination in desulfurization process: Molecilar dynamic simulatioms 査読有り

Takahiro Murakani, Noriyuki Kurita, Ichiro Naruse

Journal of the Ceramic Society of Japan 114 巻 ( 8 ) 頁： 676-680 2006年

Mechanisms of Fine Particulates Formation with Alkali Metal Compounds during Coal Combustion 査読有り

T. Takuwa, I. S. N. Mkilaha, I. Naruse

Fuel 85 巻頁： 671-678 2006年

Mercury Emissions and Species during Combustion of Coal and Waste 査読有り

Hong Yao, Guangqian Luo, Minghou Xu, Tamotsu Kameshima, Ichiro Naruse

Energy & Fuels 20 巻頁： 1946-1950 2006年

1-6.重質油や廃油の無触媒下での水蒸気による改質技術((2)重質油,燃焼・ガス化,Session 1 石炭・重質油等)

鳴海良成, 鈴木雄三, 後藤信一, 高橋伸定, 成瀬一郎, 多久和毅志

日本エネルギー学会大会講演要旨集 15 巻 ( 0 ) 頁： 43 - 44 2006年

5-4.廃棄物焼却過程における鉛の挙動((1)燃焼,Session 5 燃焼・熱利用)

前山武史, 森茂史, 多久和毅志, 姚洪, 成瀬一郎

日本エネルギー学会大会講演要旨集 15 巻 ( 0 ) 頁： 307 - 308 2006年

41. Desulfurization and Regeneration Characteristic with Molten Alkali Carbonates at High Temperature

Raharjo Slamet, Naruse Ichiro

石炭科学会議発表論文集 43 巻 ( 0 ) 頁： 83 - 84 2006年

311 カオリンの微量添加による石炭燃焼場における微粒子生成およびアルカリ金属化合物の制御(大気汚染物質除去,大気・水循環保全技術)

多久和毅志, 成瀬一郎

環境工学総合シンポジウム講演論文集 2006 巻 ( 0 ) 頁： 270 - 273 2006年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

In order to control emissions of sodium compounds during coal combustion, the sorbent injection technology is tested under the coal combustion condition. Kaolin is selected as the sorbent to absorb vapors of sodium compounds evolved from the coals. In the combustion experiments, the kaolin is physically mixed with coal. Two types of coal, which have the similar coal properties, are burned. Combustion tests are conducted, using an electrically heated drop tube furnace, to study effect of kaolin addition on the capture characteristics of sodium compounds. As a result, the kaolin can effectively capture the vapor of sodium compounds even under the actual coal combustion condition. The capture efficiency depends on the coal type. The sodium compounds for the coals, which produce many fine particles with size of less than 1μm, tend to be effectively captured by the kaolin.

DOI： 10.1299/jsmeenv.2006.16.270

310 気相中における水銀反応挙動の実験的・理論的解析(大気汚染物質除去,大気・水循環保全技術)

多久和毅志, 亀嶋保, 成瀬一郎

環境工学総合シンポジウム講演論文集 2006 巻 ( 0 ) 頁： 267 - 269 2006年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

The objectives are to elucidate homogeneous mechanisms of mercury oxidization in high temperature and study the important factors on mercury oxidization in the homogeneous reaction. The mercury oxidation experiments were carried out by injecting Hg gas with HCl or Cl_2 gas, using an electrically heated horizontal reaction tube. Additionally, chemical equilibrium and chemical kinetics analyses were also conducted for studying the main mercury elementary reaction scheme theoretically. The results show that HCl has little possibility of mercury oxidation. For Cl_2 addition case, however, the mercury oxidization is enhanced more.

DOI： 10.1299/jsmeenv.2006.16.267

23.金属と石炭灰との界面反応が付着力変化に与える影響

長沼宏, 相沢威一郎, 成瀬一郎, 河合隆之, 伊藤正, 狩野勝広

石炭科学会議発表論文集 43 巻 ( 0 ) 頁： 47 - 48 2006年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In pulverized coal combustors, molten ash particles generated during combustion have possibility of adhesion on surface of heat exchanger tubes. This ash deposition layer formed plays a role for insulation surrounding the tubes. In order to prevent this problem, surface treatment technology of the tube to control the ash adhesion is tested in this study. Time change of an adhesive bond of coal ash on the metal, which is important to understand the fouling mechanism, is measured. The metal and ash composition at the interface is also observed, and the effect of the interfacial reactions on the change of the adhesive bond is discussed.

DOI： 10.20550/jiesekitanronbun.43.0_47

1.1 固体の燃焼(1. 燃焼理論,III エネルギー変換技術の進展と研究動向,平成17年における重要なエネルギー関係事項)

成瀬一郎

日本エネルギー学会誌 85 巻 ( 8 ) 頁： 677 - 678 2006年

1-8.金属表面における石炭灰の経時的付着力変化と界面反応((2)重質油,燃焼・ガス化,Session 1 石炭・重質油等)

長沼宏, 相沢威一郎, 成瀬一郎, 河合隆之, 伊藤正, 狩野勝広

日本エネルギー学会大会講演要旨集 15 巻 ( 0 ) 頁： 47 - 48 2006年

Exencephaly induction by valproic acid in the genetic polydactyly/arhinencephaly mouse, Pdn/Pdn.

Maekawa M, Ohta K, Katagiri R, Ueta E, Naruse I

Congenital anomalies 45 巻 ( 4 ) 頁： 132 - 6 2005年12月

Combustion characteristics of dried sewage sludge and control of trace-metal emission

Yao H.

Energy and Fuels 19 巻 ( 6 ) 頁： 2298 - 2303 2005年11月

Control of Trace Metal Emissions by Sorbents during Sewage Sludge Combustion 査読有り

H. Yao and I. Naruse

Proc. of Combus. Inst. 30 巻 ( 2 ) 頁： 3009-3016 2005年8月

Control of Trace Metal Emissions by Sorbents during Sewage Sludge Combustion 査読有り

H. Yao, I. Naruse

Proc. of Combus. Inst. 30 巻 ( 2 ) 頁： 3009-3016 2005年8月

Characteristics of co-combustion of low-rank coal with biomass

Gani A.

Energy and Fuels 19 巻 ( 4 ) 頁： 1652 - 1659 2005年7月

Fundamental ash deposition characteristics in pulverized coal reaction under high temperature conditions

Naruse I.

Fuel 84 巻 ( 4 ) 頁： 405 - 410 2005年3月

Fundamental Study on Initial Ash Deposition during Pulverized Coal Reaction 査読有り

I. Naruse, D. Kamihashira, Khairil, Y. Miyauchi, Y. Kato, T. Yamashita and H. Tominaga

Fuel 84 巻頁： 405-410 2005年

Characteristics of Co-combustion of Low-Rank Coal with Biomass 査読有り

A. Gani, K. Morishita, K. Nishikawa and I. Naruse

Energy & Fuels 19 巻頁： 2298-2303 2005年

Characteristics of Co-combustion of Low-Rank Coal with Biomass 査読有り

A. Gani, K. Morishita, K. Nishikawa, I. Naruse

Energy & Fuels 19 巻頁： 2298-2303 2005年

Control of trace metal emissions by sorbents during sewage sludge combustion

Yao H.

Proceedings of the Combustion Institute 30 II 巻頁： 3009 - 3016 2005年

Effect of mineral matters in coal on formation behaviors of particulate matter and alkali metal compounds during coal combustion

Takuwa T.

Proceedings of the 18th International Conference on Fluidized Bed Combustion, 2005 頁： 271 - 275 2005年

Fundamental Study on Initial Ash Deposition during Pulverized Coal Reaction 査読有り

I. Naruse, D. Kamihashira, Khairil, Y. Miyauchi, Y. Kato, T. Yamashita, H. Tominaga

Fuel 84 巻頁： 405-410 2005年

No and N<inf>2</inf>O formation/decomposition characteristics during co-combustion of coal with biomass

Gani A.

Proceedings of the 18th International Conference on Fluidized Bed Combustion, 2005 頁： 219 - 223 2005年

1-15.灰付着挙動における液相成分の影響((4)共処理・灰・プロセス,Session 1 石炭・重質油等)

長沼宏, 相澤威一郎, 成瀬一郎, 宮内良樹, 河合隆之, 伊藤正, 三木良治, 狩野勝広

日本エネルギー学会大会講演要旨集 14 巻 ( 0 ) 頁： 44 - 45 2005年

3-48.木質系バイオマス熱分解ガス化改質システムの研究開発((13)ガス化1,Session 3 バイオマス等)

鳴海良成, 鈴木雄三, 後藤信一, 高橋伸定, 成瀬一郎

日本エネルギー学会大会講演要旨集 14 巻 ( 0 ) 頁： 192 - 193 2005年

3-32.林産系バイオマスを基軸とした持続可能な森林地域社会システムの提案((8)システム,Session 3 バイオマス等)

榛葉貴紀, 多久和毅志, 成瀬一郎, 川合吉雄, 富村周平

日本エネルギー学会大会講演要旨集 14 巻 ( 0 ) 頁： 160 - 161 2005年

3-3.バイオマスの燃焼・熱分解特性へのリグニン・セルロースの影響((1)熱分解,Session 3 バイオマス等)

ガニアスリ, 成瀬一郎

日本エネルギー学会大会講演要旨集 14 巻 ( 0 ) 頁： 102 - 103 2005年

23.均一反応系における水銀化合物の反応挙動解明

亀嶋保, 姚洪, 成瀬一郎

石炭科学会議発表論文集 42 巻 ( 0 ) 頁： 49 - 50 2005年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

The objectives are to elucidate homogeneous mechanisms of mercury oxidization and study the important factors on mercury oxidization in the homogeneous reaction system. The mercury oxidation experiments were conducted by injecting Hg gas with HCl or Cl_2 gas, using an electrically heated horizontal tube. Chemical equilibrium and chemical kinetics analyses were also carried out to study the main mercury elementary reaction scheme theoretically. The results show that HCI has little possibility of mercury oxidization. For Cl_2 addition, however, the mercury oxidization is enhanced more. The coexistence atmosphere of H_2O with Cl_2 affects promotion of mercury oxidization.

DOI： 10.20550/jiesekitanronbun.42.0_49

218 木質バイオマスによる地産地消型地域社会システムを構築するためのシナリオ策定愛知県新城・鳳来地区を対象として(燃焼・ガス化(2),廃棄物処理技術)

榛葉貴紀, 多久和毅志, 成瀬一郎, 川合吉雄, 富村周平

環境工学総合シンポジウム講演論文集 2005 巻 ( 0 ) 頁： 174 - 177 2005年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

In this study, Shinshiro and Horai areas were selected as a local community with forest resources unused effectively since fraction of forest area in this community exceeded to 60%. First, tree types and their amount were investigated in those areas. Amount and types of recycled and wasted woody biomass were also investigated by hearing and questionnaires to sawmill factories in Shinshiro and Horai areas. Based on those investigation results, available amount of woody biomass to energy and material resources was estimated. Additionally, several energy production technologies such as combustion, gasification and so forth were also surveyed Consequently, a small-scale fixed bed gasifier with a gasoline engine was selected as one of the candidate. To operate this gasifier, fundamental thermal properties of the biomass selected were analyzed, and the gasification and power generation experiments were also conducted.

DOI： 10.1299/jsmeenv.2005.15.174

12.石炭ガス化過程における灰の挙動と付着特性

河合隆之, 宮内良樹, 成瀬一郎

石炭科学会議発表論文集 42 巻 ( 0 ) 頁： 27 - 28 2005年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Recently, high-temperature and high-pressure coal gasification combined cycle systems have been under developed to realize more efficient and ecological coal utilization technologies. In the gasification process, however, slugging and fouling troubles sometimes occur in the section of furnace wall and heat exchanger, respectively, since the operating temperature exceeds the ash melting temperature. Therefore, it is necessary to predict ash behaviors in the gasification process, based on the properties of mineral particles in the raw coals. Objective of this study is to elucidate the formation behaviors of ash particles and deposition characteristic during coal gasification. The experiments were conducted, using a horizontal high-temperature pulverized coal reactor. Ash particles in the reacting particles sampled during reaction were analyzed, using a Computer Controlled Scanning Electron Microscope (CCSEM).

DOI： 10.20550/jiesekitanronbun.42.0_27

1.1 固体の燃焼(1.燃焼理論,III エネルギー変換技術の進展と研究動向,平成16年における重要なエネルギー関係項目)

成瀬一郎

日本エネルギー学会誌 84 巻 ( 8 ) 頁： 670 - 671 2005年

Application of waste plastics to electric furnaces for steel making as thermal and carbon sources

Naruse I.

Waste Management in Japan 頁： 145 - 154 2004年12月

Sonic hedgehog expression in Gli3 depressed mouse embryo, Pdn/Pdn.

Ueta E, Maekawa M, Morimoto I, Nanba E, Naruse I

Congenital anomalies 44 巻 ( 1 ) 頁： 27 - 32 2004年3月

The prognostic and therapeutic relevance of p27kip1 in Ewing's family tumors.

Matsunobu T, Tanaka K, Matsumoto Y, Nakatani F, Sakimura R, Hanada M, Li X, Oda Y, Naruse I, Hoshino H, Tsuneyoshi M, Miura H, Iwamoto Y

Clinical cancer research : an official journal of the American Association for Cancer Research 10 巻 ( 3 ) 頁： 1003 - 12 2004年2月

1-6.表面改質による石炭灰付着低減技術の開発 : 模擬灰による高温濡れ性試験((2)石炭灰・改質,Session 1 石炭・重質油等)

長沼宏, 相澤威一郎, 成瀬一郎, 田平修一, 加藤雄士, 宮内良樹

日本エネルギー学会大会講演要旨集 13 巻 ( 0 ) 頁： 34 - 35 2004年

Enrichment Mechanisms of Alkali Metal Compounds in Fine Particulates during Coal Combustion

Takuwa Tsuyoshi, Naruse Ichiro

アジア・太平洋化学工学会議発表論文要旨集 2004 巻 ( 0 ) 頁： 549 - 549 2004年

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

Some trace metal compounds in the fuel tend to be enriched in the fine particulates. The fine particulates with the size of less than 1 m as well as hot metallic vapor with alkali metal compounds cause erosive and corrosive effects to blades of a gas turbine. Therefore, it is necessary to understand behaviors and mechanisms of fine particulates formation with alkali metal compounds during coal combustion. Combustion tests were conducted, using an electrically heated drop tube furnace to burn two types of coal with different Na and K concentrations. The burning particles were collected by a Low Pressure Impactor (LPI). As a result, the enrichment mechanism of Na was elucidated by the size distribution of Na concentration in the fine particulates collected in each stage of the LPI. For the fine particulates, the enrichment phenomena were controlled by an internal reaction of Na compounds vapor with fine ash particulates or nucleation, which depended on the coal type. For the relatively coarse particulates, on the other hand, the gas film diffusion controlled the enrichment of Na compounds into the ash particles with the chemical reactions of Na compounds vapor with the those ash particles.

DOI： 10.11491/apcche.2004.0.549.0

Emissions and Control of Lead and Cadmium during Sludge Combustion

Yao Hong, Naruse Ichiro

アジア・太平洋化学工学会議発表論文要旨集 2004 巻 ( 0 ) 頁： 386 - 386 2004年

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

This paper focuses on the emission behaviors of Pb, Cd and Cr during the sewage sludge combustion using a 2 m tall, 40 mm inner diameter electrically heated drop tube furnace. Equilibrium calculations were carried out before to predict the tendency of these trace metal emissions as the same conditions of experiments. The potential use of sorbent to manage emissions of Pb, Cd and Cr for the sewage sludge combustion was also tested. Experimental procedures involved baseline runs of sludge alone and a number of runs with the kaolin addition at 1073, 1148 and 1223K. The sample was collected by the aerosol size fractionation system composed of a water-cooled sampling probe with rapid N2 quenching and a Low Pressure Impactor (LPI). Particle size distributions (PSDs) indicate that most of Pb and Cd are contained in the fine particles (less than 1µm). However, Cr compounds are not enriched in the fine particulates. Since the equilibrium calculations predict that Pb and Cd vaporize at above 973K, these results are due to Pb and Cd vaporization and subsequent reaction in the furnace and/or nucleation in the probe. The addition of 5 % dispersed kaolin power causes an approximate 51 % of Pb and 40 % Cd reduction in the fine particles at the temperature of 1223K during sewage sludge combustion. Pb compound in coarse particles becomes insoluble because of the reaction with kaolin in the furnace.

DOI： 10.11491/apcche.2004.0.386.0

39.溶融炭酸塩による石炭及びバイオマスガス化基礎実験

岩崎伸, 成瀬一郎

石炭科学会議発表論文集 41 巻 ( 0 ) 頁： 83 - 84 2004年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Gasification technology of solid fuels in molten carbonates has been selected as one of the advanced gasification systems. The molten carbonates employed in this study are eutectic salts of Na_2CO_3 (43mol%) and K_2CO_3 (57mol%). As the advantages of utilization of the eutectic salts for coal gasification, the alkali metals play a role for the gasification catalyst, desulfurization solvent and capture material of ash particles. The gasification test results show that the main compositions in the product gas are CO and H_2. H_2S and COS concentrations in the product gas is low enough to introduce the gasified gas into an Molten Carbonate Fuel Cell (MCFC) system, in which H_2S and COS concentrations should be less than 1ppm in the gasified gas.

DOI： 10.20550/jiesekitanronbun.41.0_83

1.1 固体の燃焼(1. 燃焼理論,III エネルギー変換技術の進展と研究動向,平成15年における重要なエネルギー関係項目)

成瀬一郎

日本エネルギー学会誌 83 巻 ( 8 ) 頁： 631 - 632 2004年

Mechanism of Ash Deposition in Pulverized Coal Reaction under High Temperature Conditions

Naruse Ichiro, Miyauchi Yoshiki, Kato Yuji, Yamashita Toru, Tominaga Hiroaki

アジア・太平洋化学工学会議発表論文要旨集 2004 巻 ( 0 ) 頁： 269 - 269 2004年

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

When mineral matters in coal transform during the reaction, the ash compositions as well as the particle size distribution vary. This phenomenon affects fundamental characteristics of ash deposition. In the experiment, three types of coal with the different melting temperature and ash content were burned under the condition of high-temperature air pulverized coal reaction. A water-cooled tube was inserted into the furnace to make the ash adhere. Particle size and composition distributions of ash particles in both reacting coal particles and depositing layer were analyzed, using a Computer Controlled Scanning Microscope (CCSEM). As a result, quantity of the ash deposition on the tube surface increases with a decrease of the melting temperature of coal ash. The growth rate for the coal with low ash-melting temperature became higher. For structure of the deposit layer, fine particles of size less than 3 mm mainly consisted of the initial layer for three types of coal, and the thickness was about 30 mm. Deposition of fine particulates of about 3 mm became a trigger of initial deposition at the stagnation point of tube even if the different types of coal were burned. This phenomenon was also simulated by a simple deposition model, which considered turbulence of flow field, thermophoresis force to the ash particles and so forth. The chemical compositions of ash particles in the reacting particles differed from those in the initial deposition layer. This suggests that the chemical compositions also contribute to the ash deposition phenomena.

DOI： 10.11491/apcche.2004.0.269.0

NO and N2O Formation/Decomposition Characteristics during Co-Combustion of Coal with Biomass

Gani Asri, Naruse Ichiro

アジア・太平洋化学工学会議発表論文要旨集 2004 巻 ( 0 ) 頁： 554 - 554 2004年

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

Co-combustion technologies of coal with biomass have been applied in several practical coal boilers in order to reduce CO2 emission, fuel cost and so forth. Furthermore, the biomass may be able to enhance the combustion performance and to control NOx emission, since the biomass contains high volatile matter and evolves NH3 as volatile-N species. Emission of NOx from coal combustion has recently become a subject of intense research, because of its increasing concentrations in the atmosphere and its known ability to deplete the ozone layer and also contribute to the Greenhouse effect. However, fundamental combustion and NOx emission characteristics for biomass and mixtures of coal with biomass have not been elucidated precisely yet. From these viewpoints, co-combustion technology is one of the candidates to reduce the NOx emission and enhance the effective utilization of both low-grade coals and biomasses. In this study, fundamentals of pyrolysis characteristics of several types of biomass were studied first, using a thermo-gravimetric analyzer. The combustion behaviour of biomass, coal and its mixture were tested, using electrically heated drop tube furnace. In the combustion test, the ignition behaviour, Combustion efficiency and NOx (NO and N2O) emission behaviour were focused, based on the results of gas compositions along the furnace axis. The main results obtained show that biomass can enhance the ignition characteristics of the low-volatile coal during co-combustion. NO and N2O formation during the co-combustion affects effect of coal combustion even if the input fuel nitrogen becomes half of that under coal combustion condition. At least NO behavior can be simulated by the homogeneous reaction scheme relating to NOx even at constant temperature. During biomass combustion, fine particulates less than 2 µm are produced as ash particles. Burning biomass with coal shifts the particle size distribution from fine particles to coarse particles.

DOI： 10.11491/apcche.2004.0.554.0

Effect of coal type on emission characteristics of alkali metal compounds in particulate matters

Takuwa T.

Proceedings of the International Conference on Fluidized Bed Combustion 頁： 229 - 233 2003年12月

Formation Characteristics of Fine Particulates with Na Compounds during Coal Combustion

Takuwa Tsuyoshi, Mkilaha I. S. N., Naruse Ichiro

Journal of chemical engineering of Japan 36 巻 ( 11 ) 頁： 1347 - 1351 2003年11月

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

Some metal compounds in coal vaporize and form fumes during the combustion. The fumes are usually exhausted through the flue gas. For coal-fired combined power generation systems such as pressurized fluidized bed combustion (PFBC), hot metallic vapors may contact with the surfaces of gas-turbine blades. Since this contact of the hot vapors with the surface has a corrosive effect, it is necessary to control the formation of those fumes, which contain alkali metal compounds. In this paper, the evolution behavior of alkali metal compounds, especially sodium compounds, has been studied, using an electrically heated drop tube furnace with a low-pressure impactor. The main objective in this study is to elucidate the conditions and the possible mechanisms to form alkali metal compounds in particulate matter during combustion. Two types of coal with different sodium contents were tested, where the coal conversion characteristics were established. Furthermore, the evolution and inclusion of sodium compounds into the sub-micron particles were studied in relation to the particle size distribution and sodium fraction distribution in the collected particulates. The study proved that the evolution and inclusion of sodium on sub-micron particles depended on the functions of the coal type. The reaction-controlled mechanism and heterogeneous condensation via chemical reactions during the combustion much more influenced the inclusion of sodium in sub-micron particles. At the coarse particles of above about 0.5 μm, the reaction that formed the particles was mainly via gas film diffusion surrounding the particle.

DOI： 10.1252/jcej.36.1347

Molecular Dynamics Simulations of the Effect of NaCl-Doping on the Calcination Characteristics in Desulfurization Processes

Murakami Takahiro, Kurita Noriyuki, Naruse Ichiro

Journal of chemical engineering of Japan 36 巻 ( 3 ) 頁： 225 - 230 2003年3月

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

Desulfurization performance of wasted seashells was found to be over twice as high as that of limestone, which was currently used as a desulfurizer in fluidized bed coal combustors. NaCl-doping into limestone was also found to be effective in improving the desulfurization efficiency. From X-ray diffraction (XRD) analyses of calcined seashell, limestone and NaCl-doped limestone, on the other hand, not only the calcined seashell but also the NaCl-doped limestone had strong peaks of CaO crystal, and those two materials also had high desulfurization activity. This improvement was hypothesized to be due to NaCl causing a change in the crystal structure of CaO. In order to elucidate the effect of NaCl addition on the CaO crystal structure in the incineration of CaCO3, the change of structures was simulated by means of molecular dynamics simulations of CaO. In the simulation one molecule of NaCl was exchanged into one molecule of CaO. A pair correlation functions and the distances between Ca and O atoms, which were obtained by the simulations, were compared with those from the crystal CaO. NaCl-doping affected the crystalization temperature of CaO. The crystallization temperature increased due to adding a little bit of NaCl. From the result of the pair correlation functions obtained in NaCl-doped CaO, the difference of the potential energy of NaCl from that of CaO seemed to contribute to the crystallization of the bulk of CaO. The simulation and experimental results obtained suggested that NaCl-doping contributed to crystallizing the CaO molecules.

DOI： 10.1252/jcej.36.225

1-10.高温微粉炭反応場における灰付着挙動の解明((3)石炭ガス化・灰,Session 1 石炭・重質油等)

Molecular Dynamics Simulations of the Effect of NaCl-doping on the Calcination Characteristics in Desulfurization Processes 査読有り

T. Murakami, N. Kurita and I. Naruse

Journal of Chemical Engineering, Japan 36 巻 ( 3 ) 頁： 225-230 2003年3月

Molecular Dynamics Simulations of the Effect of NaCl-doping on the Calcination Characteristics in Desulfurization Processes 査読有り

T. Murakami, N. Kurita, I. Naruse

Journal of Chemical Engineering, Japan 36 巻 ( 3 ) 頁： 225-230 2003年3月

加藤雄士, 宮内良樹, 成瀬一郎

日本エネルギー学会大会講演要旨集 12 巻 ( 0 ) 頁： 42 - 43 2003年

E155 石炭とバイオマスの混焼特性

ガニアスリ, 西川国博, 森下桂樹, 成瀬一郎

熱工学コンファレンス講演論文集 2003 巻 ( 0 ) 頁： 201 - 202 2003年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Fundamentals of pyrolysis and combustion characteristics of several types of biomass were studied, using a thermogravimetric analyzer. In order to elucidate effect of the biomass addition on coal combustion behavior, combustion performance, NOx emission characteristics and ash formation were discussed, using an electrically heated drop tube furnace. The results obtained showed that pyrolysis and combustion characteristics of biomass depended on lignin and cellulose composition in the biomass. The biomass could enhance the ignition of the low-rank coal. However, NO and N_2O emission behaviors under the co-combustion condition resembled those under the coal combustion. When the biomass was burned alone, fine particulates of less than 2,, m are produced. Under the co-combustion condition, coal ash could capture the fine particulates from the biomass during combustion.

DOI： 10.1299/jsmeted.2003.201

59.溶射バーナを用いた模擬石炭灰による付着実験

加藤雄士, 宮内良樹, 成瀬一郎

石炭科学会議発表論文集 40 巻 ( 0 ) 頁： 120 - 121 2003年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Recently, high temperature coal utilization technologies have been focused. However, those technologies have some problems such as slagging and fouling due to molten coal ash. Therefore, it is necessary to study characterization of ash deposition and its mechanisms. This work studies fundamental characteristics on ash deposition, using a thermal spraying burner. Several kinds of inorganic particle are tested as a simulated coal ash. In the experiments, the deposition mass was weighed, and cross-section of the deposition layers was analyzed by a scanning electron microscope.

DOI： 10.20550/jiesekitanronbun.40.0_120

58.表面改質技術による微粉炭灰付着抑制効果

長沼宏, 成瀬祐一, 成瀬一郎, 加藤雄士, 宮内良樹, 伊藤正, 三木良治

石炭科学会議発表論文集 40 巻 ( 0 ) 頁： 118 - 119 2003年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

In pulverized coal combustors, melting ashes generated during combustion usually adhere to surface of heat exchanger tubes, so that the ash deposition forms a insulation layer surrounding the tubes. In order to prevent this problem, surface treatment technology of the tube to control the ash adhesion was applied in this study. Test pieces with various surface properties were inserted into actual coal combustion atmosphere to evaluate the adhesion characteristics. After the adhesion tests, the amount of ash deposition, physical and chemical analyses of ash deposition layer and so forth were performed. Consequently, the ash adhesion could be controlled by the surface treatment technology.

DOI： 10.20550/jiesekitanronbun.40.0_118

203 劣質炭とバイオマスの混焼基礎特性

ガニアスリ, 西川国博, 森下桂樹, 成瀬一郎

環境工学総合シンポジウム講演論文集 2003 巻 ( 0 ) 頁： 107 - 110 2003年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Fundamental pyrolysis and combustion characteristics of several types of biomass were studied, using a thermogravimetric analyzer. An electrically heated drop tube furnace was employed to elucidate the effect of the biomass addition on the combustion behavior, NOx emission characteristics and ash formation. The results obtained show that pyrolysis and combustion characteristics of biomass depend on lignin and cellulose compositions in the biomass. The biomass can enhance the ignition of the low-grade coal. However, NO and N_2O emission behaviors under the co-combustion condition resemble those under the coal combustion condition. When the only biomass is burned, fine particulates of less than 2μm are produced. However, the coal ash captures the fine particulates from biomass during co-combustion.

DOI： 10.1299/jsmeenv.2003.13.107

202 乾燥下水汚泥燃焼時における微量金属成分の放出挙動とその制御

瀧川洋平, 姚洪, 成瀬一郎

環境工学総合シンポジウム講演論文集 2003 巻 ( 0 ) 頁： 103 - 106 2003年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Trace metal components in wastes evolve and/or concentrate in fine particulates during the combustion or incineration processes. Some of them may be emitted as a gaseous phase or fine particulates to the atmosphere. When released to the atmosphere, however, those compounds may cause adverse effects to the ecological system. In this study, the optimum sorbent to capture them during combustion is tested in burning dried sewage sludge at temperature ranging from 1073 to 1223 K, using an electrically heated drop tube furnace. Both formation behaviors of particulate mater and capture characteristics of trace elements by the optimum sorbent are discussed under practical combustion conditions. This study also conducts the leaching test of trace metals in the by-product.

DOI： 10.1299/jsmeenv.2003.13.103

1.1 固体の燃焼(1. 燃焼理論,III エネルギー変換技術の進展と研究動向,平成14年における重要なエネルギー関係事項)

成瀬一郎

日本エネルギー学会誌 82 巻 ( 7 ) 頁： 462 - 463 2003年

Integration of a transposon into the Gli3 gene in the Pdn mouse.

Ueta E, Nanba E, Naruse I

Congenital anomalies 42 巻 ( 4 ) 頁： 318 - 22 2002年12月

Comparative Study of Lead and Cadmium Compounds Capture by Sorbents

Yao Hong, Saito Noboru, Mkilaha Iddi S.N., NARUSE Ichiro

Journal of chemical engineering of Japan 35 巻 ( 5 ) 頁： 401 - 408 2002年5月

掲載種別：研究論文（学術雑誌）出版者・発行元：公益社団法人化学工学会

Trace metal compounds, which are emitted from combustion systems such as waste incinerators, coal combustors, and so forth, enrich in fine particulates, usually formed during various stages of combustion. Owing to the difficulties of capturing fine particulates by conventional particulate dust collection systems, these are exhausted in the atmosphere. Fundamentals of the emission and control of trace metal compounds of lead and cadmium were studied at relatively low temperature (1073–1273 K), using a thermobalance. In order to capture these trace metal compounds, seven types of sorbent, namely alumina, silica, kaolin, limestone, scallop, zeolite and apatite, were used. As a result, the natural aluminosilicate materials like kaolin and zeolite were found to be effective in capturing lead and cadmium chemically. Although the presence of HCl decreases capture efficiencies, the products didn’t react with HCl. The types of kaolin had a little influence on the capture efficiency and processes in general. On the other hand, the calcium-based sorbents like limestone, scallop and apatite, could capture both the trace metals and chlorine. On the presence of HCl, the capture efficiencies of these sorbents decreased sharply. Both alumina and silica have low ability to capture trace metal compounds. Moreover, in reducing atmosphere, all sorbents showed low capture abilities since the products were reduced.

DOI： 10.1252/jcej.35.401

Fundamentals on Vaporization Behavior of Trace Metal Compounds at Different Atmospheres and Temperatures

Enhanced anti-tumor effect of trastuzumab in combination with cisplatin.

Naruse I, Fukumoto H, Saijo N, Nishio K

Japanese journal of cancer research : Gann 93 巻 ( 5 ) 頁： 574 - 81 2002年5月

Yao Hong, Minato Hirofumi, Mkilaha Iddi S. N., NARUSE Ichiro

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 81 巻 ( 4 ) 頁： 256 - 262 2002年4月

Feasibility study of the co-generation system with direct internal reforming-molten carbonate fuel cell (DIR-MCFC) for residential use

Sugiura K.

Journal of Power Sources 106 巻 ( 1-2 ) 頁： 51 - 59 2002年4月

貝殻の流動層燃焼炉内脱硫剤への適用

成瀬一郎, 村上高広

火力原子力発電 53 巻 ( 3 ) 頁： 2 - 10 2002年3月

Antitumor activity of the selective epidermal growth factor receptor-tyrosine kinase inhibitor (EGFR-TKI) Iressa (ZD1839) in an EGFR-expressing multidrug-resistant cell line in vitro and in vivo.

Naruse I, Ohmori T, Ao Y, Fukumoto H, Kuroki T, Mori M, Saijo N, Nishio K

International journal of cancer 98 巻 ( 2 ) 頁： 310 - 5 2002年3月

Hydrocephalus manifestation in the genetic polydactyly/ arhinencephaly mouse (Pdn/Pdn).

Naruse I, Ueta E

Congenital anomalies 42 巻 ( 1 ) 頁： 27 - 31 2002年3月

Fundamentals on Vaporization Behavior of Trace Metal Compounds at Different Atmospheres and Temperatures.

YAO Hong, MINATO Hirofumi, MKILAHA Iddi S.N, NARUSE Ichiro

日本エネルギー学会誌 81 巻 ( 4 ) 頁： 256 - 262 2002年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Trace metals are usually inevitably contained in wastes, coals and so forth. When the wastes and/or coals are burnt, pollutants like NOx, SOx, soot, particulates, dioxins and heavy metal compounds are emitted from the furnaces. Some of the heavy trace metal compounds condense on the particle surface and/or form fine particulates during the combustion/incineration processes. Owing to the difficulties in capturing those fine particulates by means of conventional dust collection systems, those particulates tend to be exhausted into the atmosphere. In this study, fundamental behavior of the vaporization of Pb, Cd and Cr compounds was studied at relatively low temperature. In this experiment the effects of temperature and reaction atmosphere on the vaporization behavior of Pb, Cd and Cr compounds were studied using a thermobalance. The chemical thermoequilibrium calculation for each compound was also carried out in order to validate the experimental results obtained. As a result, the vaporization behavior of the metal compounds appears dependent on their respective melting points. Most of chlorides were easily vaporized at relatively low temperatures. This suggests that the presence of HCl enhances the vaporization of metal compounds, while coexistence of SO2 shows inhibition of the vaporization tendencies of Pb and Cd compounds. All of the Cd compounds vaporized in the reducing conditions. The results of chemical thermoequilibrium calculation agreed closely with the experimental results obtained.

DOI： 10.3775/jie.81.256

Interaction between molten coal ash and coke in raceway of blast furnace

Khairil K.

Proceedings of the Combustion Institute 29 巻 ( 1 ) 頁： 805 - 810 2002年

1503 高温空気微粉炭燃焼場における灰の挙動

成瀬一郎, 神柱大助, カイリル

年次大会講演論文集 2002 巻 ( 0 ) 頁： 5 - 6 2002年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Particle size and composition distributions of ash particles in both reacting coal and depositing layer are analyzed, using CCSEM (Computer Controlled Scanning Microscope), to study behaviors of ash particles included in the reacting coal and deposition phenomena. For the behaviors of ash particles in the reacting coal, fraction of the coarse particles gradually increases due to coagulation, so that the composition of the coarse particles also changes during evolution and combustion processes of volatile matter. For structure of the deposit layer, on the other hand, fine particles of size less than 3μm mainly consist of the initial layer for three types of coal, and the thickness was about 30μm. Growth behavior of the deposit at the stagnation depended on the coal type. The deposition phenomena take place due to preference of both particle size and composition.

DOI： 10.1299/jsmemecjo.2002.4.0_5

D145 石炭燃焼場におけるアルカリ金属化合物含有微粒子の生成挙動

多久和毅志, 村上高広, 成瀬一郎

熱工学講演会講演論文集 2002 巻 ( 0 ) 頁： 187 - 188 2002年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本機械学会

Some metal compounds in coal vaporize and form fumes during the combustion. The fumes are usually contained in the exhaust gas. For coal-fired combined power generation systems such as pressurized fluidized bed combustion, hot metallic vapors are introduced in gas turbine. As this phenomenon causes corrosion problem of the turbine blades, it is necessary to control the formation of those fumes, which include alkali metal compounds. In this paper, the evolution behavior of alkali metal compounds, especially for sodium compounds, has been studied, using a drop tube furnace with a low-pressure impactor.

DOI： 10.1299/jsmeptec.2002.0_187

52 石炭燃焼場におけるアルカリ金属化合物を含む微粒子生成特性の炭種依存性

多久和毅志, Mkilaha Iddi S.N., 成瀬一郎

石炭科学会議発表論文集 39 巻 ( 0 ) 頁： 121 - 122 2002年

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本エネルギー学会

Some metal compounds in coal vaporize and form fumes during the combustion. The fumes are usually contained in the exhaust gas. For coal-fired combined power generation systems such as pressurized fluidized bed combustion, hot metallic vapors are introduced in a gas turbine. As this phenomenon causes corrosion problem of the turbine blades, it is necessary to control the formation of those fumes, which include alkali metal compounds. In this paper, the evolution behavior of alkali metal compounds, especially for sodium compounds, has been studied, using a drop tube furnace with a low-pressure impactor. As a result, concentration profile of sodium in the fine particles has dependence on coal type. On the other hand, the condensation mechanism of sodium seems to be similar in each coal.

DOI： 10.20550/jiesekitanronbun.39.0_121

Modeling on combustion characteristics of biocoalbriquettes

Kim H.

Journal of Energy Resources Technology, Transactions of the ASME 123 巻 ( 1 ) 頁： 27 - 31 2001年12月

地域物質循環型社会構築のためのデータベースとその利用法

堀田雅也, 後藤知行, 船津公人, 成瀬一郎

廃棄物学会研究発表会講演論文集 = Proceedings of the Annual Conference of the Japan Society of Waste Management Experts 12 巻 ( 1 ) 頁： 202 - 204 2001年10月

固体燃焼I固体燃焼総論

成瀬一郎

燃焼研究 124 巻頁： 35 - 46 2001年4月

石炭の燃焼技術

成瀬一郎

日本エネルギー学会誌 = Journal of the Japan Institute of Energy 80 巻 ( 4 ) 頁： 216 - 228 2001年4月

燃焼プロセスにおける微粒子生成制御

成瀬一郎

火力原子力発電 52 巻 ( 4 ) 頁： 1 - 9 2001年4月

Effect of Molten Coal Ash on Coke Degradasion in High Temperature Pulverized Coal Reaction

KHAIRIL, KAMIHASHIRA Daisuke, NARUSE Ichiro

材料とプロセス : 日本鉄鋼協会講演論文集 = Current advances in materials and processes : report of the ISIJ meeting 14 巻 ( 1 ) 2001年3月

Fundamental Reaction Characteristics of Pulverized Coal at High Temperature

KAMIHASHIRA Khairil Daisuke, NAKAYAMA Katsuya, NARUSE Ichiro, Naruse Ichiro

ISIJ international 41 巻 ( 2 ) 頁： 136 - 141 2001年2月

掲載種別：研究論文（学術雑誌）出版者・発行元：一般社団法人日本鉄鋼協会

In order to enhance the overall thermal efficiency in blast furnace system as well as coal gasifiers, it is necessary to elucidate fundamental reaction characteristics of pulverized coal at high temperature. The experiments were carried out using a horizontal pulverized coal reactor with a pre-combustor to produce vitiated air at high temperature and high-oxygen concentration. The reaction behavior of coal during combustion and/or gasification are elucidated by means of sampling and analyzing both reacting particles and reaction gases as well as optical measurement of the instantaneous particle temperature. Evolution rate of the volatile matter for various types of coal at high temperature is obtained from the Arrhenius plots. As a result, the volatile matter is rapidly evolved as soon as coal particles are introduced into the furnace since temperature of the vitiated air increases sufficiently. Result shows that the evolution rate of volatile matter does not depend on coal types. Activation energy and frequency factor of the evolution rate of volatile matter for various types of coal remain almost constant in the particle temperature range of 2 200 to 2 700 K, even when other experimental conditions were varied. In the char combustion region, char structure was found to affect the reaction rate of fixed carbon. It is observed that coal, which forms a network-type of char, indicated reaction rate of fixed carbon which did not always increase even when the vitiated air temperature was high enough. For a balloon-type char, on the other hand, the reaction rate of fixed carbon decreased with an increase of the vitiated air temperature.

DOI： 10.2355/isijinternational.41.136